Koninklijke Philips Electronics N.V. or their respective owners. TP Vision Netherlands B.V. reserves the right to change products at any time without being obliged to adjust earlier supplies accordingly. PHILIPS and the PHILIPS’ Shield Emblem are used under license from Koninklijke Philips Electronics N.V.
EN 2 TPM14.2E LA Revision List 1. Revision List Manual xxxx xxx xxxx.0 • Chapter 6: Updated tables 6-2 White tone default settings • First release. 6-3 Display code overview. • Chapter 11: Added styling sheets11.20 6400 series 48", 11.26 6400 series 55", 11.30 7199 series 55",...
2-1. Here is product information available, as well as 40"/48"/55" 6900 series & 65"5900 series) getting started, user manuals, frequently asked questions and 2.5 Chassis Overview software & drivers. Table 2-1 Described Model Numbers and Diversity Mechanics Schematics 32PFS5709/12 4-37 4-38 10.4 10.15 10.17 11.1 32PFK5709/12...
Page 4
10.17 11.33 65PFS6659/12 4-27 4-44 4-46 10.7 10.8 10.14 10.17 11.34 65PFS7559/12 4-28 4-44 4-46 10.7 10.8 10.14 10.17 11.35 Directions for Use Directions for use can be downloaded from the following websites: http://www.philips.com/support http://www.p4c.philips.com back to 2014-Sep-26 div. table...
Page 5
Technical Specs, Diversity, and Connections TPM14.2E LA EN 5 Connections ( for 32"/40"/42"/47"/48" 6400/6500/6600/6710 series & 32"/40"/48"/55" 5700 series) Rear Connectors Side Connectors AUDIO IN USB1 NETWORK HDMI 1 HDMI3 ARC SERV .U HDMI2 ARC TV ANTENNA DIGITAL AUDIO OUT SCART (RGB/CVBS) USB 2...
Page 6
EN 6 TPM14.2E LA Technical Specs, Diversity, and Connections 4 - USB2 2.0 10 - RJ45: Ethernet 10000_022_090121.eps 090121 10000_025_090121.eps Figure 2-4 USB (type A) 120320 Figure 2-7 Ethernet connector - +5V - Data (-) - TD+ Transmit signal - Data (+) - TD- Transmit signal - Ground...
Page 7
Technical Specs, Diversity, and Connections TPM14.2E LA EN 7 Connections ( for 42"/47"/55" 7000 series & 55" 6400/6500 series & 65" 6600/7500 series & 40"/50"/58" 6800 series & 40"/48"/55" 6900 series & 65"5900 series) Rear Connectors Side Connectors AUDIO IN SCART SERV.U (RGB/CVBS)
Page 8
EN 8 TPM14.2E LA Technical Specs, Diversity, and Connections 4 - USB2 2.0 - RD+ Receive signal - CT Centre Tap: DC level fixation - CT Centre Tap: DC level fixation - RD- Receive signal 10000_022_090121.eps - GND 090121 - GND Figure 2-12 USB (type A) 10 - TV ANTENNA - In Signal input from an antenna, cable or satellite.
Page 9
Technical Specs, Diversity, and Connections TPM14.2E LA EN 9 - D0- Data channel 15 - DDC_SCL DDC clock 10 - CLK+ Data channel 16 - DDC_SDA DDC data 11 - Shield 17 - Ground 12 - CLK- Data channel 18 - +5V 13 - Easylink/CEC Control channel 19 - HPD...
Spare Parts the following points: • Route the wire trees correctly and fix them with the For the latest spare part overview, consult your Philips Spare mounted cable clamps. Part web portal. • Check the insulation of the Mains/AC Power lead for external damage.
Page 11
Precautions, Notes, and Abbreviation List TPM14.2E LA EN 11 result in sets which have the same CTN (Commercial Type 6 = play 16 : 9 format, 12 = play 4 : 3 Number; e.g. 28PW9515/12) but which have a different B.O.M. format number.
Page 12
6.5 MHz. L' is Band (VESA standard for communication I, L is all bands except for Band I channel and display). Using E-DDC, LG.Philips LCD (supplier) the video source can read the EDID Loudspeaker information form the display.
Page 13
SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4-wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board Spread Spectrum Clocking, used to reduce the effects of EMI...
EN 14 TPM14.2E LA Mechanical Instructions 4. Mechanical Instructions Index of this chapter: 4.8 Assembly/Panel Removal ( for 42"/47"/55" 7199/7500 4.1 Cable Dressing series & 55" 7300 series) 4.2 Service Positions 4.9 Assembly/Panel Removal ( for 65" 6600/7500 series) 4.3 Assembly/Panel Removal ( for 32"/42"/47" 6500 series & 4.10 Assembly/Panel Removal ( for 40"/50"/58"...
