Philips 170S7FS/00 Service Manual

Philips 17” lcd color monitor service manual

Hide thumbs Also See for 170S7FS/00:

Quick manual (3 pages)

User manual (100 pages)

Specifications (3 pages)

Table of Contents

Quick Links

Summary of Contents for Philips 170S7FS/00

Page 1: Table Of Contents
17” LCD Color Monitor Service Service Service 170S7FS/00 Horizontal Frequency 30- 83KHz TABLE OF CONTENTS Description Page Description Page Table Of Contents..........………….1 5.2 Software Flow Chart..........16 Revision List.............…………….2 5.3 Electrical Block Diagram......………………..18 Important Safety Notice……………….........3 6. Schematic Diagram…........………..20 1. Monitor Specifications………........…..4 6.1 Main Board……………………….…………………………20...
Page 2: Revision List
17” LCD Color Monitor GB: 3122 785 15842 Revision List Version Release Date Revision History TPV model T780KGMDBPPHNP Mar.20, 2006 Initial release T780KQMDBPPHNP...
Page 3: Important Safety Notice
NOT EXHAUSTIVE. Philips could not possibly know, evaluate and advise the service trade of all conceivable ways in which service might be done or of the possible hazardous consequences of each way. Consequently, Philips has not undertaken any such broad evaluation. Accordingly, a servicer who uses a service procedure or tool which is not recommended by Philips must first satisfy himself thoroughly that neither his safety nor the safe operation of the equipment will be jeopardized by the service method selected.
Page 4: Monitor Specifications
17” LCD Color Monitor 1. Monitor Specifications Screen type Active matrix - TFT LCD LM170E01-TLBB (LPL) Panel Type QD17EL07 (QDI) Size 430mm (17.0") LCD Panel Pixel pitch 0.264mm(H) x 0.264mm(V) Horizontal 140º, Vertical 140º (type) (LPL) Viewable angle (CR>=10) Horizontal 140º, Vertical 125º (type) (QDI) 8 ms (type) (LPL) Response time 8 ms (type) (QDI)
Page 5: Lcd Monitor Description
17” LCD Color Monitor 2. LCD Monitor Description The LCD MONITOR will contain a main board, PWPC board, keypad board, which house the flat panel control logic, brightness control logic and DDC. The power board will provide AC to DC Inverter voltage to drive the backlight of panel and the main board chips each voltage.
Page 6: Operation Instructions
17” LCD Color Monitor 3. Operation instructions 3.1 General Instructions Press the power button to turn the monitor on or off. The other control buttons are located at front panel of the monitor. By changing these settings, the picture can be adjusted to your personal preferences. - The power cord should be connected.
Page 7 17” LCD Color Monitor Back View...
Page 8: Adjusting The Picture
17” LCD Color Monitor 3.3 Adjusting the Picture This is a feather in all Philips LCD monitors. It allows an end user to adjust screen performance of the monitors directly through an on-screen instruction window. The user interface provides user-friendliness and ease-of-use when operating the monitor.
Page 9: Connecting To Your Pc
17” LCD Color Monitor 3.4 Connecting to the PC 1) Connect the power cord to the back of the monitor firmly. (Philips has pre-connected) VGA cable for the first installation.) 2) Connect to PC Turn off your computer and unplug its power cable.
Page 10: Input/Output Specification
