Boru Stoves Carraig Mor Installation & Operation Instructions
  1. Manuals
  2. Brands
  3. Boru Stoves Manuals
  4. Stove
  5. Carraig Mor
  6. Installation & operation instructions

Boru Stoves Carraig Mor Installation & Operation Instructions

Boiler stove 20kw with co2burn technology
Hide thumbs
Table of Contents

Advertisement

Quick Links

©
Made in Ireland
Congratulations! On the purchase of your
BORU BOILER STOVE
Carraig Mor 20kW
With Co
burn Technology
2
INSTALLATION & OPERATION INSTRUCTIONS
*FUEL GUIDELINES PLEASE SEE PAGE 15-16*
TO AVAIL OF OUR EXTENDED WARRANTY COVER PLEASE FILL OUT PAGE 35 IN FULL OR
VISIT http://borustoves.ie/boru-stoves-warranty/ FOR DETAILS
.
1

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Carraig Mor and is the answer not in the manual?

Questions and answers

Related Manuals for Boru Stoves Carraig Mor

Summary of Contents for Boru Stoves Carraig Mor

  • Page 1 © Made in Ireland Congratulations! On the purchase of your BORU BOILER STOVE Carraig Mor 20kW With Co burn Technology INSTALLATION & OPERATION INSTRUCTIONS *FUEL GUIDELINES PLEASE SEE PAGE 15-16* TO AVAIL OF OUR EXTENDED WARRANTY COVER PLEASE FILL OUT PAGE 35 IN FULL OR...

  • Page 2: Table Of Contents

    TABLE OF CONTENTS 1. Specification & Technical Details Page 3 2. Installation & Operation Guidelines Page 4-8 3. Connection to the chimney Page 9-11 4. Connection to the heating system Page 11-13 5. Cautions & Additional Information Page 14 6. Fuel Guidelines Page 15-16 7.

  • Page 3: Specification & Technical Details

    1. SPECIFICATION & TECHNICAL DETAILS The Carraig Mor 20kW Boiler is independently tested in accordance with standards: EN13240:2001 & EN 13240-A2:2004 Total thermal output - 21.2kW Energy Efficiency - 77.1% Fire Safety - Approved Boiler type - Wraparound boiler for up to 14 single radiators or 55,000 BTU’s Each radiator is based on a 4’...

  • Page 4: Installation & Operation Guidelines

    – Heat Producing Appliances MUST BE ADHERED TO. Boru Stoves cannot accept responsibility for any fault arising through incorrect use or installation. It is the responsibility of the stove installer & owner to be aware of any amendments to the above document &...
  • Page 5  The stove is pre-assembled and ready for installation  Please keep this manual along with the checklist and copy of the extended warranty sheet in a safe place, fill out and hand the extended warranty sheet to the stove owner on completion of the installation.
  • Page 6 IMPORTANT WARNING  Only one appliance may be used per flue.  There must not be an extractor fan fitted in the same room as the stove as this can cause the stove to emit fumes and smoke into the room - For solid fuel appliances extract ventilation should not be installed in the same room as an open-flued solid fuel appliance.
  • Page 7 The Carraig Mor 20kW Boiler Model Stove produces radiant heat. The stove must be situated in accordance with parts J, F & L of the Building Regulations. The clearance specifications in this manual must be adhered to and comply with Building Regulations.
  • Page 8 Notwithstanding these dimensions, stove installed in a room with no standard chimney must be provided with a hearth measuring at least 840mm x 840mm. 2.5 AIR SUPPLY A heat producing appliance shall be installed so that there is an adequate supply of air to it for combustion, to prevent overheating and for the efficient working of any flue pipe or chimney serving the appliance.

  • Page 9: Connection To The Chimney

    3. CONNECTION TO THE CHIMNEY All Boru Stoves are certified with a chimney draught reading of 12-14 pascals – where the chimney draught exceeds this reading we recommend a draught stabiliser be installed – please contact an accredited chimney specialist for further details.
  • Page 10  Where the chimney is believed to have previously served an open fire installation, it is possible that the higher flue gas temperature from the stove may loosen deposits that were previously firmly adhered, with the consequent risk of flue blockage. It is therefore recommended that the chimney be swept a second time within a month of regular use after installation.

  • Page 11: Connection To The Heating System

     BTU requirements MUST be confirmed with an accredited installer before this stove is installed to ensure this stove is suitable for requirements. Boru Stoves and/or its authorised agents will not be responsible for an appliance which is not confirmed suitable for room and water requirements.
  • Page 12  Each installation is unique to the dwelling so it is not possible to give exact instructions for each specific fitting, therefore consult with your accredited installer.  The pipe fittings on the stove are 1” BSP, all inlet and outlet piping and connections should be 1”...

  • Page 14: Cautions & Additional Information

    5. CAUTIONS  Hot while in operation, children, clothing and furniture should be kept a safe distance from the stove and the minimum distances to combustibles must be adhered to. See page 8  Handles & Sliders can get extremely hot – Use Multi Tool provided. See page 5. ...

  • Page 15: Fuel Guidelines

    Burning petroleum based fuels will push your stove beyond it’s design capability. This will over fire your stove and void your extended warranty. Please do not hesitate to contact any member of our team at Boru Stoves if you have any further queries.
  • Page 16 6.1 Boru Stoves are NOT designed to burn the following:  All Paper or cardboard based items  Treated or painted wood, pallets or manufactured board products  Synthetic fuel or logs that are not approved for solid fuel stoves ...