Page 15
Mechanical Instructions TPM14.2E LA EN 15 ECN1404 ECN700 CN8501 CN700 CN1404 MAIN POWER SUPPLY (1054) (1053) CN602 CN4250 ECN4250 CN410 ECN602 ECN401 LOUDSPEAKER ECN410 (1186) LOUDSPEAKER ECN401 (1185) KEYBOARD CONTROL (1057) 19612_100.eps Figure 4-2 Cable dressing (32" 6500 series) ECN700 CN8501 CN700 MAIN POWER SUPPLY...
Page 16
EN 16 TPM14.2E LA Mechanical Instructions ECN700 CN9101 CN8101 CN700 MAIN POWER SUPPLY (1053) (1054) CN602 CN4250 CN410 ECN401 ECN410 LOUDSPEAKER (1186) KEYBOARD CONTROL (1057) LOUDSPEAKER (1185) ECN401 19613_102.eps Figure 4-4 Cable dressing (40" 6400 series) ECN700 ECN1404 CN8101 CN9101 CN700 CN1404 MAIN POWER SUPPLY...
Page 17
Mechanical Instructions TPM14.2E LA EN 17 ECN9101 ECN700 CN700 CN9101 (1053) MAIN POWER SUPPLY (1054) CN602 CN4250 ECN602 ECN401 ECN602 KEYBOARD CONTROL (1057) IR LED BOARD LOUDSPEAKER (1056) LOUDSPEAKER (1184) (1184) 19616_100.eps Figure 4-6 Cable dressing (40" 6809 series) XA04 ECN700 CN9301 CN8101...
Page 18
EN 18 TPM14.2E LA Mechanical Instructions ECN1404 ECN700 CN8101 CN700 CN1404 MAIN POWER SUPPLY (1054) (1053) CN602 CN4250 CN410 ECN410 ECN602 EXA05 ECN401 LOUDSPEAKER (1186) LOUDSPEAKER ECN401 KEYBOARD CONTROL (1185) (1057) 19612_101.eps Figure 4-8 Cable dressing (42" 6500 series) ECN700 CN8101 CN9301 ECN1404...
Page 19
Mechanical Instructions TPM14.2E LA EN 19 EXA04 ECN700 ECN413 RF4CE Modeul ASSY (1076) CN8101 CN9301 ECN1404 CN700 CN1404 CN413 ECN409 MAIN POWER SUPPLY ECN408 (1053) (1054) CN602 CN4250 LOUDSPEAKER ECN602 (1186) ECN4250 LOUDSPEAKER (1185) KEYBOARD CONTROL (1057) IR/LED BOARD (1056) ECN602 19610_101.eps Figure 4-10 Cable dressing (42"...
Page 20
EN 20 TPM14.2E LA Mechanical Instructions AmbiLight AmbiLight AmbiLight (1062) (1063) (1063) RF4CE Modeul ASSY (1076) EXA04 EXA04 CN8101 CN8102 CN9301 ECN700 ECN1404 MAIN POWER SUPPLY (1054) CN700 ECN409 CN1404 CN413 (1053) CN401 ECN602 CN602 LOUDSPEAKER (1186) CN4250 ECN401 ECN602 KEYBOARD CONTROL (1057) LOUDSPEAKER...
Page 21
Mechanical Instructions TPM14.2E LA EN 21 ECN700 CN8101 CN9301 CN700 MAIN POWER SUPPLY (1054) (1053) CN602 CN4250 ECN602 ECN602 LOUDSPEAKER (1186) KEYBOARD CONTROL LOUDSPEAKER (1057) ECN401 (1185) 19614_101.eps Figure 4-14 Cable dressing (48" 6400 series) ECN700 CN9301 CN8101 ECN1404 CN700 CN1404 MAIN POWER SUPPLY (1054)
Page 22
EN 22 TPM14.2E LA Mechanical Instructions ECN700 CN8101 CN9301 ECN1404 CN700 CN1404 MAIN POWER SUPPLY (1054) (1053) CN410 ECN410 ECN602 ECN401 ECN602 LOUDSPEAKER (1186) KEYBOARD CONTROL (1057) LOUDSPEAKER EXA05 (1185) R LED BOARD 1056) OPTION BOARD (1058) ECN401 19612_103.eps Figure 4-16 Cable dressing (48" 6700 series) XA04 ECN700 ECN1404...
Page 23
Mechanical Instructions TPM14.2E LA EN 23 ECN9101 CN9101 ECN700 MAIN POWER SUPPLY (1054) CN700 (1053) CN602 CN4250 ECN401 ECN602 ECN602 KEYBOARD CONTROL ECN4250 (1057) IR/LED BOARD LOUDSPEAKER LOUDSPEAKER (1056) (1184) (1184) 19616_101.eps Figure 4-18 Cable dressing (50" 6809 series) CN8101 ECN700 CN700 MAIN POWER SUPPLY...