17” LCD Color Monitor 4. Input/Output Specification 4.1 Input Signal Connector Pin NO. Description Pin NO. Description Red Video input DDC +5V Green Video input (SOG) Logic GND Blue Video input Ground Sense (GND) Serial data line (SDA) Cable Detect H.sync/H + V.sync Red Video Ground V.Sync...
Page 11: Panel Specification
17” LCD Color Monitor 4.3 Panel Specification 4.3.1 Display Characteristics LM170E01-TLBB Panel QD17EL07 Panel...
Page 12 17” LCD Color Monitor 4.3.2 Optical Characteristics LM170E01-TLBB Panel...
Page 13 17” LCD Color Monitor QD17EL07 Panel...
Page 14 17” LCD Color Monitor 4.3.3 Electrical Characteristics LM170E01-TLBB Panel QD17EL07 Panel...
Page 15: Block Diagram
17” LCD Color Monitor 5. Block Diagram 5.1 Monitor Exploded View...
Page 16: Software Flow Chart
17” LCD Color Monitor 5.2 Software Flow Chart...
Page 17 17” LCD Color Monitor MCU Initializes. 2) Is the EEprom blank? 3) Program the EEprom by default values. 4) Get the PWM value of brightness from EEprom. 5) Is the power key pressed? 6) Clear all global flags. 7) Are the AUTO and SELECT keys pressed? 8) Enter factory mode.
Page 18: Electrical Block Diagram
17” LCD Color Monitor 5.3 Electrical Block Diagram 5.3.1 Main Board Panel Interface (CN406) Keypad Interface NT68623MEFG- 64 (CN403) (Include MCU, ADC, OSD) (U401) H-SYNC TXD RGB V-SYNC EEPROM Crystal 12MHz D-Sub Connector AT24C16AN-10SU-2.7 (X401) (U403) (CN405) DB15_SDA DB15_SCL EEPROM M24C02-WMN6TP (U405)
Page 19 17” LCD Color Monitor 5.3.2 Inverter/Power Board...
Page 20: Schematic Diagram
HSIN R456 CH201209T-300 24C02_WP VGA-SCL 　 1/16W VGA-SDA ZD402 R436 C430 RI1- UDZS5.6B 2.2K 　 1/16W 22pF M24C02WMN6 FB405 GND_A 1/16W 　 GND_A GND_A GND_A GND_A Title 715G1712-1 Size Document Number PHILIPS 170S-ADC Input Date: Thursday, March 02, 2006 Sheet...
Page 21 RIGHT R460 AUTO GND_A TODEBUG 4.7K 1/16W 　 C415/NC TO RS232 C436 0.1uF C441 C437 C439 C438 C440 0.1uF 1000pF 1000pF 1000pF 1000pF 1000pF Title 715G1712-1 GND_A GND_A Size Document Number PHILIPS 170S-SCALER GND_A Date: Thursday, March 02, 2006 Sheet...
Page 22 GND_A 　 Q405 R414 AO3401L 100K 　 1/16W Q406 LCD-ON PMBS3904 FB408 C424 0.1uF 120 OHM C425 0.1uF R472 VGA_3V3 　 1/16W FB409/NC 120 OHM GND_A Title 715G1712-1 Size Document Number PHILIPS 170S-PANEL OUTPUT Date: Thursday, March 02, 2006 Sheet...
Page 23 VGA_3V3 120 OHM +12V GND_A FB707(NC) 120 OHM FOR 1.8V POWER USE STANDBY VOLUME MUTE OUT-L+ OUT-R+ OUT-L- OUT-R- CN702/NC 7x2PIN/2.0mm GND_A GND_A GND_A GND_A GND_A Title 715G1712-1 Size Document Number PHILIPS 170S-Scaler Power Date: Thursday, March 02, 2006 Sheet...
Page 24: Pwpc Board
17” LCD Color Monitor 6.2 Pwpc Board PN : PWPC1742LGR1 L902 S901 R931 C8B-R6H spotgap_NC 2R2_1206 R900 C931 R932 680K C900 0.001uF/250V 2R2_1206 3.3nF/500V T901 R901 VAR901 C908 L901 680K +12VCC CN901 0.47uF/275V varistor_NC AC SOCKET R904 R905 C920 D931 R902 BD901 1.5M/R1206...
Page 25 17” LCD Color Monitor PT801 C802 CN831 5pF/3KV R834 CONN +12V 6.2M 1/2W_NC 　 C803 C801 5pF/3KV R835 10pF/6KV R831 C820 C821 R822 R823 1K　 10K_1% 470uF/25V R824 C838 24:24:2400 7.5K_1%_NC C811 1000pF R836 10K_1% D833 D831 R804 BAV70/SOT23B BAV99 1/10W 　...
Page 26: Pcb Layout
17” LCD Color Monitor 7. PCB Layout 7.1 Main Board 715G1712 - F...
Page 27 17” LCD Color Monitor...
Page 28 17” LCD Color Monitor...
Page 29: Pwpc Board
