Any current measured must not exceed 0.5mA. Reverse the instrument power cord plug in the outlet and repeat the test. See Fig. 1-1. Fig. 1-2 Insulation Resistance Test Samsung electronics...
Page 4
(5) antenna wiring. Always inspect in all areas whenever appropriate. for pinched, out-of-place, or frayed wiring, Do not change spacing between a component and the printed-circuit board. Check the AC power cord for damage. Samsung Electronics...
When replacing components, use components which have the same ratings. Components identified by shading, by( ) or by ( ) in the circuit diagram are important for safety or for the characteristics of the unit. Always replace them with the exact replacement components. Samsung Electronics...
(7) Immediately before removing the protective materials from the leads of a replacement ESD device, touch the protective material to the chassis or circuit assembly into which the device will be installed. Samsung Electronics...
Be sure to put on a wrist strap grounded to the sheet. u Be sure to lay a conductive sheet made of copper etc. Which is grounded to the table. Samsung Electronics...
1080 at 40 Mbit/sec) - Large capacity means no compromise on video quality. Furthermore, a Blu-ray Disc has the same familiar size and look as DVD. 2-1-3 HD DVD Features The HD DVD video disc is a high-density, mass-storage medium. The HD DVD disc standard has been approved by the DVD forum. The HD DVD (dual-layer) can store up to 30 GB of data, and the single layer HD DVD can do so up to 15 GB. On one side of a single layer DVD, you can store up to 8 hours of high resolution video source in 1125 scanning lines, and up to 48 hours of standard resolution source in 525 scanning lines. (The fi gures can differ, depending on the bit rate of the recorded source) * The following BD/HD DVD Disc features are disc dependant and will vary. Appearance and navigation of features will also vary from disc to disc. Not all discs will have the features described below. q Video highlights The BD-ROM/ HD DVD-ROM format for movie distribution supports three highly advanced video codecs, including AVC, VC-1, and MPEG-2. HD video resolutions are also available: - 1920 x 1080 HD - 1280 x 720 HD q For High-Defi nition Playback To view high-defi nition contents in BD/HD DVD Disc, an HDTV (High Defi nition Television) is required. Some BD discs may require using the player's HDMI OUT to view high-defi nition content. The ability to view highdefi nition content on BD discs may be limited depending on the resolution of your TV. q Graphic planes Two individual, full HD resolution (1920x1080) video layers are available, on top of the HD video layer. One layer is assigned to video-related graphics (like subtitles), and the other layer is assigned to interactive elements, such as buttons or menus. Various wipes, fades and scroll effects may be available on both layers. q Menu graphics Support full color resolution graphics and animation, thereby greatly surpassing the capabilities of DVD-Video. (Blu-ray disc only) Unlike DVD, Menus can be accessed during video playback. q Menu sounds Samsung Electronics...
Once a DVD-R recorded in Video Mode is fi nalized, it becomes DVD-Video. DVD-R(V mode This unit can play back DVD-R discs recorded and fi nalized with a Samsung DVD video recorder. It may not be able and fi nalized only) to play some DVD-R discs depending on the disc and the condition of the recording.
South East Asia. Europe, Greenland, French territories, Middle East, Africa, Australia and New Zealand. India, China, Russia, Central and South Asia. 2-1-7 Blu-ray Disc Compatibility Blu-ray Disc is a new and evolving format. Accordingly, disc compatibility issues are possible. Not all discs are compatible and not every disc will play back. For additional information, refer to the Compliance and Compatibility Notice section of this Manual. If you encounter compatibility problems, please contact the SAMSUNG customer care center. This Samsung Blu-ray disc player (BD-UP5000) supports only the BDROM Profi le 1 version 1.0 specifi cation. If you want to play later version discs, you may need to update player's fi rmware. Please refer to http://www.samsung.com or contact SAMSUNG customer care center at 1-800 SAMSUNG. 2-1-8 HD DVD Disc Compatibility HD DVD is a new format, disc compatibility issues with new and existing format discs are possible. Not all discs are compatible. If you experience compatibility problems, please contact SAMSUNG Customer Service.
Product Specification 2-2 Chassis Product Specification General Features BD-P200/XAA BD-P400/XAA BD-UP5000/XAA Chassis CVBS Output S-Video Output YPbPr Output Input / HDMI Ouput Digital Audio Output(Optical/Coaxial) AOnalog Audio Output (2ch/5.ch) /(7.ch) HDMI CEC A/V Decoder BCM7438 SMP8634 BCM7440 Audio/Video Video DAC...
