Examples: Handle brackets, Metal Part metal cabinets, screwheads and control shafts. The current measured should not Ohmmeter exceed 0.5 milliamp. Reverse the power- plug prongs in the AC outlet and repeat. Fig. 1-2 Insulation Resistance Test Samsung Electronics...
Make sure that the 8. Always connect a test instrument's ground portion around the serviced part has not lead to the instrument chassis ground been damaged. before connecting the positive lead; always remove the instrument's ground lead last. Samsung Electronics...
Page 4
SCAN : Manufactured for Scandinavian KATSO SATEESEEN! Market. VARNING: OSYNLIG LASERSTRÅLNING NAR DENNA DEL AR OPPNAD OCH SPARREN AR URKOPPLAD BETRAKTA EJSTRÅLEN! Fig. 1-4 Warning Labels (Location: Disc Clamper, Inner Side of Unit Door or Nearby Unit Chassis ) Samsung Electronics...
Page 5
6. After replacing the Pickup, reopen the Short Terminal. See diagrams below: THE UNIT (1) WRIST-STRAP CONDUCTIVE SHEET FOR GROUNDING short short short short terminal terminal terminal terminal SOH-A1 SOH94T4N SOH91CI(CAR,walkman) (CMS-V10,CMS-V30) SOH91VI(LDP) (CMS-V10,CMS-V30) Samsung Electronics...
Signal to noise ratio 40dB Total harmonic distortion 2.5% Frequency response 100Hz ~ 10KHz(¡ 1dB) Signal to noise ratio 85dB(1kHz 0dB) Compact Disc Channel separation 75dB(1kHz 0dB) Total harmonic distortion 0.1%(1kHz 0dB) * Specifications are subject to change without notice. Samsung Electronics...
3. Disassembly and Reassembly 3-1 Cabinet-Top, Cabinet-Rear 1. Remove 8 screws of ! and 6 screws of @ of its rear part. 2. Pull its top part upward vertically as shown in the figure 3-1. Figure 3-1 Samsung Electronics...
Page 8
Disassembly and Reassembly 3-2 Main-PCB 1. Remove the Main-PCB backward. Main-PCB Figure 3-2 Samsung Electronics...
Page 9
Disassembly and Reassembly 3-3 Cabinet-Bottom 1. Remove 3 screws of ! and pull it out backward. Figure 3-3 3-4 CD-Pack 1. Undo 4 screws of ! and then remove the CD-Pack downward. Figure 3-4 Samsung Electronics...
Page 10
9. Remove the Gear(c) ) by pushing the hook. 10. Lift the Gear(b) 1 . 11. Remove the Gear(a) 2 . 12. Remove 2 screws 3 and then remove the Feed-Motor 4 . 13. Remove the Chassis-Deck(M) 5. Figure 3-5 Samsung Electronics...
SSG FREQ. 999KHz Adjustment point SEMI-VR(20KB) (ISVR2) "TUNED" is shown on LCD(Figure 4-3) AM Loop antenna jack Speaker AM SSG Test Loop Terminal Antenna Antenna Oscilloscope 60 cm Electronic 52dB Voltmeter Figure 4-3 AM Auto Search Level Adjustment Samsung Electronics...
Page 12
2 . Adjust Record Bias Level Pre-Setup Step Item Pre-Setup To Adjust Standard Remark Condition See the 85KHz 5% Turn BIAS oscillator diagram Insert MTT-5512 Figure 4-6 BIAS frequency coil (JT1) to into Deck,then press adjustment REC button. the right and left locations Samsung Electronics...
Page 13
Raise NVR1702 and adjust the waveform so that its middle Set NVR1701 to 0mV. comes to GND of the oscilloscope (or until the upper half of waveform becomes symmetrical to the bottom half, A=B) Adjust NVR1704 (arrow) for normal sound. Samsung Electronics...
? RZD2,RC4,RR3,RR4, oscillate ? (pin no. 13 ;5.0V) RR2,RC1,RD1 Front PCB When the power is Replace µ-com ON 'H' displays at pin no. 49 ?(5V) Connect Front PCB and Main PCB. Check the connector Main PCB. Wafer JWC3,JWC4 Samsung Electronics...
Page 15
4,2,15 source part in RD2(PBL403), B+,B- circuits RC3 and RC14. Confirm for TR short AQ1L/1R Base B+ ? replace it. Is Mute selected ? Remove it with Remocon Replace Headphone jack Headphone Jack short ? soldering condition Samsung Electronics...