17” LCD Color Monitor 7.2 Pwpc Board 715G1813-1...
Page 30 17” LCD Color Monitor...
Page 31: Key Board
17” LCD Color Monitor 7.3 Key Board 715G1755-1...
Page 32: Mechanical Instructions
17” LCD Color Monitor 8. Mechanical Instructions 1. Back View as Fig.1 Fig.1 2. Remove base as Fig.2- Fig.3 a. Remove 1 screw for hinge cover as Fig.2 b. Remove 5 screws for base as Fig.3 Fig.2 Fig.3...
Page 33 17” LCD Color Monitor 3. Remove rear cover as Fig.4- Fig.6 a. Remove 2 screws for back cover as Fig.4 b. Using the “1” type screwdriver to open the 3 clicks on bottom side as Fig.5 Fig.4 Fig.5 Fig.6...
Page 34 17” LCD Color Monitor 4. Remove shield as Fig.7 Remove 6 screws as Fig.7 Fig.7 5. Remove main and pwpc board as Fig.8 Remove 13 screws for main and pwpc board as Fig.8 Fig.8 6. Remove the bezel as Fig.9- Fig.11 a.
Page 35 17” LCD Color Monitor Fig.10 Fig.11 7. Remove the main frame as Fig.12- Fig.14 a. Remove 2 screws at the right of main frame Fig.12 b. Remove 2 screws at the left of main frame Fig.13 Fig.12...
Page 36 17” LCD Color Monitor Fig.13 Fig.14...
Page 37: Trouble Shooting
17” LCD Color Monitor 9. Trouble Shooting This page deals with problems that can be corrected by a user. If the problem still persists after you have tried these solutions, contact Philips customer service representative.
Page 38 17” LCD Color Monitor...
Page 39: Repair Flow Chart
17” LCD Color Monitor 10. Repair Flow Chart (1). No Power No power Press power key and look if the picture is normal Please reinsert and make sure the AC of 100-240 is normal Reinsert or check the power section Measure U701 Pin2=3.3V, U702 Pin2=1.8V? Replace U701, U702...
Page 40 17” LCD Color Monitor (2). No Picture No picture Measure U701 PIN2=3.3V, U702 PIN2=1.8V? Replace U701, U702 X401 oscillate waveforms are normal Replace X401 Check if the sync signal from computer is output and video cable is connected normally Input the sync signal of computer, or change the cable Replace U401...
Page 41 17” LCD Color Monitor (3). White screen White screen Measure Q406 base X401 oscillate is high level? waveform is normal Replace X401 Check Q406, Q405 is broken Check reset circuit of or CN406 solder? U401 is normal Check Correspondent component. Check Correspondent component.
Page 42 17” LCD Color Monitor 9.2.2 Power/Inverter Board No power Adapter Board Check CN951 pin 6/7 = 12V? Check AC line volt 100-240V Check AC input Check the voltage of C907 (+) Check bridge rectified circuit and F901 circuit Check start voltage for the pin 8 of IC901 Check R907 and IC901 Check the auxiliary voltage is bigger than 10V and smaller than 20V...
Page 43 17” LCD Color Monitor Inverter board No power Check C811 (+) =12V Check adapter section Check ON/OFF signal Check Interface section or main board Check U811 pin 2=12V? Check Q801 Check U811 Pin1/pin15 have the output of sawtooth wave at short time Check U811 pin 5/pin6 Replace U811 Check Q821/Q841 pin5/pin8 is 12V?
Page 44: Isp Instruction
17” LCD Color Monitor 11. ISP Instruction (1). Install the program software a. First decompressing files , as follow: b. Double – click , start to install as follows:...
Page 45 17” LCD Color Monitor...
Page 46 17” LCD Color Monitor c. There will be a shortcut key appears on the desktop. (2). Connect the ISP board as follow: Connect to the Philips Connect to 150S/170S/190S the PC LPT a. Double-click ，running the program as follows:...