Page 24
EN 24 TPM14.2E LA Mechanical Instructions CN8101 ECN700 MAIN POWER SUPPLY CN700 (1054) ECN408 (1053) CN602 LOUDSPEAKER CN4250 (1186) ECN602 LOUDSPEAKER (1185) KEYBOARD CONTROL (1057) ECN401 19614_103.eps Figure 4-20 Cable dressing (55" 6400 series) EXA05 ECN700 CN8101 ECN4250 ECN1404 CN700 CN1404 MAIN POWER SUPPLY (1054)
Page 26
EN 26 TPM14.2E LA Mechanical Instructions AmbiLight AmbiLight AmbiLight (1070) (1070) (1071) RF4CE Modeul ASSY (1076) EXA04 EXA04 CN8101 CN8102 CN9301 ECN700 MAIN POWER SUPPLY ECN1404 (1054) CN700 ECN409 CN1404 CN413 (1053) CN401 ECN602 CN602 LOUDSPEAKER (1186) CN4250 ECN401 ECN602 KEYBOARD CONTROL (1057) LOUDSPEAKER...
Page 27
Mechanical Instructions TPM14.2E LA EN 27 ECN700 ECN401 KEYBOARD CONTROL (1057) MAIN POWER SUPPLY (1054) ECN409 CN700 CN401 (1053) ECN4250 CN602 CN4250 ECN602 ECN602 LOUDSPEAKER LOUDSPEAKER (1184) (1184) 19617_102.eps Figure 4-26 Cable dressing ( 65" 5900 series) EXA05 CN9101 CN8102 ECN1404 CN700 MAIN POWER SUPPLY...
Page 28
EN 28 TPM14.2E LA Mechanical Instructions AmbiLight AmbiLight AmbiLight (1070) (1070) (1071) EXA04 EXA04 RF4CE Modeul ASSY (1076) ECN700 CN9101 ECN413 ECN9101 CN8102 ECN1404 CN700 CN1404 CN413 ECN409 MAIN POWER SUPPLY (1054) ECN408 (1053) CN602 CN4250 ECN401 ECN602 ECN602 KEYBOARD CONTROL (1057) LOUDSPEAKER LOUDSPEAKER...
Page 29
Mechanical Instructions TPM14.2E LA EN 29 M4 × 10 Q3 × 8 M3 × 4 19610_102.eps Figure 4-29 Rear cover removal 4.3.2 Small Signal Board (SSB) Refer to Figure 4-30 for details. Caution: it is mandatory to remount all different screws at their original position during re-assembly.
Page 30
EN 30 TPM14.2E LA Mechanical Instructions 4.3.4 Speakers 4.3.9 AmbiLight control panel 1. Gently release the tapes that secures the speaker cables. 1. Unplug the connector from the AmbiLight control panel. 2. Unplug the speaker connectors from the SSB. 2. Gently release the clip that holds the panel and take it out 3.
Page 31
Mechanical Instructions TPM14.2E LA EN 31 4.4.2 AmbiLight Panel from the FFC connector that connect with the AmbiLight control panel [3]. 2. Lift the AmbiLight panel from the rear cover. Make sure that Refer to Figure 4-32 for details. wires and flat foils are not damaged while lifting the ambilight panel from the rear cover.
Page 32
EN 32 TPM14.2E LA Mechanical Instructions 4.4.5 Speakers 4.4.10 WIFI module 1. Gently release the tapes that secures the speaker cables. 1. Unplug the connector from the SSB. 2. Unplug the speaker connectors from the SSB. 2. Remove fixation screw that secure the WIFI module, gently 3.
Page 33
Mechanical Instructions TPM14.2E LA EN 33 4.5.2 AmbiLight Panel from the FFC connector that connect with the AmbiLight control panel [3]. 2. Lift the AmbiLight panel from the rear cover. Make sure that Refer to Figure 4-35 for details. wires and flat foils are not damaged while lifting the ambilight panel from the rear cover.
Page 34
When defective, replace the whole unit. Assembly/Panel Removal ( for 32"/48" 5700 series & 48"/55" 6400 series) Instructions below apply to the 32PFS5709/12, but will be similar for other 32"/48" 5700 series & 48"/55" 6400 series models. 4.6.1...
Page 35
Mechanical Instructions TPM14.2E LA EN 35 M4 × 10 Q3 × 8 M3 × 6 19613_108.eps Figure 4-37 Rear cover removal 4.6.2 Small Signal Board (SSB) Refer to Figure 4-38 for details. Caution: it is mandatory to remount all different screws at their original position during re-assembly.
Page 36
EN 36 TPM14.2E LA Mechanical Instructions 4.6.4 Speakers 1. Gently release the tapes that secures the speaker cables. 2. Unplug the speaker connectors from the SSB. 3. Take the speakers out. When defective, replace the both units. 4.6.5 Keyboard Control unit 1.
