SERVICE AIDS Compact Disc: Service Tools: SBC426/426A Test disc 5 + 5A ......4822 397 30096 Universal Torx driver holder .........4822 395 91019 SBC442 Audio Burn-in test disc 1kHz ....4822 397 30155 Torx bit T10 150mm ...........4822 395 50456 SBC429 Audio Signals disc .........4822 397 30184 Torx driver set T6-T20 .........4822 395 50145 Dolby Pro-logic Test Disc ........4822 395 10216 Torx driver T10 extended ........4822 395 50423...
Page 3
CD PLAYABILITY CHECK Customer complaint "CD related problem" Set remains closed! check playability playability ok ? For flap loaders (= access to CD drive possible) "fast" lens cleaning cleaning method is recommended check playability Standard repair procedure playability ok ? clean the lens check playability Play a CD...
Page 4
CD PLAYABILITY CHECK PLAYABILITY CHECK LIQUID LENS CLEANING Before touching the lens it is advised to clean the surface of the lens by blowing clean air over it. For sets which are compatible with CD-RW discs This to avoid that little particles make scratches on use CD-RW Printed Audio Disc ....7104 099 96611 the lens.
Page 5
CD PLAYABILITY CHECK EYE-PATTERN SIGNAL – JITTER MEASUREMENT CD DRIVE – LASER CURRENT MEASUREMENT Measure the signal on the input of the Signal processor The laser current can be measured as a voltage drop on a using an analog oscilloscope. Please find the exact resistor.
2 - 1 AMPLIFIER SPEAKERS Output power ........2 x 20 W RMS Bass reflex system ................800W PMPO Dimensions (w x h x d) . 190 x 292 x 182 (mm) Signal-to-noise ratio ......62 dBA (IEC) Frequency response ..63 – 16000 Hz, ± 3 dB GENERAL INFORMATION Impedance loudspeakers .........
Page 9
4 - 1 4 - 1 DISASSEMBLY DIADRAMS C. Remove CD Loader A. Remove CD Door C1: Remove screws SP 3x8 - 2 pcs. a.Power on the unit and open the CD door. C2: Remove screws SP 3x15 - 2 pcs. b.Remove the CD door cover.
Page 27
D501 9965 000 38843 BRIDGE RECTIFIER KBU604 6A IC501 9965 100 02288 IC TDA8947J (DBS17P)(SOT243-1)(/55/77) IC501 9965 100 09066 IC TDA8948J (DBS17P)(PHILIPS)(/12) JK201 9940 000 03989 ST PHONES JACK 3.5MM 7P JK601 9965 100 06430 AUX RCA JACK (RCA-207)(RED/WHT Q501...
Page 28
9965 000 38840 TR PNP 2SB764E-SSH-AE(TP) BOM FOR VERSION /37 9965 100 10624 FWM143/12 COMPLETE SPEAKER L 9965 100 10625 FWM143/12 COMPLETE SPEAKER R 9965 100 06436 REMOTE HANDSET MCS SECTION:55 Note: Only these parts mentioned in the list are normal...
13-1 VERSION LIST VERSION 1.1 ......ADD VERSION /77 PARTLIST VERSION 1.2 ......ADD VERSION /12 PARTLIST VERSION 1.3 ......ADD VERSION /37/55 PARTLIST...