Section 11 − Parts List; Recommended Spare Parts - Miller Electric Bobcat 250 Owner's Manual

Trouble
Unstable or sluggish engine speeds.
Engine does not return to idle speed.
During operation in near freezing tem-
peratures, engine starts and goes to
idle but stalls after a few minutes.
During operation in severe cold weath-
er, engine starts and goes to idle but
stalls after a few minutes.

11-1. Recommended Spare Parts

Dia. Part
Mkgs.
. . . . . . . . . F1, F2 . . . 169296
. . . . . . . . . . . F6 . . . . . 021718
. . . . . . . . . . . . . . . . . . . . 215984
. . . . . . . . . . . . . . . . . . . . 230015
. . . . . . . . . . . . . . . . . . . . 230016
. . . . . . . . . . . . . . . . . . . . 066698
. . . . . . . . . . . . . . . . . . . . 215985
. . . . . . . . . . . . . . . . . . . . 067007
. . . . . . . . . . . . . . . . . . . . 230017
. . . . . . . . . . . . . . . . . . . . 066113
. . . . . . . . . . . . . . . . . . . . 199062
. . . . . . . . . . . . . . . . . . . . 198755
. . . . . . . . . . . . . . . . . . . . 198754
. . . . . . . . . . . . . . . . . . . . 215985
. . . . . . . . . . . . . . . . . . . . 198777
.
A complete Parts List is available on-line at www.MillerWelds.com.
Readjust throttle linkage if necessary. Check throttle solenoid TS1 for smooth operation.
Check oil level. Oil level should not exceed Full mark on dipstick. Fuel pump will operate erratically if
crankcase is overfilled.
Tune-up engine according to engine manual.
Remove weld and generator power loads.
Check throttle linkage for smooth, non-binding operation.
Have Factory Authorized Service Agent check idle module PC1, current transformer CT1, Engine Control
switch S2, and throttle solenoid TS1.
Treat fuel with isopropyl alcohol de-icer product.
Place Engine Control switch in the Run position until unit has been in operation and loaded for a peri-
od of time.
Install engine manufacturer's kit for cold-weather operation.
SECTION 11 − PARTS LIST
No.
Recommended Spare Parts
. . Fuse, Mintr Gl 25. Amp 125 Volt
. . Fuse, Mintr Gl 30. Amp 32 Volt
. . Filter, Fuel In−line .250 (Kohler)
. . Tune−up & Filter Kit, Kohler (Includes)
. . . . Air Filter Element, Kohler
. . . . Oil Filter, Kohler
. . . . Filter, Fuel w/Clamps & 1/4 in Fuel Line
. . . . Spark Plug . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . Air Filter Wrapper
. . Filter, Fuel In−line .250 (Robin)
. . Tune−up & Filter Kit, Robin (Includes)
. . . . Element, Air Filter
. . . . Filter, Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . Filter, Fuel w/Clamps & 1/4 Fuel Line
. . . . Spark Plug . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.
A complete Parts List is available at www.MillerWelds.com
Remedy
Description
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Quantity
2
1
1
1
1
1
1
2
1
1
1
1
1
1
1
OM-4419 Page 45