There are four types of main board in according of destination for The front panel opens to the bottom of main unit. XR-M500R. In performing the repair, place the main unit on the base having the height exceeding 1 cm.
SECTION 2 This section is extracted from instruction manual. GENERAL (XR-M500R) Location of controls Security side The corresponding buttons of the unit qk TA button 16, 17, 18 control the same functions as those on ql SOUND button the card remote commander.
Säkerhetsföreskrifter Precauções •If you mount other Sony equipment with this •Si monta otro equipo Sony con esta unidad, es •Om du monterar annan Sony-utrustning till •É preferível montar este aparelho na posição unit, it is better to mount this unit in the lower preferible montar esta unidad en la posición más...
(XR-M500R) Connections Conexiones Anslutning Ligações Cautions Precauciones Säkerhetsföreskrifter Cuidado •This unit is designed for negative earth 12 V DC •Esta unidad ha sido diseñada para alimentarse •Denna bilstereo är endast avsedd för anslutning •Este aparelho foi concebido para funcionar operation only.
If the supplied power connecting cord can not Felaktig anslutning kan skada bilen. Kontakta be used with your car, consult your nearest Sony närmaste Sony-återförsäljare om den medföljande dealer. strömkabeln inte passar till din bil.
Page 10
Power connection diagram Diagrama de conexión de Strömanslutningsschema Diagrama de ligação de corrente alimentación Auxiliary power connector may vary depending Typen av yttre strömanslutning varierar från bil O conector auxiliar de corrente pode variar de on the car. Check your car’s auxiliary power till bil.
Connection diagram Diagrama de conexiones Kopplingsschema Diagrama de ligações Equipment used in illustrations Equipo utilizado en las ilustraciones Utrustning som visas i illustrationer Equipamento utilizado nas ilustrações (not supplied) (no suministrado) (medföljer inte) (não fornecido) Front speaker Rear speaker Power amplifier CD/MD changer Altavoz delantero Altavoz trasero...
SECTION 3 DISASSEMBLY • See page 3 for Servicing Notes. Note: Follow the disassembly procedure in the numerical order given. MECHANISM DECK (MG-25E-136) 1 screw flexible board Note: Don't pull out flexible board from front panel ass’y. 1 screw 2 front panel ass'y 4 two screws 5 mechanism deck (MG-25E-136)
Page 16
FRONT PANEL ASS’Y 1 cover (flexible) 2 flexible board (CN402) • Note for Installation of Flexible Board 2 flexible cover 1 Set the flexible board to be at the position in the figure. 3 front panel ass'y MOTOR BLOCK ASS’Y, CAM (R) ASS’Y 4 screw 2 screw 4 screw...
Page 17
SUB PANEL (XR) SUB ASS’Y 1 flexible board 2 screw (CN601) (PTT2.6 × 6) 3 sub panel (XR) sub ass'y 2 screw 2 two screws (PTT2.6 × 6) (PTT2.6 × 6) MAIN BOARD 1 two screws (PTT2.6 × 6) 1 screw (PTT2.6 ×...
SECTION 4 ASSEMBLY Note: Follow the assembly procedure in the numerical order given. 4-1. FRONT PANEL MACHINERY MOTOR BLOCK ASS’Y 2 stop ring 1 cam (L) 7 bracket (motor) ass'y hole 6 washer (M) switch 5 gear (C) 4 gear (B) 6 washer (M) Set bracket (motor) ass’y to be at the position in the...
Page 20
CAM (R) ASS’Y, MOTOR BLOCK ASS’Y 1 Supply the power to the motor. gray wiring – Voltage : 9V Violet wiring : MOTOR – Gray wiring : MOTOR + 2 Motor stops at full open position. violet wiring full open position 4 screw (PTT2.6 ×...
Page 21
4-2. MECHANISM DECK HOUSING 7 Holder the hanger by bending the claw. 5 Fit projection on C part. 1 Install the catch to the hanger. 2 Install the hanger onto two claws of the housing. hanger 4 Fit claw on B part. 3 Put the housing 6 Fit projection on D part.
Page 22
LEVER (LDG-A) / (LDG-B) shaft A shaft A shaft B shaft B shaft C 1 Fit the lever (LDG-A) on 3 type-E stop ring 2.0 shafts A – C and install it. 2 Fit the lever (LDG-B) on shafts A and B and install it.
Page 23
GUIDE (C) 2 guide (C) 1 three claws MOUNTING POSITION OF CAPSTAN/REEL MOTOR (M901) two precision screws (P2 × 2) capstan/reel motor (M901) 30˚...
SECTION 5 SECTION 6 MECHANICAL ADJUSTMENTS ELECTRICAL ADJUSTMENTS 1. Clean the following parts with a denatured-alcohol-moistened TEST MODE swab: playback head pinch roller <Set the Test Mode> rubber belt capstan 1. Turn ON the regulated power supply. (All LEDs on the set idler lights up, and the clock is displayed.) [OFF]...