Page 37
Mechanical Instructions TPM14.2E LA EN 37 M4 × 10 Q3 × 8 M3 × 6 19613_110.eps Figure 4-39 Rear cover removal 4.7.2 Small Signal Board (SSB) Refer to Figure 4-40 for details. Caution: it is mandatory to remount all different screws at their original position during re-assembly.
Page 38
EN 38 TPM14.2E LA Mechanical Instructions 4.7.4 Speakers 1. Gently release the tapes that secures the speaker cables. 2. Unplug the speaker connectors from the SSB. 3. Take the speakers out. When defective, replace the both units. 4.7.5 Keyboard Control unit 1.
Page 39
Mechanical Instructions TPM14.2E LA EN 39 M4 × 10 Q3 × 8 M3 × 6 19613_112.eps Figure 4-41 Rear cover removal 4.8.2 AmbiLight Panel Refer to Figure 4-42 for details. 1. Gently release the clamps and unplug the two connectors [1, 2,3] that secure the ambilight panels.
Page 40
EN 40 TPM14.2E LA Mechanical Instructions 19613_113.eps Figure 4-42 Rear cover removal [1] 4.8.3 Small Signal Board (SSB) Refer to Figure 4-43 for details. Caution: it is mandatory to remount all different screws at their original position during re-assembly. Failure to do so may result in damaging the SSB.
Page 41
Mechanical Instructions TPM14.2E LA EN 41 4.8.5 Speakers 1. Remove fixation screws [1] that secure the base assy, pull out the base assy from the set. Then remove the fixation screws [2], [3] that secure the rear cover. Refer to 1.
Page 42
EN 42 TPM14.2E LA Mechanical Instructions M4 × 10 Q3 × 8 M3 × 6 19614_107.eps Figure 4-44 Rear cover removal 4.9.2 AmbiLight Panel Refer to Figure 4-45 for details. 1. Gently release the clamps and unplug the two connectors [1, 2,3] that secure the ambilight panels.
Page 43
Mechanical Instructions TPM14.2E LA EN 43 19614_108.eps Figure 4-45 Rear cover removal [1] 4.9.3 Small Signal Board (SSB) Refer to Figure 4-46 for details. Caution: it is mandatory to remount all different screws at their original position during re-assembly. Failure to do so may result in damaging the SSB.
Page 44
EN 44 TPM14.2E LA Mechanical Instructions 4.9.5 Speakers 1. Remove fixation screws [1] that secure the base assy, pull out the base assy from the set. Then remove the fixation screws [2], [3], [4] that secure the rear cover. Refer to 1.
Page 45
Mechanical Instructions TPM14.2E LA EN 45 M3 × 8 M4 × 6 Q3 × 8 D3 × 8 19616_103.eps Figure 4-47 Rear cover removal 4.10.2 Small Signal Board (SSB) Refer to Figure 4-48 for details. Caution: it is mandatory to remount all different screws at their original position during re-assembly.
Page 46
EN 46 TPM14.2E LA Mechanical Instructions 4.10.4 Speakers When defective, replace the whole unit. 1. Gently release the tapes that secures the speaker cables. 4.10.9 LCD Panel 2. Unplug the speaker connectors from the SSB. 3. Take the speakers out. 1.
Page 47
Mechanical Instructions TPM14.2E LA EN 47 M3 × 6 19617_104.eps Figure 4-50 Rear cover removal [1] 19617_105.eps Figure 4-51 rear cover removal [2] back to 2014-Sep-26 div. table...
Page 48
EN 48 TPM14.2E LA Mechanical Instructions 4.11.2 AmbiLight Panel the FFC connector that connect with the Ambilight control panel. 3. Lift the Ambilight panel from the rear cover. Make sure that Refer to Figure 4-52 for details. wires and flat foils are not damaged while lifting the ambilight panel from the rear cover.
Page 49
Mechanical Instructions TPM14.2E LA EN 49 4.11.4 Power Supply Unit (PSU) 4.11.9 LCD Panel Caution: it is mandatory to remount all different screws at their 1. Remove the rear cover and keyboard unit as described original position during re-assembly. Failure to do so may result earlier.
Page 50
EN 50 TPM14.2E LA Mechanical Instructions 19617_109.eps Figure 4-55 Keyboard control unit removal 4.12.2 Small Signal Board (SSB) Refer to Figure 4-56 for details. Caution: it is mandatory to remount all different screws at their original position during re-assembly. Failure to do so may result in damaging the SSB.
Page 51
Mechanical Instructions TPM14.2E LA EN 51 4.12.4 Speakers 1. Gently release the tapes that secures the speaker cables. 2. Unplug the speaker connectors from the SSB. 3. Take the speakers out. When defective, replace the both units. 4.12.5 Stand bracket 1.