  • Page 17: Lighting The Stove For The First Time

     After each fire leave the stove to cool down completely before lighting the next fire.  The Carraig Mor Boiler Stove is fitted with an automatic stove damper numbered 1-8 (8 being the maximum, 1 being the minimum), This allows a controlled volume of air through the stove.
  • Page 18  Only open the door to fuel/refuel the stove. Operating the stove with the door open will result in excess air that will cause the stove to over fire and will void your extended warranty and cause irreparable damage.  DO NOT OVER FIRE. IF THE CHIMNEY OR STOVE GLOW RED YOU ARE OVER FIRING CAUSING AN UNSAFE CONDITION.

  • Page 19: Controlling The Stove

    8. CONTROLLING THE STOVE  For your stove to burn correctly you need air to burn the fuel. The volume of air is controlled by using the dampers on the door and the stove thermostat - this will get the maximum amount of air into the stove getting the fire established and getting heat transferred to the water and radiators.

  • Page 20: Refueling

    9. REFUELING  Before refuelling open the primary & secondary levers to reduce the chance of fuel odour.  Care must be taken when refuelling the stove. A protective glove or the multi tool handle (see diagram) provided must be used as the handle on the body of the stove can get extremely hot.

  • Page 21: Replacement Parts

    The following guidelines must be adhered to IF FUMES ARE PERSISTENT  If the CO alarm goes off do not enter the room  Open the doors and windows to ventilate the room  Let the fire out or remove and safely dispose of the fuel from the stove ...

  • Page 23: Stove Maintenance

    12. STOVE MAINTENANCE Boru Stoves recommend your stove is checked and serviced by an accredited engineer at least once a year It is very important that your stove is checked regularly for the following:  Creosote: When fuel is burned slowly, it produces tar and other organic vapours, which combined with expelled moisture form creosote.

  • Page 24: Cleaning The Glass

    Do not open the door until the stove is completely cool. Glass for your Stove is 4mm Boru Stoves Heat Resistant Glass. Only use genuine Boru Glass. If handling glass whether broken or not – ALWAYS wear protective gloves.

  • Page 25: Test And Repair Of Rope Seal

    14. TEST & REPAIR OF DOOR GASKET (ROPE SEAL) You will need to replace the rope seal a minimum of once a year using the following steps:  Remove the original rope seal by grasping an end and pulling firmly ...

  • Page 26: In The Event Of A Chimney Fire

    16. IN THE EVENT OF A CHIMNEY FIRE  IF IN IMMEDIATE DANGER LEAVE THE BUILDING  Raise the alarm to let others in the house know.  Call the Fire Brigade on 999 or 112  Reduce the appliance-burning rate by closing all air controls ...

  • Page 27: Frequently Asked Questions

    What warranty do I have with my Boru Stove  Boru Stoves offer a limited extended warranty cover of 6 years on the Carraig Mor 20kW boiler, excluding wearable parts, from date of purchase, including your statutory rights. ...
  • Page 28  All Boru Stoves boiler model stoves are designed to heat water once installed correctly into a suitable heating system, guidelines set out in this manual must be followed along with the use of suitable fuel ...
  • Page 29 Can I continue to use my stove in a power failure  NEVER continue to use the stove in the event of a power failure  Do not fuel and/or use the stove  Close all dampers fully Why do I have to use insulation around the inset stoves - ...

  • Page 30: Service And Maintenance Record

    SERVICE & MAINTENANCE RECORD Details of service & items replaced: Date: Serviced by: Signature: Contact number: Details of service & items replaced: Date: Serviced by: Signature: Contact number: Details of service & items replaced: Date: Serviced by: Signature: Contact number: Details of service &...
  • Page 31 SERVICE & MAINTENANCE RECORD Details of service & items replaced: Date: Serviced by: Signature: Contact number: Details of service & items replaced: Date: Serviced by: Signature: Contact number: Details of service & items replaced: Date: Serviced by: Signature: Contact number: Details of service &...

  • Page 32: Extended Warranty Policy And Procedures

    EXTENDED WARRANTY POLICY & PROCEDURES Boru Stoves offer a limited extended warranty cover of 6 years on the Carraig Mor 20kW Boiler Stove, from the date of purchase, including your statutory rights. Please be advised your extended warranty must be activated within three months of purchase.

  • Page 33: Troubleshooting

     It may be advisable to fit a rain cowl to the chimney to reduce this problem, please take advice from your installer or an accredited chimney specialist. If the Carraig Mor 20kW emits smoke into the room continuously, close the air controls and allow the stove to go out, and ventilate the room to clear the fumes.

  • Page 34: Extended Warranty Claim Form

    Please provide contact details of your stove installer: Name: Phone No: Address: E-Mail: Please tick to confirm you authorise Boru Stoves to contact your stove installer: Yes, I authorise _____ No, I do not authorise _____ If you answered no, please state the reason: ___________________________________________________________________________...

  • Page 35: Must Be Filled Out In Full Within 3 Months Of Purchase

    Phone: 0504-59033 Please be advised your extended warranty must be activated within three months from the day of purchase. After this Righpur Ltd t/a Boru Stoves will cancel their offer of extended warranty. If you require confirmation of an activated extended warranty please include a stamped addressed envelope or provide us with your email address.

  • Page 36: Terms & Conditions Of Extended Warranty

    Boru Stoves control. warranty details sheet filled out in full and It is the responsibility of the stove owner and sent back to Boru Stoves within 3 months Boru stoves may amend these terms and installer to install the stove in accordance from the date of purchase.

Table of Contents

Save PDF