Page 47 17” LCD Color Monitor b. Click icon, search the program” PHILIPS_170S_QDI_QD17EL0711_AP_036.HEX”, and click open: Note: If it is 170s model, you can select the (for QDI panel) (for LPL panel)
Page 48 17” LCD Color Monitor c. After click “OPEN”, there would be a dialog box, select...
Page 49 17” LCD Color Monitor d. Click icon, the writer is in processing… e. Until appears the follow Fig, writer completed.
Page 50: Ddc Instruction
17” LCD Color Monitor 12. DDC Instruction (1). Install software You must install the at the first. The processing as follows:...
Page 51 17” LCD Color Monitor...
Page 52 Note: After installation, you must restart the PC to take the setup effect. (2). Connect the DDC board as follow: Connect to the PC LPT Connect to the Philips 150S/170S/190S 12V Input a. Double-click ，appear as follow Figs：...
Page 53 17” LCD Color Monitor b. Click c. Key in the Serial Number printed on the barcode label, then click “OK” 14 codes, for example.
Page 54 17” LCD Color Monitor d. Unit appears the following Fig, writer completed.
Page 55 17” LCD Color Monitor 170S EDID Program 128 bytes EDID Data (Hex): 00 01 02 03 04 05 06 07 08 09 10 11 12 13 14 15 00 FF FF FF FF FF FF 00 41 0C 39 08 01 01 01 01 16: 0A 10 01 03 0E 22 1B 78 EE BE B5 A3 56 48 9A 24 32: 15 50 54 BF EF 80 71 4F 81 40 81 80 01 01 01 01 48: 01 01 01 01 01 01 30 2A 00 98 51 00 2A 40 30 70...
Page 56 1280x1024 @ 60Hz. <-x-Detailed Timing Descriptions-x-> <---Detailed Timing Descriptions---> Detailed Timing: FF (Monitor SN) ' AU 000001' Detailed Timing: FC (Monitor Name) 'Philips 170S' Detailed Timing: FD (Monitor limits) Min. V. rate: 56Hz Max. V. rate: 76Hz Min. H. rate: 30KHz Max.
Page 57: White Balance, Luminance Adjustment
17” LCD Color Monitor 13. White Balance, Luminance Adjustment Approximately 30 minutes should be allowed for warm up before proceeding White-Balance adjustment. 1. Required instruments: Chroma 7120、Chroma 2325（BGA265A）。 2. First connect the instruments together and turn on the LCD power. 3.
Page 58: Spare Parts List
17” LCD Color Monitor 14. Spare Parts List Different Spare Parts between LPL panel and QDI panel Location Part No. for TPV Description Located in CBPC780KGMPHP (LPL) CONVERSION BOARD CBPC780KQMPHP (QDI) CONVERSION BOARD AIC780KGMPHP (LPL) MAIN BOARD AIC780KQMPHP (QDI) MAIN BOARD 750GLG70E1B 11 (LPL) LPL 17"...
Page 59 EPA LABEL Q40G 582813 2A FAMILY SHEET Q41G780081312A 170S7 QSG Q44GSLIP00126A PAPER SLIPSHEET Q44GSLIP00127A PAPER SLIPSHEET Q45G 76 28A04 PHILIPS PE BAG Q52G6025 13 3 MYLAR Q70G1700813 1A CD MANUAL 040G 45762412B CBPC LABEL 051G 6 4500 705G 078057001 Q920 ASS'Y...
Page 60 U702 056G 563 31 AI1117D-1.8-EI U403 056G1133 24 AT24C16AN-10SU-2.7 U405 056G1133 34 M24C02-WMN6TP Q401 057G 417 4 PMBS3904/PHILIPS-SMT(04) Q406 057G 417 4 PMBS3904/PHILIPS-SMT(04) Q402 057G 417 13 T KEC 2N3906S-RTK/PS Q404 057G 417 13 T KEC 2N3906S-RTK/PS Q405 057G 763 1...
Page 61 17” LCD Color Monitor R402 061L0603103 CHIPR 10K OHM +-5% 1/16W R401 061L0603103 CHIPR 10K OHM +-5% 1/16W R403 061L0603104 RST SM 0603 RC0603 100K PM5 R R404 061L0603104 RST SM 0603 RC0603 100K PM5 R R434 061L0603105 RST SM 0603 RC0603 1M PM5 R R424 061L0603151 CHIPR 150 OHM +-5% 1/16W...
