Whirlpool 98015194 Installation Instructions Manual

Hide thumbs

page of 12

/ 12
Bookmarks

Quick Links

Download this manual

Installation Instructions

30" (76.2 cm)

WARNING

Tip Over Hazard

A child or adult can tip the range and

be killed.

Connect anti-tip bracket to rear

range foot.

Reconnect the anti-tip bracket, if the

range is moved.

Failure to follow these instructions can

result in death or serious burns to

children and adults.

IMPORTANT:

Read and save these

instructions.

IMPORTANT:

Installer: Leave Installation

Instructions with the homeowner.

Homeowner: Keep Installation

Instructions for future reference.

Save Installation Instructions for local

electrical inspector's use.

Freestanding Gas Range

with standard clean oven factory set for use with L.P. gas

Write down the model and serial

numbers before installing range.

Both numbers are listed on the

model/serial rating plate located on the

frame behind the broiler door.

Model #

Serial #

Quick Reference

Table of Contents:

Pages

_________________________

__________________________

Before you start

Product dimensions

Cutout dimensions/requirements

Electrical requirements

4 - 5

Gas supply requirements

5 - 7

Installation steps

8 - 9

Gas conversions

Moving the range

If range does not operate

If you need assistance/service

98015194

www.whirlpool.com.

Part No. 98015194

Summary of Contents for Whirlpool 98015194

Page 1 Installer: Leave Installation model/serial rating plate located on the Instructions with the homeowner. frame behind the broiler door. Homeowner: Keep Installation Instructions for future reference. _________________________ Model # Part No. 98015194 Save Installation Instructions for local __________________________ Serial # electrical inspector’s use.
Page 2 Before you start... To eliminate the risk of burns or fire by — WHAT TO DO IF YOU reaching over heated surface units, SMELL GAS cabinet storage space located above the surface units should be avoided. If Your safety and the safety of •...
Page 3 Product Parts supplied for dimensions installation: anti-tip bracket Not shown: • literature pack • orifice spuds 26-3/4" (67.9 cm) depth with handle 2 screws (#10 x 1-1/2") 36" Proper gas supply (91.4 cm) connection must be cooktop 2 plastic anchors available.
Page 4 Recommended Electrical requirements In the State of Massachusetts, the ground method following installation instructions apply: For personal safety, this range is WARNING • Installations and repairs must be equipped with a power supply cord performed by a qualified or having a 3 prong ground plug. To licensed contractor, plumber, or minimize possible shock hazard, the cord gasfitter qualified or licensed by...
Page 5 Flexible metal appliance connector: If shutoff valve must be disconnected from WARNING local codes permit, a new CSA the gas supply piping system during any design-certified, 1/2" or 3/4" I.D., flexible pressure testing of that system at test metal appliance connector is pressures greater than 1/2 psig (3.5 kPa).
Page 6 All connections must be wrench-tightened. Making sure the anti-tip bracket is Check that range regulator installed: shutoff valve is in the “on” position. Open the manual shutoff valve in the gas • Look for the anti-tip bracket securely supply line. 90˚elbow attached to floor.
Page 7 Check operation of cooktop Open oven door and remove oven racks, oven tray, flame spreader and set Replace control panel and aside. tighten screws securely. Replace control Push in and turn each surface knobs. unit control knob to “LITE” position. The flame should light within 4 seconds.
Page 8 Gas conversion Place L.P . gas orifice spuds in plastic parts bag for future use and keep with Remove burner grates, burner caps, literature package. burners and screws. Lift cooktop. Gas conversions (from L.P . gas to Natural Reinstall burner tube and bracket gas;...
Page 9 Cooktop burners: Oven burner: Remove control knobs. Reinstall the control panel. Securely tighten the 4 a. Check that all control knobs are in the a. Open oven door and remove oven screws. Reinstall the control knobs. OFF position and remove the knobs. racks, oven tray, flame spreader and set aside.
Page 10 Moving the range: WARNING Tip Over Hazard A child or adult can tip the range and be killed. Connect anti-tip bracket to rear range foot. Reconnect the anti-tip bracket, if the range is moved. Failure to follow these instructions can result in death or serious burns to children and adults.
Page 11 For cleaning and If range does not If you need service: maintenance... operate: Maintain the quality built into your range by calling an authorized service company. Check that the circuit breaker is not If removing the range is necessary for tripped or the house fuse blown.