Dismantling Instructions - Philips FW-C399 Service Manual

DISMANTLING INSTRUCTIONS

Dismantling of the Cassette Cover
1. Place screw driver
(flat side) between
the cover & cassette
door
2. Twist screw driver
3. Lift up and out
Figure 1
Dismantling the 3CDC Module and Tuner Board
1) Loosen the 4 screws, slide Cover top (pos 255) towards
the rear and remove it upwards.
2) Loosen 3 screws, slide the Panel right (pos 254) towards
the rear and remove it outwards. Do likewise for the Panel
left (pos 253).
3) Push the gear slowly towards the front as shown in figure
A
A
2-1
Figure 2
3 until the CDC tray starts to move out of the Front Cabinet
(pos 101). The CDC tray is now disengaged and can be
pulled out completely.
4) Remove the Cover Tray (pos 106) as shown in figure 4.
5) Loosen 4 screws A to remove the CDC Module (pos 1105)
as shown in figure 3.
6) Loosen 3 screws N (see figure 10) on the Panel Rear (pos
256) and release 2 catches C1 to remove the Tuner Board.
A
Turn the Gear towards the Front
till the CDC Tray starts to open
Figure 3
Dismantling of the Cover Front Display (pos 129) and Cover Front Ornamental (pos 130)
1) Cut a piece of packaging tape approximately 5cm width by
12cm length and tape its narrow side on to the top and
bottom side of the Volume knob (pos 139) as shown in
figure 5.
2) Place a small screw driver in between the tape & knob (see
figure 5) to give more leverage in pulling out the knob as
shown in figure 6.
3) Do likewise for the Jog Rotary knob (pos 138). You may
have to rotate the knob to provide the most exposed area
during application of the packaging tape.
4) Remove the Button Sound Control & Lightguide assembly
(pos 136 & 140) by releasing 3 catches.
Figure 5
2-1
Figure 4
5) Remove the 2 screws behind the knobs' locations and
release 4 catches to detach the Cover Front Display (pos
129).
6) Release 4 catches to detach the Cover Front Ornamental
(pos 130).
Notes: There is nothing are sandwiched between the
Front Cabinet (pos 101) and Cover Front Display
(pos 129) but it has to be removed in order to
reach the catches for the Cover Front
Ornamental (pos 130) .
Figure 6