Page 62 17” LCD Color Monitor C436 065G040210415T 0402 MLCC 0.1UF K 16V C446 065G040210415T 0402 MLCC 0.1UF K 16V C702 065G040210415T 0402 MLCC 0.1UF K 16V C703 065G040210415T 0402 MLCC 0.1UF K 16V C704 065G040210415T 0402 MLCC 0.1UF K 16V C705 065G040210415T 0402 MLCC 0.1UF K 16V C706...
Page 63 U702 056G 563 31 AI1117D-1.8-EI U403 056G1133 24 AT24C16AN-10SU-2.7 U405 056G1133 34 M24C02-WMN6TP Q401 057G 417 4 PMBS3904/PHILIPS-SMT(04) Q406 057G 417 4 PMBS3904/PHILIPS-SMT(04) Q402 057G 417 13 T KEC 2N3906S-RTK/PS Q404 057G 417 13 T KEC 2N3906S-RTK/PS Q405 057G 763 1...
Page 64 17” LCD Color Monitor R432 061L0603102 CHIPR 1K OHM +-5% 1/16W R431 061L0603102 CHIPR 1K OHM +-5% 1/16W R428 061L0603102 CHIPR 1K OHM +-5% 1/16W R427 061L0603102 CHIPR 1K OHM +-5% 1/16W R426 061L0603102 CHIPR 1K OHM +-5% 1/16W R420 061L0603102 CHIPR 1K OHM +-5% 1/16W R472...
Page 65 17” LCD Color Monitor R452 061L0603750 CHIPR 75 OHM+-5% 1/16W R451 061L0603750 CHIPR 75 OHM+-5% 1/16W R454 061L0603750 9F 75OHM 1% 1/10W R455 061L0603750 9F 75OHM 1% 1/10W R456 061L0603750 9F 75OHM 1% 1/10W FB410 061L0805000 CHIPR 0OHM +-5% 1/10W R444 061L1206151 CHIP 150OHM 1/4W...
Page 66 17” LCD Color Monitor C407 065G040247312T 0402 MLCC 47NF K 16V C408 065G040247312T 0402 MLCC 47NF K 16V FB407 071G 56F102 K CHIP BEAD 1KOHM D401 093G 64 33 DIO SIG SM BAV99 (PHSE)R D406 093G 64 33 DIO SIG SM BAV99 (PHSE)R D405 093G 64 33 DIO SIG SM BAV99 (PHSE)R...
Page 67 17” LCD Color Monitor Power Board(LPL and QDI) Location Part No. for TPV Description PWPC1742QDR1P POWER BOARD CN831 033G8021 2D U 3.5mm WAFER CN833 033G8021 2D U 3.5mm WAFER CN851 033G8021 2D U 3.5mm WAFER CN853 033G8021 2D U 3.5mm WAFER IC902 056G 139 3A PC123Y22FZOF...
Page 68 17” LCD Color Monitor Q873 057G 760 4B PDTA144WK SOT346 Q841 057G 763 14 AM9945N Q821 057G 763 14 AM9945N RJ827 061L0805000 CHIPR 0OHM +-5% 1/10W RJ801 061L0805000 CHIPR 0OHM +-5% 1/10W R849 061L0805000 CHIPR 0OHM +-5% 1/10W R829 061L0805000 CHIPR 0OHM +-5% 1/10W R822 061L0805100...
Page 69 17” LCD Color Monitor R944 061L0805910 1F CHIP 9.1K OHM 1/10W 1% R945 061L0805910 1F CHIP 9.1K OHM 1/10W 1% RJ804 061L1206000 CHIPR 0 OHM +-5% 1/8W R926 061L1206000 CHIPR 0 OHM +-5% 1/8W R918 061L1206000 CHIPR 0 OHM +-5% 1/8W R907 061L1206103 CHIP 10KOHM 5% 1/4W...
Page 70 17” LCD Color Monitor D887 093G 64 44 S LL4148WP D885 093G 64 44 S LL4148WP ZD874 093G 39S 24 T RLZ 5.6B LLDS ZD975 093G 39S 25 T RLZ5.1B LLDS PW1742QDR1AIP POWER BOARD FOR AI CN901 006G 31500 EYELET T901 006G 31502 1.5MM RIVET...
Page 71 17” LCD Color Monitor KEPC Board (LPL and QDI) Vendor P/N Description KEPC780KE7P KEY BOARD CN101 033G3802 6H WAFER 6P RIGHT ANGLE PITCH 2.0 077G 600 1GCJ TACT SWITCH TSPB-2 -NP 077G 600 1GCJ TACT SWITCH TSPB-2 -NP 077G 600 1GCJ TACT SWITCH TSPB-2 -NP 077G 600 1GCJ TACT SWITCH TSPB-2 -NP...

Philips 170S7FS/00 Service Manual

1 Monitor Specifications

2 LCD Monitor Description

3 Operation Instructions

4 Input/Output Specification

5 Block Diagram

6 Schematic Diagram

7 PCB Layout

8 Mechanical Instructions

9 Trouble Shooting

10 Repair Flow Chart

11 ISP Instruction

1100 DDC Instruction

13 White Balance, Luminance Adjustment

14 Spare Parts List

Quick Links

TABLE OF CONTENTS

Related Manuals for Philips 170S7FS/00

Summary of Contents for Philips 170S7FS/00

Table of Contents