Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for Sodikart LR5
Summary of Contents for Sodikart LR5
- Page 1 owner’s manual RENTAL...
- Page 2 Foreword The purpose of the Owner’s Manual is to familiarise you with the operation, maintenance, and safety features of of publication. Sodikart nevertheless reserves the right to apply changes in order to uphold its policy of continuous ferences between the content of the manuals and the go-kart you own.
-
Page 3: Table Of Contents
owner’s manual RENTAL Table of contents 1 - General ..........4 6.5 - Spark plug ..........12 6.6 - Rocker arm ..........12 1.1 - Warning ............ 4 6.7 - Idle............12 1.2 - Safety instructions ........4 6.8 - Fill with fuel..........12 1.2.1 - Track ............4 1.2.2 - Buildings ............4 6.9 - Brake pads .......... -
Page 4: General
● Use tyres with a grip adapted to the surface of the ● Use the go-kart only on a go-kart track track. In case of difficulty, contact SODIKART ● Get the track approved. ● Check and maintain the safety components with care: ●... -
Page 5: Prohibitions
owner’s manual RENTAL ● For small driver (between 130cm and 150cm), use a Suit for wet conditions with waterproof fastening spacer (removable foam). (recommended when necessary). Notffollowingfsizefandfagefrestrictionsf Thefmobcapfisfdesignfforfthefhygiene.fItf exposesfthefdriverfandfotherfpilotsftof isfnotfafdeviceftofsecureflongfhair. seriousforfevenffatalfinjuries,fandfmayf Longfhairfstickingfoutfoffthefhelmetfandf involvefthefliabilityfofftheftrack. (or)floosefclothesfexposefthefdriverftofaf riskfoffseriousforfevenffatalfinjuries,fbyf 1.2.7 - Prohibitions windingfaroundfrotatingfpartsfoffthefgo- kart. ●... -
Page 6: Safety Stickers
2.1 - Delivery During the delivery, check the go-kart is not damaged, and all documents are supplied (user maintenance guide, declaration of conformity). Otherwise contact SODIKART. ● Make sure the go-kart and the engine correspond to your order. 2.2 - Standards This go-kart complies with the French standard NF S52-002 of February 2001. -
Page 7: Chassis
2.5 - Engine ● Check that the maintenance and operating manual for the engine has been supplied. If not, contact SODIKART at the above address. ● Use only unleaded fuel 98 or 95. 2.6 - Lubricant Fuel.......Unleaded fuel 98 or 95 Engine oil ......Oil 4T KARTLUB 10W40... -
Page 8: Start Up With A Driver On The Go-Kart
owner’s manual RENTAL 4 - Driving the go-kart 3.3 - Start up with a driver on the go-kart ● Place the driver on the go-kart. 4.1 - Pedals ● Set the start button to ON. ● Pull the starter lever. Adjusting the position of the pedals ●... -
Page 9: Seat
owner’s manual RENTAL 4.3 - Seat Adjusting the position of the seat Legend Belt ● Pull the strap (1) to adjust the front/rear position of the seat according to the driver’s height. ● Check that the seat is properly indexed in a position. LR5_Owner_EN_00... -
Page 10: Frequency Of Maintenance
owner’s manual RENTAL 5 - Frequency of maintenance ● The following tables list the recommended frequency of all the periodic maintenance operations required to ensure optimum go-kart operation. ● ● When●go-karts●are●used●under●harsh● conditions,●carry●out●maintenance●more● often. ● I = Inspect and then clean, adjust, replace, or grease if necessary ●... -
Page 11: Routine Maintenance Programme
owner’s manual RENTAL 6 - Routine maintenance programme 6.3 - Air filter 6.1 - Engine oil Legend Paper filter unit Foam filter element Soapy water or solvent Legend Engine oil Filler cap / Oil gauge Drain plug 6.3.1 - Paper filter unit Washer Lower edge of the oil fill hole Gently tap the filter unit on a hard surface several times... -