Page 15
Product Specification General Features BD-P200/XAA BD-P400/XAA BD-UP5000/XAA Chassis Front Display Screen capture Miscellane- Closed Caption pass through from disc Main Menu (including Setup Menu) Samsung Electronics...
Product Specification 2-3 Option Product Specification Description Fig Description Parts No Remark Model Standard of Remote Control AK59-00075A BD-UP5000/XAA Model Standard of Batteries for Remote Control 430-00035 BD-UP5000/XAA S.N.A Model Standard of Instruction Manual AK68-0477A BD-UP5000/XAA Model Standard of Quick Guide...
CAUTION : Connector Must be remove with care 3-1-1 Top Cabinet Removal 1) Remove 5 Screws 2) Lift up the Top Cabinet in direction of arrow. 3 SCREWS (3X0 B) TOP CABINET 2 SCREWS (3X8 B) Fig. 3- Top Cabinet Removal Samsung Electronics...
Page 19
Disassembly and Reassembly 3-1-3 Ass’y Deck Removal 1) Remove 4 Screws from the Ass’y Deck and lift it up. 4 SCREWS (3X0 W) ASS’Y DECK Fig. 3-3 Ass’y Deck Removal Samsung Electronics...
Page 20
Disassembly and Reassembly 3-1-4 S.M.P.S PCB Removal 1) Remove 4 Screws , from the S.M.P.S PCB and lift it up. 4 SCREWS (3X8 W) S.M.P.S PCB Fig. 3-4 S.M.P.S PCB Removal Samsung Electronics...
Page 21
Disassembly and Reassembly 3-1-5 Main PCB Removal 1) Remove 10 Screws from the Main PCB and lift it up. 4 SCREWS (3X6 W) MAIN PCB SCREW (3X6 B) SCREWS (3X0 B) Fig. 3- Main PCB Removal Samsung Electronics...
Page 22
Disassembly and Reassembly 3-1-6 FAN Removal 1) Remove 2 Screws from the Fan and lift it up. 2 SCREWS (X4 S) Fig. 3-6 FAN Removal Samsung Electronics...
Refer to a pattern Refer to a pattern image of Table 4-1 image of Table 4-1 Switching operation Change ICS of ICS is normal? Refer to a pattern image of Table 4-1 Change the SMPS PCB Samsung Electronics...
Page 27
Refer to a pattern image of S.M.P.S PCB page 6-7 This must be between 150V and 160V VCC of IC1S11 must be under 26V This must be a short Refer to a pattern image of S.M.P.S Page 7-5 Fig. 4- Samsung Electronics...
Page 28
Replace the Main PCB (Pin ) Refer to a pattern image of Table 4-2 Check Check AIC soldering or Digital Audio Data replace AIC at AIC (Pin ,4,6) Refer to a pattern image of Table 4-2 Digital Audio cable error Samsung Electronics...
Page 29
Trouble Shooting DIGITAL AUDIO DATA AIC (Pin,4,6,) Refer to a pattern image of Main PCB page 6-6 Refer to a pattern image of Audio (Main PCB) Page 7-6 Fig. 4- Samsung Electronics...
Page 30
AIC Check Check AIC soldering or replace the Audio AIC signal at pin,,7~48 of AIC Check Check AIC4~7 soldering of the Audio peripheral devices signal at AIC4,,6,7 Refer to a pattern image of Table 4-3 Audio cable error Samsung Electronics...
Page 31
Trouble Shooting ANALOG AUDIO DATA(AIC,4,,6,7) Refer to a pattern image of Main PCB page 6-4 Refer to a pattern image of Audio (Main PCB) Page 7-6 Fig. 4- Samsung Electronics...
Page 32
Check the Audio signal AIC8 at Pin0~ of AIC8 Refer to a pattern image of Table 4-4 Check AIC soldering of peripheral Check the Audio signal devices at AIC Refer to a pattern image of Table 4-4 Audio cable error Samsung Electronics...
Page 33
Trouble Shooting ANALOG AUDIO DATA AIC, AIC8 (Pin6, Pin0~) Refer to a pattern image of Main PCB page 6-4 Refer to a pattern image of Audio (Main PCB) Page 7-6 Fig. 4-4 Samsung Electronics...
Page 34
40pin FFC cable(between main & Reinsert FFC cable correctly deck) inserted correctly? the wave- from of J7 Pin normal? Change the Main board (MAIN PCB) Refer to a pattern image of Table 4-5 Change the deck 4-0 Samsung Electronics...
