This TK-8102H service manual contains a number of sections which differ from the service manual (B51-8611-00) for the TK-8102H. For items other than those in this TK-8102H service manual please refer to the service namual (B51-8611-00) for the TK-8102H. Chassis...
TK-8102H GENERAL INTRODUCTION PRE-INSTALLATION CONSIDERNATIONS SCOPE OF THIS MANUAL 1. UNPACKING This manual is intended for use by experienced techni- Unpack the radio from its shipping container and check cians familiar with similar types of commercial grade com- for accessory items. If any item is missing, please contact munications equipment.
Page 3
Plan cable runs for protection against pinching or crush- Your KENWOOD dealer can help you select an antenna sys- ing wiring, and radio installation to prevent overheating. tem that will best serve your particular needs.
Les articles non mentionnes dans le Parts No. ne sont pas fournis. Y : AAFES (Europe) X : Australia M: Other Areas Teile ohne Parts No. werden nicht geliefert. TK-8102H (Y51-4840-XX) DISPLAY UNIT (X54-3340-20), TX-RX UNIT (X57-6390-XX) Desti- Desti- Ref. No.
Page 5
TK-8102H PARTS LIST TX-RX UNIT (X57-6390-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation CC73GCH1H080B CHIP C 8.0PF C143 CK73GB1H102K CHIP C 1000PF CC73GCH1H030B CHIP C 3.0PF K2,M2 C144 CK73GB1H392K...
Page 6
TK-8102H PARTS LIST TX-RX UNIT (X57-6390-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation C226 CK73GB1C683K CHIP C 0.068UF C367 CK73GB1H471K CHIP C 470PF K,M,K3 C228 CK73GB1H471K CHIP C 470PF...
Page 7
TK-8102H PARTS LIST TX-RX UNIT (X57-6390-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation C841 C93-0599-05 CHIP C 470PF K2,M2 L19,20 L40-2785-92 SMALL FIXED INDUCTOR (270NH) K2,K3,M2 C842 C93-0552-05 CHIP C 2.0PF...
Page 8
TK-8102H PARTS LIST TX-RX UNIT (X57-6390-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation RK73GB1J102J CHIP R 1.0K 1/16W R108 RK73GB1J274J CHIP R 270K 1/16W RK73GB1J123J CHIP R 1/16W R109...
Page 9
TK-8102H PARTS LIST TX-RX UNIT (X57-6390-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation R192 RK73GB1J562J CHIP R 5.6K 1/16W R302 RK73GB1J683J CHIP R 1/16W R194 RK73GB1J153J CHIP R 1/16W...
Page 10
TK-8102H PARTS LIST TX-RX UNIT (X57-6390-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation MA360 VARIABLE CAPACITANCE DIODE 2SK1824 DAN222 DIODE 2SC3356(R24) TRANSISTOR MA2S111 DIODE 2SC4617(S) TRANSISTOR MA742 DIODE 3SK255...
TK-8102H EXPLODED VIEW M2.6 x 8 : N67-2608-46 M2.6 x 6 (Br-Tap) : N87-2606-46 M2.6 x 14 (Br-Tap) : N87-2614-46 Bx2 Bx2 IC101 Q101 DISPLAY UNIT (X54) TX-RX UNIT (X57) Parts with the exploded numbers larger than 700 are not supplied.
TK-8102H ADJUSTMENT Test Equipment Required for Alignment Test Equipment Major Specifications 1. Standard Signal Generator Frequency Range 400 to 520MHz (SSG) Modulation Frequency modulation and external modulation Output –127dBm/0.1µV to greater than –7dBm/100mV 2. Power Meter Input Impedance 50Ω Operation Frequency...
Page 14
TK-8102H ADJUSTMENT Note Adjustment Location • EEPROM Switch The tuning data (Deviation, Squelch, etc.) for the Power Display EEPROM, is stored in memory. When parts are changed, Volume readjust the transceiver. up/down Speaker • AF PA IC (IC101) How to mounting the IC101.
Page 15
TK-8102H ADJUSTMENT 5. The solder melts and binds the FET and the cube se- Replacing a Drive FET (Q801) curely. Then, slide the soldering iron along the PCB sur- 1. When replacing the Drive FET, you must also replace its face to cool the soldering down ( r ).
TK-8102H TK-8102H LEVEL DIAGRAM Receiver Section Center Frequency 49.95MHz 450kHz Audio Frequency W –85.0dBm W –93.0dBm N –85.5dBm N –91.0dBm W –121.0dBm W –119.0dBm W –105.5dBm W –106.0dBm W –117.5dBm W –103.0dBm N –120.5dBm N –118.5dBm N –105.5dBm N –105.0dBm N –117.0dBm...
TK-8102H SPECIFICATIONS GENERAL Frequency Range ....... K,M : 450 to 490MHz K2 : 485 to 512MHz K3 : 400 to 430MHz M2 : 485 to 520MHz Number of Channels ......4 channels Channel Spacing ......... Wide : 25kHz Narrow : 12.5kHz PLL Channel Stepping ......
Page 27
Leuvensesteenweg 248 J, 1800 Vilvoorde, Belgium KENWOOD ELECTRONICS FRANCE S.A. 13, Boulevard Ney, 75018 Paris, France KENWOOD ELECTRONICS U.K. LIMITED KENWOOD House, Dwight Road, Watford, Herts., WD1 8EB United Kingdom KENWOOD ELECTRONICS EUROPE B.V. Amsterdamseweg 37, 1422 AC Uithoorn, The Netherlands KENWOOD ELECTRONICS ITALIA S.p.A.