Page 12: Spark Plug
owner’s manual RENTAL 6.5 - Spark plug 6.8 - Fill with fuel Petrolfisfhighlyfflammablefandfexplosive,f andfseriousfinjuriesfcanfoccurfwhenf fillingfup. Switchfofffthefenginefandfbanfanyfheatf sources,fsparks,forfflamesfinfthefvicinity. 0.7 / 0.8mm Never use spoiled or contaminated petrol ● Legend or an oil/petrol mixture. Prevent dirt and Spark plug water from entering the fuel tank. Sealing washer ●... -
Page 13: Brake Pads
owner’s manual RENTAL 6.9 - Brake pads ● ● Double-check●that●the●clips●(4)●are●properly● engaged. The brake pads must be changed, when their have worn ● ● Ensure●that●the●pads●are●in●the●correct● down to minimum thickness. position. Minimum brake pad thickness: 8 mm (4 mm lining ● ● It●is●strongly●advised●to●bleed●and●renew●the●... -
Page 14: Belt Tension
● ● We●recommend●that●you●drain●and●refill●the● ● ● Check●the●tension●daily.●Incorrect●tension● brake●circuit●after●every●brake●pad●change.● leads●to●premature●wear. This●will●allow●you●to●maintain●optimum● braking●performance. ● ● Replace●any●damaged●belt●to●eliminate●the● ● ● risk●of●engine●overspeed. To●bleed●your●brake●system●more● rapidly,●especially●for●a●big●fleet,●we● recommend●the●priming●system●SODIKART● Belt tension adjustment (Ref.●OU951.002). ● ● Store●the●used●brake●fluid●in●labelled● 5 à 10 mm containers●until●it●is●collected●by●a●specialist● waste●disposal●company. ● ● The●brake●liquid●doesn’t●contain●petrol,●so● never●pour●the●liquid●into●a●using●oil●tank. ● ● Brake●fluid●absorbs●water●Make●sure●the● replacement●brake●fluid●comes●from●a●... -
Page 15: Tyres
owner’s manual RENTAL ● ● A●poorly●tightened●belt●is●subject●to● Changefallfdamagedfrims:fafdamagedf premature●wear.●Check●its●tension●regularly. rimfmayfleadftofaflossfofftyreforflossfoff ● ● An●excessively●tight●belt●causes●engine●and● pressurefandfmayfleadftofafseriousforf chassis●fatigue. evenffatalfinjury. CheckftheftyrefwearfdailyfWornforf Theftransmissionf(includingfthefrearf damagedftyresfmayfleadftofafseriousforf shaft)fisfafmovingfpartfthatfcreatesfaf evenffatalfinjury. riskfoffseriousforffatalfaccidentfifflongf Neverfrunfwithfwornforfdamagedftyres:f hairforfclothingfshouldfbecomefcaughtf afburstfofftyrefmayfleadftofafseriousforf infit.fMakefsurefthatfthefprotectionsfaref evenffatalfinjury. correctlyfsecuredfandfinfafgoodfstate. Alwaysfblowfupftyrefwithfthefpressuref recommendedfbyfthefmanufacturer. Drivingfwithfcoldftyresfcanfleadftof 6.12 - Tyres skiddingfandfmayfcausefafseriousforffatalf accident. Toofmuchfgripfreducesfthefstabilityfoff thefgo-kartfunderfimpact,fandfleadftofaf tendencyftofgofonftwofwheels,fitfalsof increasesfthefriskfoffridingfover. Storeftyresfinfanfappropriatefareaftof preventffirefhazard. -
Page 16: Chassis Cleaning
owner’s manual RENTAL 7 - Troubleshooting ● Check that the retractors (5) are operating properly: Pull the strap and then release it to find out whether it rolls up fully. The go-kart will not brake Yank the strap to check that it locks in the event ●... -
Page 17: Declaration Of Conformity
- The NFS52-002. - The FFSA technical and safety rules for karting. - The CIK-FIA recommendations for leisure karting. Made at Couëron, on 28-02-2014 on behalf of Sodikart, Mister : Gilles BAGNARIOL Job title : Technical director Signature : LR5_Owner_EN_00...
Need help?
Do you have a question about the LR5 and is the answer not in the manual?
Questions and answers