Page 16
7.5V ? Replace LC72131 AM VT Check the LC72131 LC72131 pin 20 CONTROL ok ? 7V ? 0.9V Check HIC1 pin 20 ? Check FEP interior LPF(IL1, IL2) Check LC75394E function ok? pattern, and any line output ok? disconnections. Samsung Electronics...
Page 17
Check for voltage at pin 6 AMPS IC JIC2 AMPS When between songs : High (Normal) (LA2010) When playing song : Low (Normal) Osc Frequency : 85KHz Oscillate RECORD BIAS (85KHZ) BIAS OSC When inoperative : JQ5,JQ6 check Samsung Electronics...
Page 18
CLOSE condition : 0V Check oscillation of NXF100 Is Focus Search done properly ? (16.9344MHz). Does Laser function during Replace PICK-UP. Focus Search ? Check NIC9282 pin73 voltage Replace NIC9282. during Focus Search : 5V Replace NIC9220 or NIC9258. Samsung Electronics...
GEAR-PLAY 22-222-4282 10000-611-057 AH81-10033H ASSY PULLEY FR CRF452 22-093-3918 10000-611-063 AH81-10033J BELT FR CRF452 02-083-4127 10000-611-064 AH81-10033K ASS’Y FLYWHEEL L CRF452 22-220-3738 10000-611-065 AH81-10033L 10000-611-066 ASS’Y FLYWHEEL R CRF452 22-093-3917 10000-611-067 AH81-10033M BELT MAIN CRF452 02-084-4128 18 19 Samsung Electronics...
Page 21
Exploded Views and Parts List 7-2 Main Exploded View and Parts List MUTE SLEEP FUNCTION CLOCK PRE/MAN RPLAY STOP F.PLAY FM-MODE COUNT REVERSE MODE SYNCHRO BAND PROG/MEMO VOLUME TUN/PRE TUN/PRE DOWN TIME TIME VOLUME STOP PLAY/PAUSE SKIP/SEARCH CD REPEAT Samsung Electronics...
Page 22
SILICON,- RUBBER-CAP AH61-10675A -,SUS,-,T1.0 BRACKET-MOUNT 16603-511-840 ABS +GF BLK CHUCK-PLATE AH63-70025B -,T/PAPER,T0.07,L20,W10 SHEET-CHUCK AH68-50262B T/PAPER LABER-REFLECT AH61-20258C ABS,-,BLK CAP-PICK UP G3A8-1/16/C G3A8 TOP CD MM16/MM26 ASSY CD-PACK AH73-10012A RUBBER-CD SI RUBBER,-,CMS-M5M6C AH61-50182A FE FZW,D2.6,L11.5,-,- SHIFT-CD AH59-10082A UPD78P063,27,MM-26 REMOCON-ASS’Y Samsung Electronics...
Page 39
VOL SEL L P F D / A MICMIX SW V O L 16kSRAM PHASE SEL PHASE L O G I C MODE SEL C L K L P F A / D BA4560 : AIC2,LIC1,PIC2(OPTION), MIC2(OPTION), MIC3(OPTION) Samsung Electronics...
Page 41
TIMER TIMER ON OFF ON OFF AI SLEEP AI SLEEP REPEAT REPEAT MUTE MUTE SYNC SYNC ST MONO ST MONO TUNED TUNED 9 10 11 VOLUME VOLUME VOLUME VOLUME RELAX RELAX FLAT FLAT POPS POPS ROCK ROCK CLASSIC CLASSIC BGNS BGNS MEMO MEMO PROG.
Page 44
3RAM ADDRESS LOCK GENERATOR X' TAL XOUT TIMING GENERATOR INTERPOLATE X' TAL C P U MDAT TIMING INTERFACE GENERATOR MCK 38 DIGITAL FILTER (BFS) TRCNT /ISTAT VREFH2 VREFH1 D A C VREFL1 MODE DIGITAL SELECTOR OUTPUT VREFL1 9-10 Samsung Electronics...
Page 45
CE 2 LC72131 CONTROL CE BCLK BGNS CONTROL CLOCK TUNER MUTE CONTROL DI 2, DO 3 LC72131 DATA INPUT, LC75394 CONTROL DATA OUTPUT CE 3 LC75394E (FUNCTION) CONTROL CE PSENS POWER SENSE CLSW CD DOOR CLOSE CHECK Samsung Electronics 9-11...
Page 46
“ OPTION TUNER OPTION INPUT DSP/SSP CONTROL CLOCK LD XRT LD ON AND DSP/SSP RESET CONTROL MDATA DSP/SSP CONTROL DATA DSP/SSP CONTROL LATCH CDMT CD MUTE CONTROL SQDT SUB Q DATA INPUT LKFS GFS INPUT FOCUS OK 9-12 Samsung Electronics...