Page 35
Trouble Shooting J7 Pin Refer to a pattern image of Main PCB page 6-4 Refer to a pattern image of ATAPI/LAN Interface (Main PCB)- Page 7-12 Fig. 4- Samsung Electronics 4-...
Page 36
FFC cable (between Re-insert FFC cable correctly Front panel&Main) Check FU or change FU PIN the Front panel PCB SIGNAL OK? Refer to a pattern image of Table 4-6 Check the Power of FMIC(Pin) or change the Main PCB 4- Samsung Electronics...
Page 37
Trouble Shooting Remote control eye data FU Pin Refer to a pattern image of Front PCB page 6-9 Refer to a pattern image of Front (Front PCB) Page 7-24 Fig. 4-6 Samsung Electronics 4-...
Page 38
Trouble Shooting No Picture Logo screen is OK ? HDMI? NO LOGO(HDMI) BD/DVD Playback is Component? NO LOGO(Component) NO LOGO CHANGE THE MAIN PCB (CVBS/S-Video) 4-4 Samsung Electronics...
Page 39
U soldering error U(VC6,VC,VC4) Refer to a pattern image of Table 4-7 Video Check VIC soldering of output from VIC peripheral devices (VR,VR,VR4) Refer to a pattern image of Table 4-8 Component cable error Samsung Electronics 4-...
Page 40
Trouble Shooting Y(Color-bar) Pin-VC6 Pb(Color-bar) Pin-VC Refer to a pattern image of Main PCB page 6-6 Pr(Color-bar) Pin-VC4 Refer to a pattern image of Video (Main PCB) Page 7-7 Fig. 4-7 4-6 Samsung Electronics...
Page 41
Trouble Shooting Y(Color-bar) Pin-VR Pb(Color-bar) Pin-VR Refer to a pattern image of Main PCB page 6-4 Pr(Color-bar) Pin-VR4 Refer to a pattern image of Video (Main PCB) Page 7-7 Fig. 4-8 Samsung Electronics 4-7...
Page 42
U soldering error U(VC,VC,VC) Refer to a pattern image of Table 4-9 Video Check VIC soldering of output from VIC peripheral devices (VR,VR6,VR7) Refer to a pattern image of Table 4-9 Component cable error 4-8 Samsung Electronics...
Page 43
Trouble Shooting Y(Color-bar) Pin (U-VC,VIC-VR) C(Color-bar) Pin (U-VC,VIC-VR6) Refer to a pattern image of Main PCB page 6-6 CVBS(Color-bar) Pin (U-VC,VIC-VR7) Refer to a pattern image of Video (Main PCB) Page 7-7 Fig. 4- Samsung Electronics 4-...
Page 44
Check HCN Connector and HIC is High? HDMI cable connection (.0~.0V) data Check the HIC power input output from HIC? and peripheral devices (pin0,,,4,6,7, ,40) Refer to a pattern image of Table 4-12 HDMI cable error 4-0 Samsung Electronics...
Page 45
Trouble Shooting ANALOG VIDEO DATA UX (XR, XRN~XRN0) Refer to a pattern image of Main PCB page 6-4 Refer to a pattern image of Reon (Main PCB) Page 7-20 Fig. 4-0 Samsung Electronics 4-...
Page 46
Refer to a pattern Refer to a pattern image of Main PCB page 6-4 image of Main PCB page 6-6 ANALOG VIDEO DATA IC8(RN~RN), IC(RN4~RN7) Refer to a pattern image of Video (Main PCB) Page 7-7 Fig. 4- 4- Samsung Electronics...
Page 47
Trouble Shooting HDMI OUTPUT DATA HIC (pin0,,,4,6,7,,40) Refer to a pattern image of Main PCB page 6-4 Refer to a pattern image of HDMI (Main PCB) Page 7-17 Fig. 4- Samsung Electronics 4-...
4) When finished , power goes off automatically. Fig. 4- 2) Tray opened automatically, then Press YES if the up date CD you insert is a later one than before. Fig. 4-4 3) Wait about 7 minutes. Fig. 4- 4-4 Samsung Electronics...
Page 49
2) Tray opened automatically, then Press YES if the up date CD you insert is a later one than before. Fig. 4-6 3) Wait about 1~2 minutes. Fig. 4-7 Fig. 4-8 4) When finished , power goes off automatically. Samsung Electronics 4-...
There is no need to update." q If there is a disc in the player : "Please maintain "No Disc" state for network update." This indicates that you must remove all discs from the unit to perform the update. 4-6 Samsung Electronics...
Page 51
You will see a message about the upgrade process for 3seconds. - When update is fi nished, the power will turn off. q If you do not want to update fi rmware, select No and then press the ENTER button. Fig. 4-6 Samsung Electronics 4-7...
