Table of Contents
Advertisement
■ FORK OIL
● Place the front fork vertically without spring.
● Compress it fully.
● Pour specified front fork oil up to the top level of the
outer tube.
● Move the inner rod slowly more than ten times until
bubbles do not come out from the oil.
NOTE
Refill front fork oil up to the top of the outer tube
to find bubbles while bleeding air.
● Refill specified front fork oil up to the top level of the
outer tube again. Move the outer tube up and down
several strokes until bubbles do not come out from
the oil.
● Keep the front fork vertically and wait 5-6 minutes.
NOTE
● ● Always keep oil level over the tube top end, or
air may enter the tube during this procedure.
● ● Take extreme attention to pump out air com-
pletely.
● Hold the front fork vertically and adjust fork oil level
with the special tool.
NOTE
When adjusting the fork oil level, remove the fork
spring and compress the outer tube fully.
Front fork oil capacity
Front fork
146mm(5.8 in) from end of outer tube
oil level
(when maximum compressed without spring)
Front fork oil specification : TELLUS #32
Front fork oil level gauge : 09943-74111
Each leg
380cc
Standard
CHASSIS 7-20
- Quick Links:
- Fuel System
Hide quick links:
Advertisement
Chapters
Table of Contents
Need help?
Do you have a question about the GT 650 and is the answer not in the manual?
Questions and answers
Hi, where are the little lamps for in the headlight unit? They don’t light up
The little lamps in the headlight unit of a HYOSUNG GT 650 are illumination lamps with a wattage of 1.7W. If they do not light up, possible reasons could be a blown bulb, a faulty connection, or an issue with the electrical system. Checking the bulb, wiring, and fuse could help identify the problem.
This answer is automatically generated
@Mr. Anderson thanks for your reply. The lamp isn’t broken but just doesn’t illuminate. By the way I don’t know the reason for this little lamp because the headlight of a Hyosung 650 is always on, there is no switch to turn it off. For a car I know it’s used as a parking light. I hope you have an andwer for me.