XR-M500R/M550 • SIGNAL PATH : FM 7-2. BLOCK DIAGRAM – MAIN Section – : AM (MW/LW) : TAPE PLAY : BUS AUDIO IN CN300 (1/2) INPUT SELECT, FM MPX, AUDIO IN SPEANA (Page 29) ELECTRICAL VOLUME IC100 (XR-M500R) OUTSSL CN300 (2/2)
BUS-ON XTAL LCD-SW1 85 BUS-ON (Page 30) BU IN BU-IN D628 D611 SCHMITT TRIGGER BATT B+ IC606 C911, R982 TH601 SONY BUS INTERFACE IC501 BATT RESET RESET RESET SWITCH 12 13 DATA RESET SIGNAL BACK UP +5V GENERATOR RESET UNISO...
XR-M500R/M550 7-10. SCHEMATIC DIAGRAM – MAIN Board (3/4) – • See page 31 for Waveforms. • See page 42 for IC Block Diagrams. (Page 34) (Page 35) (Page...
(IC607) MUTE Audio line muting on/off control signal output terminal “H”: muting on System reset signal output to the liquid crystal display drive controller (IC607) and SONY bus SYSRST interface (IC501) “L”: reset Forward/reverse direction control signal output to the CXA2510AQ (IC401) N-ROUT “L”: forward direction, “H”: reverse direction...
Page 45
(LSW901 TA, LSW903 D-BASS: XR-M500R only) Key input terminal (A/D input) (LSW913 to LSW919, LSW921 to LSW925, S902) 6 to 3, SHUF 2, REP 1, AF, +, PTY DSPL (XR-M500R), DSPL (XR-M550), –, OFF, SOURCE, KEYIN1 MODE o keys input...
Page 46
101 to 103 Setting terminal for security code SCODE3 DSTSEL1, 104, 105 Destination setting terminal (A/D input) XR-M500R: fixed at “L”, XR-M550: fixed at “H” DSTSEL2 BOOT Serial data output to the liquid crystal display drive controller (IC607) DSP GAIN...
Page 47
Pin No. Pin Name Description Tuner system power supply on/off control signal output terminal TUNON “H”: tuner power on LED SW1, Security/operation side select control signal output to the liquid crystal display drive controller 115, 116 LED SW2 (IC607) 117, 118 Not used (open) —...
Page 48
Battery detect signal input from the SONY bus interface (IC501) and battery detect circuit BU-IN “L” is input at low voltage LINK-OFF Link on/off control signal output for the SONY bus “L”: link on, “H”: link off Not used (open) ILL-ON Power on/off control signal output of the illumination LED “H”: power on...
Page 49
— Power supply terminal (+5V) 90 to 96 PF6 to PF0 Not used (open) UNI-SO Serial data output to the SONY bus interface (IC501) UNI-SI Serial data input from the SONY bus interface (IC501) 99, 100 — Ground terminal UNICKI...
Page 50
Pin No. Pin Name Description P46/AN6/DA0 Not used (fixed at “L”) P47/AN7/DA1 Not used (fixed at “L”) AVSS — Ground terminal (for A/D converter) — Ground terminal 115 to 122 P17 to P10 Not used (open) Setting terminal for the CPU operational mode (fixed at “H”) Setting terminal for the CPU operational mode (fixed at “H”) Setting terminal for the CPU operational mode (fixed at “H”) 126 to 128...
SECTION 8 EXPLODED VIEWS NOTE: • -XX and -X mean standardized parts, so they • Items marked “*” are not stocked since they • Please refer to servicing notes (page 3) for may have some difference from the original are seldom required for routine service. Some system of TYPE A, B, C and D.
Page 52
(2) FRONT PANEL SECTION LCD902 LCD901 M500R Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark X-3378-768-1 PANEL (MAIN) ASSY, FRONT 3-045-739-01 BUTTON (SEEK) (M550) 3-045-781-01 BUTTON (RESET) (MAIN) (DISC +,> M, - DISC, .) 3-045-702-01 BRACKET (LCD) (MAIN) 3-045-734-01 CUSHION (SEEK) 1-694-685-11 CONDUCTIVE BOARD, CONNECTION 3-044-469-11 PANEL (SUB), FRONT (M500R)
SECTION 9 DISPLAY ELECTRICAL PARTS LIST NOTE: • Due to standardization, replacements in the • Items marked “*” are not stocked since they When indicating parts by reference number, please include the board. are seldom required for routine service. parts list may be different from the parts speci- fied in the diagrams or the components used Some delay should be anticipated when order- on the set.
Page 57
MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-3294-887-A MAIN BOARD, COMPLETE (M550) C139 1-164-346-11 CERAMIC CHIP A-3294-889-A MAIN BOARD, COMPLETE (M500R: TYPE C) C140 1-163-235-11 CERAMIC CHIP 22PF A-3294-890-A MAIN BOARD, COMPLETE (M500R: TYPE A) C141 1-164-505-11 CERAMIC CHIP 2.2uF...
Page 65
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark XR-M500R PARTS FOR INSTALLATION AND CONNECTION ************************************* 1-465-459-21 ADAPTER, ANTENNA (M500R) 1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER) (M500R) ANTENNA ADAPTER POWER CORD 1-792-194-11 CORD (WITH CONNECTOR) (POWER) (M550) ×...
Page 66
XR-M500R/M550 Sony Corporation 9-870-088-11 2000C0557-1 Mobile Electronics Division Company Printed in Japan C 2000. 3 Published by General Engineering Dept.
Need help?
Do you have a question about the XR-M500R and is the answer not in the manual?
Questions and answers