Page 52
Trouble Shooting M E M O 4-8 Samsung Electronics...
5. Exploded View and Parts List 5-1 Cabinet Assembly ------------------------------------------------------------------------------- 5-2 5-2 Electrical Parts List ---------------------------------------------------------------------------- 5-4 삼성전자...
Exploded Views and Parts List 5-1 Cabinet Assembly W001 W348 W348 P003 C015 H003 W009 W289 P001 W271 P030 W344 P025 W001 A001 W009 C001 P007P P007F C002 C011 This Document can not be used without Samsung's authorization Samsung Electronics...
Page 55
ASSY PCB-POWER KEY;BD-P1400,ASSY PC P025 AC39-10200N CBF-POWER CORD;AT,US,EP2/Y,HOUSING( P030 3103-001158 FAN-DC;12V,20mA,2000rpm,0.125m^3/mi W001 6003-000275 SCREW-TAPTITE;BH,+,-,B,M3,L10,ZPC(B W009 6003-000276 SCREW-TAPTITE;BH,+,-,B,M3,L10,ZPC(W W271 6009-001411 SCREW-SPECIAL;TH,+,-,M5,L 14,NI PLT, W289 6003-001264 SCREW-TAPTITE;CH,HEX,-,S,M3,L10,NI W344 6003-001076 SCREW-TAPTITE;BH,+,-,S,M3,L6,ZPC(BL W348 6003-000255 SCREW-TAPTITE;BWH,+,-,B,M3,L8,ZPC(W Samsung Electronics This Document can not be used without Samsung's authorization...
TR-DIGITAL;-,NPN,00MW,K/K,SOT- AD 0407-0004 DIODE-ARRAY;-,80V,00mA,CA-,SOT- 0504-00056 TR-DIGITAL;KSR0,PNP,00MW,K/ AD 0407-0004 DIODE-ARRAY;-,80V,00mA,CA-,SOT- 0504-00056 TR-DIGITAL;KSR0,PNP,00MW,K/ AD4 0407-0004 DIODE-ARRAY;-,80V,00mA,CA-,SOT- 0504-0008 TR-DIGITAL;-,NPN,00MW,K/K,SOT- AD5 0407-0004 DIODE-ARRAY;-,80V,00mA,CA-,SOT- AD6 0407-0004 DIODE-ARRAY;-,80V,00mA,CA-,SOT- 0504-0008 TR-DIGITAL;-,NPN,00MW,K/K,SOT- 0504-00056 TR-DIGITAL;KSR0,PNP,00MW,K/ AD7 0407-0004 DIODE-ARRAY;-,80V,00mA,CA-,SOT- This Document can not be used without Samsung's authorization Samsung Electronics...
Page 57
007-000450 R-CHIP;80ohm,5%,/0W,TP,608 AR80 007-000078 R-CHIP;Kohm,5%,/0W,TP,608 AR4 007-000450 R-CHIP;80ohm,5%,/0W,TP,608 AR8 007-000078 R-CHIP;Kohm,5%,/0W,TP,608 AR5 007-000450 R-CHIP;80ohm,5%,/0W,TP,608 AR8 007-000078 R-CHIP;Kohm,5%,/0W,TP,608 AR6 007-000450 R-CHIP;80ohm,5%,/0W,TP,608 AR8 007-000078 R-CHIP;Kohm,5%,/0W,TP,608 AR84 007-000078 R-CHIP;Kohm,5%,/0W,TP,608 AR7 007-000450 R-CHIP;80ohm,5%,/0W,TP,608 Samsung Electronics This Document can not be used without Samsung's authorization...
Page 58
C-CER,CHIP;00nF,0%,6V,X7R,TP,60 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 C84 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 C85 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 0-00084 C-CER,CHIP;0.05nF,5%,50V,C0G,608 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 This Document can not be used without Samsung's authorization Samsung Electronics...
Page 59
HIC 05-00 IC-TRANSMITTER;SII94CTU,TQFP,00P CER 007-000084 R-CHIP;4.7Kohm,5%,/0W,TP,608 HIC 0505-00679 FET-SILICON;FDC60N,N,5V,0.A,5O CEXT 80-00094 RESONATOR-CERAMIC;4MHz,0.5%,TP,8xx 007-0000 R-CHIP;0ohm,5%,/4W,TP,6 0-0005 BEAD-SMD;0ohm,x.5x0.9mm,-,TP,- CON 7-00549 JACK-MODULAR;P/8C,-,N,ANGLE,N,AU, D506 040-000 DIODE-SWITCHING;RLS448,75V,50mA,L 007-0000 R-CHIP;0ohm,5%,/4W,TP,6 D507 040-00075 DIODE-RECTIFIER;MBR050L,0V,0.5A,S 007-0000 R-CHIP;0ohm,5%,/4W,TP,6 Samsung Electronics This Document can not be used without Samsung's authorization...