EN 52 TPM14.2E LA Service Modes, Error Codes, and Fault Finding 5. Service Modes, Error Codes, and Fault Finding Index of this chapter: SAM in a decimal value. Every two soft-resets increase the 5.1 Test Points hour by + 1. Stand-by hours are not counted. 5.2 Service Modes 5.3 Stepwise Start-up Software Identification, Version, and Cluster...
Page 53
Service Modes, Error Codes, and Fault Finding TPM14.2E LA EN 53 Table 5-1 SAM mode overview Main Menu Sub-menu 1 Sub-menu 2 Description System Information Op Hour e.g. 00003 This represents the life timer. The timer counts normal operation hours, but does not count Stand-by hours.
Page 54
EN 54 TPM14.2E LA Service Modes, Error Codes, and Fault Finding Table 5-2 Factory mode overview Default value Item Item value 32" 40" 42" 47" 48" 55" 58" 65" Description F/W VERSION Press OK Displays the software versions of the supplier, Flash PQ, Smart Picture, BL Dimming, Source Meter, the Picture Quality checksum, the Dimming library, the Source meter library, the Flash AQ, the MTK, MCU and OAD software versions.
Page 55
Service Modes, Error Codes, and Fault Finding TPM14.2E LA EN 55 Default value Item Item value 32" 40" 42" 47" 48" 55" 58" 65" Description DUMP PQ FROM TV Press OK Saves the picture quality data to a file “pq.bin” to the root of a FAT formatted USB memory stick LOAD PQ to TV Press OK...
Page 56
EN 56 TPM14.2E LA Service Modes, Error Codes, and Fault Finding • 3.2 Child lock Not active / active. This is a combined item How to Navigate for locks. If any lock (channel lock, parental lock) is active, By means of the “CURSOR-DOWN/UP” knob (or the scroll it is indicated as “active”.
Page 57
A description on how to upgrade the main 1. ComPair helps to quickly get an understanding on how to software can be found in the DFU or on the Philips website. repair the chassis in a short and effective way.
Page 58
EN 58 TPM14.2E LA Service Modes, Error Codes, and Fault Finding • FUS_clustername_version.zip: Contains the “autorun.upg” which is needed to upgrade the TV main software and the software download application. • NVM_clustername_version.zip: Default NVM content. Must be programmed via ComPair. 5.5.7 How to Copy NVM Data to/from USB When copying data to and from a USB memory stick, the folder...
Page 59
Service Modes, Error Codes, and Fault Finding TPM14.2E LA EN 59 • Via the blinking LED procedure (when you have no 5.8.1 NVM Editor picture). See paragraph 5.7 The Blinking LED Procedure. • Via ComPair. In some cases, it can be convenient if one directly can change the NVM contents.
Picture mode Screen size Green Blue signal strength of at least 1 mV and a frequency of Normal (9000K) 32PFS5709/12 61.25 MHz (channel 3). 32PFK6509/12 • LATAM models: an NTSC M TV-signal with a signal 40PFS5709/12 strength of at least 1 mV and a frequency of 40PFK6409/12 61.25 MHz (channel 3).
Page 64
EN 64 TPM14.2E LA Alignments • HDCP keys are located in the NVM. If you are loading NVM with the ComPair tool, there is warning message displayed. New NVM EEPROMs are shipped with pre-loaded HDCP keys. 6.5.2 SSB Identification SSB’s of this chassis are identified by a “715” code on the SSB. 715Axxxx-Nnn-MMM-OOOO •...
C MP8126DF-LF-Z 550mA 13V TSSOP-16EP for LNB Power supply IC 7.1.2 TPM14.2E LA Architecture Overview For details about the chassis block diagrams refer Figure 9.1.An overview of the Philips MTK5591 architecture can be found in Figure 7-1. back to 2014-Sep-26...
Page 66
EN 66 TPM14.2E LA Circuit Descriptions 7.1.3 SSB Cell Layout DC/DC COMMON INTERFACE MT5591 HDMI HDMI HDMI NETWORK TUNER Headphone SERVICE SPDIF CONNECTOR SCART 19610_200.eps Figure 7-1 SSB layout cells (top view) back to 2014-Sep-26 div. table...
Page 67
Circuit Descriptions TPM14.2E LA EN 67 DC/DC COMMON INTERFACE MT5591 HDMI SERVICE CONNECTOR HDMI NETWORK SPDIF T/C TUNER S2 TUNER Headphone HDMI HDMI 19610_201.eps Figure 7-2 SSB layout cells (top view) back to 2014-Sep-26 div. table...
Page 68
EN 68 TPM14.2E LA Circuit Descriptions Power Supply Refer to figure Figure 7-3 for the power architecture of this platform. CN8101 ( FOR 715G6338/715G6385/715G6405/715G6169) LVDS AMP CN8101 ( FOR 715G6940) CN8101 ( FOR 715G6385/715G6432) CN8501 ( FOR 715G6161) CN8601 ( FOR 715G6743) CN8602 ( FOR 715G6743) CN9101 ( FOR 715G6555/715G6661) Platform power...
