Related Manuals for Action Trackchair ST
Summary of Contents for Action Trackchair ST
- Page 1 Action Trackchair® Owner’s Manual ST, NT, PT, TR, & PR Including Models Revised ~ Nov. 3, 2016 Page | 1...
-
Page 2: Table Of Contents
Triplicate Registration Form……………………………………………………………………………………………………….. Table of Contents……………………………………………………………………………………………………......... 2 Introduction ..............................3 Safety ................................4 Operating the Action Trackchair ........................5 Comfort Adjustments ............................ 6 Batteries and Charging……………..……………………………………………………………………….……………………...7 & 8 Track Adjustment for NT model……………………………………………………………………………………………………………….9 Blank Page……………………………………………………………………………………………………………………………………………. 10 Repair and Maintenance………………………………………………………………………………………………………………………. 11 Warranties .............................. -
Page 3: Introduction
Introduction Welcome to Action Trackchair. We at Action Trackchair want to make your experience the best it can be. Enclosed in this owner’s manual you’ll find information to use and maintain your Action Trackchair. With any questions please contact us at:... -
Page 4: Safety
Safety Guidelines Only one person should be on the Trackchair at any time. Seat belt is recommended. Do not navigate Trackchair/Trackstander on more than a 20 degree slope Trackchair will climb inclines enough to tip over in any direction. ... -
Page 5: Operating The Action Trackchair
After the control has been turned off, hold the on/off button until the control has cycled both on and then off. Control is now set in the locked mode. The Action Trackchair control has five speeds, one-five and can be changed with the up and down arrows. -
Page 6: Comfort Adjustments
Comfort Adjustments There are few adjustments that are necessary. The foot rest can be moved up or down to fit the rider’s needs. The chair itself can be leveled to the desired comfort of the rider. The armrest can flip down or back for easier transferring into the chair. Electronic controls can be adjusted at a servicing distributor/dealer as far as speed, acceleration, deceleration, braking, etc. -
Page 7: Batteries And Charging
Batteries and Charging Battery charge will last up to six hours, depending on battery condition, temperatures and type of use the Trackchair is subject to (terrain and weight of rider). The Trackchair has a built-in battery charger that plugs into 110 volts. Operation after Applying AC Power to a ProSport Charger Connected to Discharged Batteries During the startup test the battery type LED will be illuminated and the red charge mode LED will flash indicating that the... -
Page 8: Batteries And Charging
Batteries and Charging (Continued) To get maximum daily use, the battery must be fully charged. This is accomplished by having the Trackchair plugged in until the “READY LIGHT” comes on. INDEPENDENT CHARGING BANK INDICATIONS When your battery charging system is activated, each bank provides charging information utilizing five red Light Emitting Diode (LED) indicators and one green Light Emitting Diode (LED) indicator. -
Page 9: Track Adjustment For Nt Model
Track Adjustment procedure for NT model Trackchairs Track can be adjusted by loosening both bolts on the front idler wheels, inside and outside. Track tensioners can be tightened with a 9/16 wrench by holding the lock nut and turning track tensioner bolts clockwise an even amount. -
Page 10: Blank Page
This page intentionally Blank Revised Nov. 3, 2016 Page | 10... -
Page 11: Repair And Maintenance
#80500 Cleaning your Trackchair/Trackstander The Action Trackchair/Trackstander can be washed with a garden hose, do not use high pressure wash to clean the chair. Always cover the joystick with a plastic bag to protect it from getting moisture inside. THE JOYSTICK IS NOT WATERPROOF and should be covered when washing, or stored outside or when transporting behind the vehicle open. -
Page 12: Warranties
Warranties 1 YEAR: The following components are covered against manufacture defects in materials and workmanship for the period of one year. o Batteries o Control box and joy stick o Motors o All sprockets and idler wheels o Seats o Tilt Actuator o All other parts 1 year Parts and Labor. -
Page 13: Specifications
Specifications ST Models TR Models Trackstander ST16, ST18, ST20, ST22, ST24 TR1816, TR1820, TR2016, TR2020 Height 42” 43” lowered 64” raised Width 37”, 37”, 39”, 41”, or 43” 37” or 39” Length 52 ½ “ w/ rear idlers 59” w/ rear idlers to front wheel kit... -
Page 14: Specifications
6 ½” X 90” Batteries Two 12 volt AGM Wheelchair Bat. Two 12 volt AGM Wheelchair Bat. Controls Action Trackchair controls Action Trackchair controls Motors 24 volt DC 24:1 ratio high torque 24 volt DC 24:1 ratio high torque Speed... - Page 15 HANDCONTROL LCD DISPLAY FAULT/WARNING REMEDY Power Section Fault, or Current Sensor Fault, or EEPROM Fault, or Main Relay Fault, or Precharge Fault, or HW Failsafe 1. Cycle power Fault. 2. Replace powerbase. Handcontrol Fault, or Joystick Fault: 1. Return joystick to neutral and cycle power Joystick out of center, 2.
- Page 16 Controller Over/Under temperature 1. If too hot, wait for controller to cool. warning. 2. If too cold, drive chair in limited current mode until controller warms up. Drive Thermal Warning 1. Wait for motor to cool. 1. Check wiring. Open Motor Fault 2.
-
Page 17: Strapping Methods With Trackchair Carrier
Strapping Methods Proper strapping options for Trackchair to carrier ***Class III receiver hitch required for carrier, Check auto manufacturers recommendation for hitch capacity*** Class III—2”-- Up to 6,000 pounds towing capacity, up to 600 pounds tongue weight Revised ~ Oct. 19, 2016... -
Page 18: Rocker Switch Override Instructions
Rocker switch override instructions Actuator not moving up or down? First check the fuse in the black fuse holder located at the black & red, 16 gauge wire harness which comes off the battery, fuse type is an ATC 20 amp. If you suspect the actuator has failed and you have a “Tilt on the Fly”... -
Page 19: Law, Regulation And Policy For Wheelchair/Mobility Device Use In "Federally Designated Wilderness
Law, Regulation and Policy for Wheelchair/Mobility Device Use in “Federally Designated Wilderness (ADA Title V Section 508c, as amended in 2008) (1) IN GENERAL – Congress reaffirms that nothing in the Wilderness Act prohibits wheelchair use in a wilderness area by an individual whose disability requires its use. The Wilderness Act requires no agency to provide any form of special treatment or accommodation or to construct any facilities or modify any conditions of lands within a wilderness area to facilitate such use.
Need help?
Do you have a question about the ST and is the answer not in the manual?
Questions and answers