Page 60
JR 007-000 R-CHIP;ohm,5%,/0W,TP,608 007-000 R-CHIP;ohm,5%,/0W,TP,608 MC50 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 007-000070 R-CHIP;0ohm,5%,/0W,TP,608 MC5 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 0-000 BEAD-SMD;0ohm,45,TP,67ohm/60M MC5 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 0-0005 BEAD-SMD;0ohm,x.5x0.9mm,-,TP,- MC5 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 MC54 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 L80 0-000 BEAD-SMD;0ohm,45,TP,67ohm/60M This Document can not be used without Samsung's authorization Samsung Electronics...
Page 61
PIC8 0-00486 IC-DC/DC CONVERTER;MP08,QFN,0P, PC6 0-00057 C-CER,CHIP;0nF,0%,50V,X7R,TP,608 PC7 0-00668 C-CER,CHIP;4700NF,0%,5V,X7R,TP, PIC9 0-004868 IC-SWITCH VOL. REG.;MP6,SOIC,8P, PC8 0-00688 C-CER,CHIP;47000nF,0%,6.V,X5R, 70-0048 INDUCTOR-SMD;8.uH,0%,77 PC9 0-00688 C-CER,CHIP;47000nF,0%,6.V,X5R, 70-0048 INDUCTOR-SMD;8.uH,0%,77 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 70-0047 INDUCTOR-SMD;4.7uH,0%,9998 Samsung Electronics This Document can not be used without Samsung's authorization...
Page 62
007-00007 R-CHIP;ohm,5%,/0W,TP,608 R94 007-0064 R-CHIP;75ohm,%,/0W,TP,608 007-000078 R-CHIP;Kohm,5%,/0W,TP,608 R94 007-0064 R-CHIP;75ohm,%,/0W,TP,608 R94 007-0064 R-CHIP;75ohm,%,/0W,TP,608 R0 007-00007 R-CHIP;ohm,5%,/0W,TP,608 R 007-00007 R-CHIP;ohm,5%,/0W,TP,608 R944 007-0064 R-CHIP;75ohm,%,/0W,TP,608 R 007-00007 R-CHIP;ohm,5%,/0W,TP,608 R945 007-0064 R-CHIP;75ohm,%,/0W,TP,608 5-0 This Document can not be used without Samsung's authorization Samsung Electronics...
Page 63
R-CHIP;.5Kohm,5%,/0W,TP,608 R6 007-000084 R-CHIP;4.7Kohm,5%,/0W,TP,608 R7 007-000 R-CHIP;.5Kohm,5%,/0W,TP,608 R6 007-000070 R-CHIP;0ohm,5%,/0W,TP,608 R8 007-000 R-CHIP;ohm,5%,/0W,TP,608 R64 007-000070 R-CHIP;0ohm,5%,/0W,TP,608 R7 007-000086 R-CHIP;5.6Kohm,5%,/0W,TP,608 R66 007-000 R-CHIP;.5Kohm,5%,/0W,TP,608 R69 007-000070 R-CHIP;0ohm,5%,/0W,TP,608 R8 007-00007 R-CHIP;ohm,5%,/0W,TP,608 Samsung Electronics This Document can not be used without Samsung's authorization 5-...
Page 64
VC 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 VC4 0-0066 C-CER,CHIP;0000nF,0%,0V,X5R,0 007-000070 R-CHIP;0ohm,5%,/0W,TP,608 007-000 R-CHIP;.5Kohm,5%,/0W,TP,608 VC5 0-0066 C-CER,CHIP;0000nF,0%,0V,X5R,0 007-000070 R-CHIP;0ohm,5%,/0W,TP,608 VC6 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 007-000070 R-CHIP;0ohm,5%,/0W,TP,608 VC7 40-00086 C-AL,SMD;00UF,0%,6V,WT,TP,6.6X6. 007-000 R-CHIP;.5Kohm,5%,/0W,TP,608 VC8 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 5- This Document can not be used without Samsung's authorization Samsung Electronics...
Page 65
C-CER,CHIP;00nF,0%,6V,X7R,TP,60 XC 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 VXC9 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 XC 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 XC 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 VXC9 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 VXC95 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 XC4 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 VXC96 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 XC5 404-0000 C-TA,CHIP;0uF,0%,0V,GP,TP,6 Samsung Electronics This Document can not be used without Samsung's authorization 5-...