Page 69
7.2.2 Diversity specifications! This part is available in the regular market. Consult the Philips Service web portal for the order codes of the The diversity in power supply units is mainly determined by the panels. diversity in displays.
Page 71
Circuit Descriptions TPM14.2E LA EN 71 TDSY-G380D MT5591 S2 function MCU ARM System I2C MPEG/vedio/audio LNB power S2 tuner T2 demod decoder CDX2842ER Scaling IF_AGC Tuner I2C Vedio enhancement S2 Demond 3D comb CDX2842ER RF_AGC IP/IN/OP/ON HDMI 1.4 Tuner I2C MT5591 H 264 TS DATA...
Page 72
EN 72 TPM14.2E LA Circuit Descriptions • Multii-standard digital video decoder (MPEG-2, H.264, MPEG-4) • Integrated DVB-T/DVB-C/DVB-S channel decoder • Integrated CI+ • 3D graphic support OpenGL ES 2.0 • A multi-standard video decoder • HDMI 1.4a receiver with 3D support •...
IC Data Sheets TPM14.2E LA EN 73 8. IC Data Sheets This chapter shows the internal block diagrams and pin configurations of ICs that are drawn as “black boxes” in the electrical diagrams (with the exception of “memory” and “logic” ICs).
Page 74
EN 74 TPM14.2E LA IC Data Sheets Diagram 10-14-3 Peripheral, B03,MT5591IVDJ (IC U401-G) Block diagram MT5591IVDJ I nput ATSC/ JPEG/M P2/M P4/ L VDS/min-L VS/ Demux DVB-T/ DivX/H.264/VC-1/ V-by-One/ Panel DVB-C RM /AVS/VP6/VP8 Decoder s OD, TCON H 264 Encoder Tuner I nput NTSC/...
Page 75
IC Data Sheets TPM14.2E LA EN 75 Pinning Information MT5591IVDJ 7 7 58 ARDQ24 ARDQ30 ARDQM2 ARDQS3 ARCLK1# ARDQ29 ARDQ20 ARDQ10 ARDQS1 ARCLK0# ARDQ13 ARDQ11 ARDQS3 ARDQS1 ARDQ19 ARDQ17 ARDQ28 ARCLK1 ARDQ25 ARDQ5 ARDQ8 ARCLK0 ARDQ9 ARDQ0 RVREF_ ARDQS2 ARDQS0 ARDQ21 ARDQ23 ARDQ26...
Page 76
EN 76 TPM14.2E LA IC Data Sheets Pinning Information MT5591IVDJ AVDD33_ DDRV PDD5 PDD3 POCE0# PACLE SD_CMD GPIO26 GPIO1 GPIO3 GPIO5 MEMPLL DDRV PDD6 PDD2 POOE# PAALE GPIO42 GPIO0 GPIO2 GPIO6 GPIO25 FSRC_W EMMC_C ARDQ4 DDRV PDD7 PDD4 PDD0 PARB# SD_D3 SD_D1 GPIO47...
Page 77
IC Data Sheets TPM14.2E LA EN 77 Diagram 10-14-5 Speaker/Headphone B05, STA381BWTR (IC U602) Block diagram STA381BW OUT 1A OUT 1B 2.1 Channel Half MCLK OUT 2A Audio Processor Bridges OUT 2B Modulator STAudioFx FFX3A LRCKI STSpeakerSafe FFX3B Parametric EQ BICKI Binary Volume...
Page 78
EN 78 TPM14.2E LA IC Data Sheets Diagram 10-14-12 DVB/T2/C/S2 Tuner B12, CXD2839ER (IC U104) Block diagram Pinning information CXD2839ER Exposed-Pad (49: AVSS) 19610_304.eps Figure 8-6 Internal block diagram and pin configuration back to 2014-Sep-26 div. table...
Page 79
IC Data Sheets TPM14.2E LA EN 79 Diagram 10-15-1 System Power 1 B01, RT8079ZQW (IC U701) Block diagram RT8079ZQW Internal pull up Over Temperature current Protection UVLO Enable Comparator Shutdown Current EN Threshold Control Sense BOOT RT/SYNC Oscillator Control Driver Slope Logic Compensation...
Page 80
EN 80 TPM14.2E LA IC Data Sheets Diagram 10-16-1 System Power 1 B01, G5312QN1U (IC U103) Block diagram G5312 On-Time On-Time PGOOD PGOOD Off-Time Off-Time DISCHG DISCHG controller controller PGND PGND 0.75V 0.75V Reference Reference AGND AGND ILIM ILIM Pinning information ILIM ILIM AGND...
