Section 10 − Parts List; Recommended Spare Parts - Miller Blue Star 185 Owner's Manual

Trouble
Erratic output at generator power ac
receptacles.
C. Engine
Trouble
Engine will not crank.
Engine will not start or runs poorly.
Engine stopped during normal
operation.
Battery discharges between uses.
Unstable or sluggish engine speeds.

10-1. Recommended Spare Parts

Part No.
. . . . . . . . . . . . . . . . . . . 268469
. . . . . . . . . . . . . . . . . . . 268467
. . . . . . . . . . . . . . . . . . . 268468
. . . . . . . . . . . . . . . . . . . 246110
. . . . . . . . . . F1 . . . . . 021718
Check fuel level.
Have Factory Authorized Service Agent check connections at terminal block 1T.
Check receptacle supplementary protector, wiring, and connections.
Check throttle linkage for smooth, non-binding operation.
Service air cleaner according to engine manual. Service engine fuel filter (see Section 8-4).
Check engine speed, and adjust if necessary (see Section 8-6).
Check and replace ignition fuse F1.
Check battery voltage.
Check battery connections and tighten if necessary.
Have Factory Authorized Service Agent check engine ignition circuit.
Check fuel level (see Section 5-5). Check and replace fuel filter if necessary (see Section 8-4).
Move choke control to correct position (see Section 6-1).
Open fuel valve (see Section 5-5). Close fuel valve before moving unit or carburetor may flood and make
starting difficult.
Check battery voltage.
Check battery connections and tighten if necessary.
Check spark plug. Clean and re-gap or replace if necessary.
Check oil level (see Section 5-5). Engine stops if oil level is too low. Refill crankcase with proper viscosity
oil for operating temperature.
Have Factory Authorized Service Agent check low oil level shutdown switch.
Check fuel level (see Section 5-5).
Open fuel valve (see Section 5-5). Close fuel valve before moving unit or carburetor may flood and make
starting difficult.
Check oil level (see Section 5-5). Engine stops if oil level is too low.
Clean battery, terminals, and posts with baking soda and water solution; rinse with clear water.
Periodically recharge battery (approximately every 3 months). Replace battery if necessary.
Check engine battery charging circuit and connections according to engine manual.
Check engine speed, and adjust if necessary (see Section 8-6). Check throttle/governor linkage for
smooth, non-binding operation.
Check and replace fuel filter if necessary (see Section 8-4).
Tune-up engine according to engine manual.
SECTION 10 − PARTS LIST
Description
. . Tune−Up & Filter Kit, Kohler (Ch440)
. . Spark Plug, Kohler (Ch440)
. . Filter, Air (Kohler Ch440)
. . Filter, Fuel In−Line .250 Kohler 75um
. . Fuse, Mintr GL 30. Amp 32 Volt
.
Complete Parts List available at www.MillerWelds.com
Remedy
Remedy
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Quantity
1
1
1
1
1
OM-267 212 Page 33