Page 66
C-CER,CHIP;00nF,0%,6V,X7R,TP,60 XR6 007-000075 R-CHIP;0ohm,5%,/0W,TP,608 XC7 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 XR7 007-00005 R-CHIP;0Kohm,%,/0W,TP,608 XC7 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 XR8 007-0064 R-CHIP;75ohm,%,/0W,TP,608 XC7 0-00548 C-CER,CHIP;00nF,0%,6V,X7R,TP,60 XR9 007-00005 R-CHIP;0Kohm,%,/0W,TP,608 XR 007-000070 R-CHIP;0ohm,5%,/0W,TP,608 XC74 404-0000 C-TA,CHIP;0uF,0%,0V,GP,TP,6 5-4 This Document can not be used without Samsung's authorization Samsung Electronics...
Page 67
P003 AK92-01493A ASSY PCB-SMPS;BD-UP5000/XAA,ASSY PC XRN9 0-006 R-NETWORK;ohm,5%,/6W,L,CHIP,8P, 040-00608 DIODE-BRIDGE;GBJJ,600V,A,SIP-4,BK XRN0 0-006 R-NETWORK;ohm,5%,/6W,L,CHIP,8P, CS0 40-004 C-AL;470uF,0%,00V,GP,BK,x5,0m XRN7 0-006 R-NETWORK;ohm,5%,/6W,L,CHIP,8P, CS0 0-00044 C-CERAMIC,DISC;0.NF,0%,400V,Y5P,T XRN8 0-006 R-NETWORK;ohm,5%,/6W,L,CHIP,8P, CS0 0-00044 C-CERAMIC,DISC;0.NF,0%,400V,Y5P,T XRN9 0-006 R-NETWORK;ohm,5%,/6W,L,CHIP,8P, Samsung Electronics This Document can not be used without Samsung's authorization 5-5...
Page 68
DIODE-ZENER;MTZJ8C,7.4-8.V,50 ZDS6 040-000509 DIODE-ZENER;MTZJ5.6B,5.4-5.7V,500mW AC7-900M COIL-INDUCTOR;RH.5X6.5RS,BEAD(RADI LS0 AK9-0000A FILTER EMI;RECORDER,SQ,0.4Ohm ZDS5 040-00075 DIODE-ZENER;MTZJ7D,6.-7.6V,500m LS0 AK9-0000A FILTER EMI;RECORDER,SQ,0.4Ohm ZDS85 040-00075 DIODE-ZENER;MTZJ7D,6.-7.6V,500m LS AH7-0009A COIL CHOKE;DR CHOKE(8*6),DVD-R000, ZDS86 040-00075 DIODE-ZENER;MTZJ7D,6.-7.6V,500m 5-6 This Document can not be used without Samsung's authorization Samsung Electronics...
Page 69
AC6 0-0006 C-CER,CHIP;0.nF,5%,50V,C0G,608 P007P AK92-01507A ASSY PCB-POWER KEY;BD-P1400,ASSY PC AC6 0-0006 C-CER,CHIP;0.nF,5%,50V,C0G,608 SCON 7-000988 HEADER-BOARD TO CABLE;BOX,5P,R,MM AC68 0-00549 C-CER,CHIP;00nF,0%,50V,X7R,608 SKEY 404-00065 SWITCH-TACT;V,50mA,60gf,6x6mm,SP SLED 060-0040 LED;ROUND,BLUE,.0mm,470nm,.0x5.5 40-0004 C-AL,SMD;00uF,0%,6V,GP,TP,6.6x6. SLED 060-00874 LED;ROUND,RED,,66nm,- Samsung Electronics This Document can not be used without Samsung's authorization 5-7...
Page 70
C-TA,CHIP;0uF,0%,6V,-,TP,58 DC0 404-00084 C-TA,CHIP;0uF,0%,6V,-,TP,58 DC0 0-00549 C-CER,CHIP;00nF,0%,50V,X7R,608 DC0 404-00084 C-TA,CHIP;0uF,0%,6V,-,TP,58 DC 0-00549 C-CER,CHIP;00nF,0%,50V,X7R,608 DC04 0-00549 C-CER,CHIP;00nF,0%,50V,X7R,608 DC 0-00549 C-CER,CHIP;00nF,0%,50V,X7R,608 DC05 0-00549 C-CER,CHIP;00nF,0%,50V,X7R,608 DC4 0-00549 C-CER,CHIP;00nF,0%,50V,X7R,608 DC5 0-00549 C-CER,CHIP;00nF,0%,50V,X7R,608 5-8 This Document can not be used without Samsung's authorization Samsung Electronics...