Page 81
IC Data Sheets TPM14.2E LA EN 81 Diagram 10-16-12 HDMI /Connector B12, SII9679CNUC (IC U713) Block diagram SiI9679 VDD5V_IN VCC33OUT Regulator RPWR5V Local I Local I Slave Logic SPI_MISO SPI Master SPI_MOSI Interface CEC_A SPI_CS0 SPI Slave (SiI9394 SPI_CS1 Dongle Only) SPI_CLK SPI Logic 1V2 Regulator...
Page 82
EN 82 TPM14.2E LA IC Data Sheets Personal Notes: 10000_012_090121.eps 110804 back to 2014-Sep-26 div. table...
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 155 10.13 A 380GLP30158SP0 PSU 10-13-1 D104 R140 PRIMARY SECONDARY R142 COLD RL101 R143 T 5A H/250V R201 F101 LF102:2 LF101:1 C210 FB601 R144 R202 C211 L603:1 C602 C601 TH101 D201 T101:1 R106 BD101 VA101...
Page 156
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 156 10-13-2 Power layout top 2014 05 20 LAYOUT TOP 380GLP30158SP0 19616_529.eps back to 2014-Sep-26 div.table...
Page 157
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 157 10-13-3 Power layout bottom 2014 04 16 LAYOUT BOTTOM 380GLP30158SP0 19616_530.eps back to 2014-Sep-26 div.table...
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 158 10.14 B 715G6080 SSB 10-14-1 System Power 1 System Power 1 VCCK VCCK 5 12 +12V AL DC POWER INPUT +12V AL 16 BRIGHT_ADJ: INVERTER_ON_OFF: OPWRSB: +12V +12V Normal:Max:+3V3, Min:0V Normal: High Normal: High DDRV DDRV...
Page 159
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 159 10-14-2 System Power 2 System Power 2 PANEL_VCC_ON/OFF 10,12 PANEL_VCC_ON/OFF 3,5,6,7,8,9,10,11,12,13,14,15,16 FB754 TUNER_LNB TUNER_LNB PVDD +12V_Audio 120R +5V_SW 3,6,7,10,14,15 +5V_SW PANEL_VCC DISEQC_OUT DISEQC_OUT +5V_SW +12V 13/18V_SW FB755 C762 13/18V_SW 120R 100UF 16V Q750 LNB_LINEDROP LNB_LINEDROP...
Page 165
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 165 10-14-8 DRAM Interface DRAM Interface U401B DDR3#3-64Mx16-1600MHz RVREF C BRDQM0 RVREF C BRDQM0 BRDQS0 BRDQS0 BRDQS0# BRDQS0# BRCLK0 BRDQ0 BRCLK0 BRDQ0 BRCLK0# BRDQ1 U401A BRCLK0# BRDQ1 BRDQ2 DDR3#1-256Mx16-1600MHz DDR3#2-256Mx16-1600MHz BRDQ2 ARDQM0 BRDQ3 DDRV DDRV...
Page 166
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 166 10-14-9 MII/GPIO/ServAD MII/GPIO/ServAD BL DIMMING BL DIMMING BL ON/OFF BL ON/OFF ARC1 EN ARC1 EN ARC2 EN ARC2 EN ARC3 EN U401H ARC3 EN CIGPIO0 DEMOD RST U401K ARC4 EN GPIO0 DEMOD RST ARC4 EN CIGPIO1...
Page 167
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 167 10-14-10 CI/Card CI/Card CI TSCLK CI TSCLK CI TSVAL CI TSVAL CI TSSY NC CI TSSY NC CI TSDATA0 CI Bus Power Control CI TSDATA0 PVR TSCLK PVR TSCLK PVR TSVAL PVR TSVAL PVR TSSY NC PCMCIA 5V Slot 10.3mm...
Page 168
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 168 10-14-11 HDMI/Connector HDMI/Connector +5V SW 3 4 6 7 10 15 +5V SW 3 4 5 6 7 8 9 10 11 12 13 15 16 ARC1 EN ARC1 EN ARC2 EN ARC2 EN ARC3 EN ARC3 EN...
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 173 10.15 B 715G6388 SSB 10-15-1 System Power 1 System Power 1 AU 12V AU 12V +5V STB +5V STB 5 6 8 VCCK VCCK 5 12 +12V AL DC POWER INPUT +12V AL 4 8 16 +12V BRIGHT ADJ:...
Page 174
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 174 10-15-2 System Power 2 System Power 2 PANEL_VCC_ON/OFF 10,12 PANEL_VCC_ON/OFF 3,5,6,7,8,9,10,11,12,13,14,15,16 TUNER_LNB TUNER_LNB +5V_SW 3,6,7,10,13,14,15 +5V_SW PANEL_VCC DISEQC_OUT DISEQC_OUT +5V_SW +12V 13/18V_SW FB754 13/18V_SW PVDD +12V_Audio 120R Q750 AON4421 LNB_LINEDROP LNB_LINEDROP +12V 3,8,16 +12V...