Page 71
C-CER,CHIP;00nF,0%,50V,X7R,608 DR5 007-000084 R-CHIP;4.7Kohm,5%,/0W,TP,608 DR6 007-000084 R-CHIP;4.7Kohm,5%,/0W,TP,608 DC80 0-00549 C-CER,CHIP;00nF,0%,50V,X7R,608 DC8 0-00549 C-CER,CHIP;00nF,0%,50V,X7R,608 DR7 007-000 R-CHIP;.Kohm,5%,/0W,TP,608 DC8 0-00549 C-CER,CHIP;00nF,0%,50V,X7R,608 DR8 007-00007 R-CHIP;47ohm,5%,/0W,TP,608 DC84 0-00549 C-CER,CHIP;00nF,0%,50V,X7R,608 DR9 007-00009 R-CHIP;Mohm,5%,/0W,TP,608 Samsung Electronics This Document can not be used without Samsung's authorization 5-9...
Page 72
AK-0000A MOTOR-LOADING;RF-00EH-D90,DP-9, DR8 007-000084 R-CHIP;4.7Kohm,5%,/0W,TP,608 S.N.A. AK66-0008A PULLEY MOTOR;DP-R,POM,-,BLK,.95,7 DR84 007-000084 R-CHIP;4.7Kohm,5%,/0W,TP,608 S.N.A. AK-0000A MOTOR-LOADING;RF-00EH-D90,DP-9, S.N.A. 409-008 SWITCH-DETECTOR;5V DC,A,DPST,0GF, DR85 007-000084 R-CHIP;4.7Kohm,5%,/0W,TP,608 DR86 007-000084 R-CHIP;4.7Kohm,5%,/0W,TP,608 S.N.A. AK4-009A PCB-MOTOR;DP-R,PHENOL,,00,T.6,5 5-0 This Document can not be used without Samsung's authorization Samsung Electronics...
Page 73
PCB-HOLDER-WIRE;SOH-BP,EPOXY,,00, SR4 007-0004 R-CHIP;.Kohm,5%,/0W,TP,608 AK6-005A BASE-YOKE;SOH-BP,SPCC,T.,W8.5,L SR5 007-000084 R-CHIP;4.7Kohm,5%,/0W,TP,608 AK67-00064A LENS-OL BD;SOH-BP,GLASS,NTR,PI4.4, SR0 007-00050 R-CHIP;.ohm,5%,/8W,TP,0 AK67-0007A LENS-PHOE;SOH-UP5000,GLS,NTR,.5*. SR 007-00050 R-CHIP;.ohm,5%,/8W,TP,0 AK67-00078A LENS-B GT;SOH-UP5000,GLS,NTR,.5*. SR40 007-00009 R-CHIP;0ohm,5%,/8W,TP,0 AK97-000A ASSY-BLADE;BLADE,COIL,PCB,SOH-UB,- Samsung Electronics This Document can not be used without Samsung's authorization 5-...
Page 74
00-0055 ADHESIVE-UV;8840L,YEL,TRANS,000,D 0.0 00-00709 ADHESIVE-UV;889L,YEL,4500mPa.s,- 0.0 00-00499 SOLDER-WIRE FLUX;SR4 SUPER LFM-48, 0.05 005-006 GREASE;FLOIL KG-5,WHT,KG 0.0 0604-000 PHOTO-INTERRUPTER;TR,-,00mW,-,- AK-0000A MOTOR STEP-CLD;-,SOH-BP,-,-,-,.5- AK4-0079A FPC-CLD;SOH-UB,-,POLYMIDE,8,0., AK6-0054A BASE-CLD;SOH-BP,ZN,T4.6,W4.,L5. AK6-00545A SPRING ETC-CLD;SOH-BP,STS04-WBP,0 5- This Document can not be used without Samsung's authorization Samsung Electronics...
Page 78
PCB Diagrams Y(Color-bar) J7 Pin 5 Pin-VR Pr(Color-bar) Pb(Color-bar) Pin-VR4 Pin-VR HDMI OUTPUT DATA ANALOG AUDIO HIC (pin0,,,4,6,7,9,40) DATA(AIC,4,5,6,7) ANALOG AUDIO DATA ANALOG VIDEO DATA AIC, AIC8 (Pin6, Pin0~) UX (XR99, XRN~XRN0), IC58(RN~RN) Samsung Electronics...
7-17 Reon (Main PCB) --------------------------------------------------------------------------------------7-20 7-18 Reon DDR I/F (Main PCB) ------------------------------------------------------------------------7-21 7-19 Reon DDR (Main PCB) ------------------------------------------------------------------------------7-22 Samsung Electronics This Document can not be used without Samsung’s authorization This Document can not be used without Samsung’s authorization Samsung Electronics...
(c) IC1S01 Vcc circuit 1) ICIS01, RIS05, RIS07,RIS08 : ICIS01 driving resistance (ICIS01 works through driving resistance at power cord in) 2) ICIS01 Vcc : RIS05, RIS07, RIS08 q Use the output of transformer as Vcc,because the current starts to flow into transformer while ICIS01 is active w Rectify to DIS07 and smooth to CIS09. e Use the output of transformer as ICIS01 Vcc : The loads are different before and after ICIS01 driving. (Vcc of ICIS01 decreases below OFF voltage , using only the resistance dut to lode increase after ICIS01 driving.) Fig. 7-1 Samsung Electronics This Document can not be used without Samsung’s authorization...
Page 88
Schematic Diagrams (d) Feedback Control Circuit Fig. 7-3 1) F/B terminal of PQIZ1 determines output duty cyle. 2) C-E (Collector-Emitter) of PQIZ1 and F/B potential of PQIZ1 are same. 7-2-3 Internal Block Diagram (Internal Block Diagram of S.M.P.S Circuit) Fig. 7-4 This Document can not be used without Samsung’s authorization Samsung Electronics...
Schematic Diagrams 7-3 S.M.P.S (S.M.P.S PCB) These are the waveforms of BD-UP5000. QS Caution There can be some differences (Voltage, Frequency, stc.) among cameras. Samsung Electronics This Document can not be used without Samsung’s authorization...
AIC (Pin,,,) ANALOG AUDIO DATA(AIC,,,,7) ANALOG AUDIO DATA AIC, AIC8 (Pin, Pin0~) These are the waveforms of BD-UP5000. Caution There can be some dif ferences (Voltage, Frequency, stc.) among cameras. This Document can not be used without Samsung’s authorization Samsung Electronics...
7-5 Video (Main PCB) Refer to a pattern image of Table 7-5 These are the waveforms of BD-UP5000. Caution There can be some differences (Voltage, Frequency, stc.) among cameras. Samsung Electronics This Document can not be used without Samsung’s authorization...
Page 92
Schematic Diagrams Pr(Color-bar) Y(Color-bar) Y(Color-bar) Pb(Color-bar) Pb(Color-bar) Pin-VR Pin-VC Pin-VC Pin-VC Pin-VR Pr(Color-bar) Y(Color-bar) CVBS(Color-bar) C(Color-bar) ANALOG VIDEO DATA Pin-VR Pin (U-VC,VIC-VR) Pin (U-VC,VIC-VR) Pin (U-VC,VIC-VR7) IC8(RN~RN), IC9(RN~RN7) Fig. 7-5 This Document can not be used without Samsung’s authorization Samsung Electronics...
Schematic Diagrams 7-8 BCM7440 GPIO (Main PCB) FCON1 PIN 25 These are the waveforms of BD-UP5000. Caution There can be some dif ferences (Voltage, Frequency, stc.) among cameras. Samsung Electronics This Document can not be used without Samsung’s authorization 7-...
Schematic Diagrams 7-9 ATAPI/LAN Interface (Main PCB) J7 Pin These are the waveforms of BD-UP5000. Caution There can be some differences (Volt age, Frequency, stc.) among cameras. 7- This Document can not be used without Samsung’s authorization Samsung Electronics...
Schematic Diagrams 7-14 HDMI (Main PCB) HDMI OUTPUT DATA HIC (pin0,,,,,7,9,0) These are the waveforms of BD-UP5000. Caution There can be some differences (Voltage, Frequency, stc.) among cameras. Samsung Electronics This Document can not be used without Samsung’s authorization 7-7...
Schematic Diagrams 7-17 Reon (Main PCB) ANALOG VIDEO DATA UX (XR99, XRN~XRN0) These are the waveforms of BD-UP5000. Caution There can be some differences (Voltage, Frequency, stc.) among cameras. 7-0 This Document can not be used without Samsung’s authorization Samsung Electronics...
7-21 Front (Front PCB) Power Remote control eye data FU3 Pin3 These are the waveforms of BD-UP5000. Caution There can be some differences (Voltage, Frequency, stc.) among cameras. 7- This Document can not be used without Samsung’s authorization Samsung Electronics...