Page 181
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 181 10-15-9 DRAM Interface DRAM Interface U401B DDR3#3-64Mx16-1600MHz RVREF C BRDQM0 RVREF C BRDQM0 BRDQS0 BRDQS0 BRDQS0# BRDQS0# BRCLK0 BRDQ0 BRCLK0 BRDQ0 U401A BRCLK0# BRDQ1 BRCLK0# BRDQ1 BRDQ2 DDR3#1-256Mx16-1600MHz DDR3#2-256Mx16-1600MHz BRDQ2 ARDQM0 BRDQ3 DDRV DDRV...
Page 182
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 182 10-15-10 MII/GPIO/ServAD MII/GPIO/ServAD BL DIMMING BL DIMMING BL ON/OFF BL ON/OFF ARC1 EN ARC1 EN ARC2 EN U401H ARC2 EN U401K ARC3 EN ARC3 EN CIGPIO0 DEMOD RST ARC4 EN GPIO0 DEMOD RST ARC4 EN CIGPIO1...
Page 183
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 183 10-15-11 CI Card CI Card CI TSCLK CI TSCLK CI TSVAL CI TSVAL CI TSSY NC CI TSSY NC CI TSDATA0 CI TSDATA0 CI Bus Power Control PVR TSCLK PVR TSCLK PVR TSVAL PVR TSVAL PVR TSSY NC...
Page 184
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 184 10-15-12 HDMI/Connectoor HDMI/Connector +5V SW 3 4 6 7 10 13 15 +5V SW 3 4 5 6 7 8 9 10 11 12 13 15 16 ARC1 EN ARC1 EN ARC2 EN ARC2 EN ARC3 EN...
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 189 10.16 B 715G6842 SSB 10-16-1 System Power 1 System Power 1 2K14 Philips 6800 EU Model +5V STB 5 8 14 +5V STB VCCK VCCK 5 12 +12V AL DC POWER INPUT...
Page 190
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 190 10-16-2 System Power 2 System Power 2 PANEL_VCC_ON/OFF 10,12 PANEL_VCC_ON/OFF Audio VCC= +12V 3,5,6,7,8,9,10,11,12,13,14,15,16 Panel VCC=12V or 5V TUNER_LNB FB754 TUNER_LNB PVDD +12V_Audio 120R +5V_SW 3,6,7,10,14,15 +5V_SW PANEL_VCC DISEQC_OUT DISEQC_OUT +5V_SW +12V 13/18V_SW PANEL VCC...
Page 197
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 197 10-16-9 DRAM Interface DRAM Interface U401B DDR3#3-64Mx16-1600MHz RVREF C BRDQM0 RVREF C BRDQM0 BRDQS0 BRDQS0 BRDQS0# BRDQS0# BRCLK0 BRDQ0 BRCLK0# BRCLK0 BRDQ0 BRDQ1 BRCLK0# BRDQ1 U401A BRDQ2 DDR3#1-256Mx16-1600MHz DDR3#2-256Mx16-1600MHz BRDQ2 ARDQM0 BRDQ3 DDRV DDRV...
Page 198
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 198 10-16-10 MII/GPIO/ServAD MII/GPIO/ServAD BL DIMMING BL DIMMING BL ON/OFF BL ON/OFF ARC1 EN ARC1 EN ARC2 EN ARC2 EN U401H ARC3 EN ARC3 EN CIGPIO0 DEMOD RST U401K ARC4 EN ARC4 EN GPIO0 DEMOD RST AC18...
Page 199
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 199 10-16-11 CI Card CI Card CI TSCLK CI TSCLK CI TSVAL CI TSVAL CI TSSYNC CI TSSYNC CI TSDATA0 CI Bus Power Control CI TSDATA0 PVR TSCLK PVR TSCLK PVR TSVAL PVR TSVAL PCMCIA 5V Slot 10.3mm PVR TSSYNC...
Page 200
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 200 10-16-12 HDMI /Connector HDMI /Connector +5V SW 3 4 6 7 10 15 +5V SW 3 4 5 6 7 8 9 10 11 12 13 15 16 ARC1 EN ARC1 EN ARC2 EN ARC2 EN ARC3 EN...
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 205 10.17 E 715G6316 Keyboard control panel 10-17-1 Direction switch Key function Resistance Voltage Center 2-5 short Menu Right 1-5 short 0.5V Left 4-5 short 0.81V Down 3-5 short VOL- 1.65V CN01 6-5 short VOL+ 2.27V...
Page 206
Circuit Diagrams and PWB Layouts TPM14.2E LA EN 206 10-17-2 Key board layout Layout Keyboard control panel (top side) SW01 Layout Keyboard control panel (bottom side) 2013 09 17 Keyboard control panel 715G6316 layout top/bottom 19610_546.eps back to 2014-Sep-26 div.table...