Advertisement
Table of Contents
- 1 Table of Contents
- 2 Safety Instructions
- 3 Total Wattage, Voltage and Installation
- 4 Features and Controls
- 5 Portability Kit Installation
- 6 Before Operation
- 7 Operating the Generator
- 8 Maintenance
- 9 Storage
- 10 Trouble Shooting
- 11 Specification
- 12 Limited Warranty
- 13 Service Information
- Download this manual
GASOLINE GENERATOR
IMPORTANT – Please make certain that
persons who are to use this equipment
thoroughly read and understand these
instructions and any additional instructions
provided prior to operation.
NOTE:
No refund or exchange once gasoline is placed
into the fuel tank.Warranty registration must be
complete within 30 days of purchase with proof
of purchase.
MBG1200
MBG2902
MBG3500
MBG5500
MBG6500/X
MBG7000/X
Operator's Manual
NOTE:
THERE IS A PERMANENT CONDUCTOR
BETWEEN THE GENERATOR (STATOR
WINDING) AND THE FRAME.
Advertisement
Table of Contents
Related Manuals for Mitsubishi MBG1200
Summary of Contents for Mitsubishi MBG1200
- Page 1 NOTE: No refund or exchange once gasoline is placed into the fuel tank.Warranty registration must be complete within 30 days of purchase with proof of purchase. MBG1200 MBG2902 Operator’s Manual MBG3500 MBG5500 MBG6500/X MBG7000/X...
-
Page 2: Table Of Contents
TABLE OF CONTENTS SAFETY INSTRUCTIONS ● Warning Labels TOTAL WATTAGE, VOLTAGE AND INSTALLATION FEATURES AND CONTROLS PORTABILITY KIT INSTALLATION BEFORE OPERATION OPERATING THE GENERATOR MAINTENANCE 11-12 ● Maintenance Schedule ● “How-To” Maintenance STORAGE TROUBLE SHOOTING SPECIFICATION LIMITED WARRANTY SERVICE INFORMATION... -
Page 3: Safety Instructions
SAFETY INSTRUCTIONS DANGER WARNING CAUTION DANGER indicates a potentially WARNING indicates a potentially CAUTION indicates a potentially hazardous situation which, if not hazardous situation which, if not hazardous situation which, if not avoided, WILL result in death or avoided, could result in death or avoided, may result in minor or serious injury. - Page 4 CAUTION CAUTION Improper treatment can damage the unit and shorten its life The unit should never be operated under these conditions To prevent surging that may possibly damage the equipment, do a. Uncontrolled change in engine speed. not allow engine to run out of fuel when electrical loads are b.
-
Page 5: Warning Labels
AVERTISSEMENT WARNING WARNING AVERTISSEMENT - 4 -... -
Page 6: Total Wattage, Voltage And Installation
TOTAL WATTAGE, VOLTAGE AND INSTALLATION electrician and in compliance with all applicable local electrical TOTAL WATTAGE codes. In order to prevent overloading and possible damage to your Proper use requires that a double throw transfer switch be installed generator it is necessary to know the total wattage of the connected by a licensed qualified electrician so that the building's electrical load. -
Page 7: Features And Controls
FEATURES AND CONTROLS Fuel Tank Cap Fuel Tank Fuel Gauge (optional) Fuel Tank Breathing Valve Engine Choke Lever Fuel Shut-off Air Filter Recoil Starter Oil Gauge Engine Shut-off 10a. Hour Meter (Only for MBG5500/7000/ MBG7000X) 120 V, 20 Ampere Duplex Receptacle or GFCI (optional) AC Protector... - Page 8 AC Protector and Circuit Breaker (12 and 13) Fuel Tank Breathing Valve (4) & Carbon Canister (19) Your generator is protected by an AC protector (expect MBG3500) Your generator may be equipped with breathing valve and carbon and circuit breaker. If the generator is overloaded or an external canister required by Section 213 of the Clean Air Act (42 U.S.C.
-
Page 9: Portability Kit Installation
PORTABILITY KIT INSTALLATION Step 1 Step 2 NUT, FLANGE M8 NUT, FLANGE M8 BRACKET, FOOT RUBBER FOOT BOLT, FLANGE M8×25 BOLT, FLANGE M8×16 Step 3 Step 4 BOLT, FLANGE M8×55 CUSHION, HANDEL PIN Ф3.2 HANDEL AXIAL, WHEEL GASKET, NYLON Φ8 WHEEL, 10"... -
Page 10: Before Operation
BEFORE OPERATION Fill the tank with clean, fresh unleaded Check Engine Oil Fuel Level automotive gasoline WARNING - Check fuel level. - If fuel level is low, refill with unleaded DO NOT attempt to start this engine without filling the crank case automotive gasoline. -
Page 11: Operating The Generator
OPERATING THE GENERATOR Start the Generator ELECTRIC START(optional feature) ON / MARCHE Turn the key to “START” Position until 1. Disconnect all electrical the engine starts,then release the loads from the generator; START / DÉBUT key so it could return to “ON” position automatically;... -
Page 12: Maintenance
MAINTENANCE 1. Maintenance Schedule DAILY INITIAL EVERY EVERY ITEM REMARKS 25HR 50HR 100HR Before Operation Check condition adjust gap and clean. Replace if ● Spark Plug necessary ● Check oil level Engine Oil ● ● Replace ● Air Filter Clean, replace if necessary Fuel ●... -
Page 13: How-To" Maintenance
Clean Air Filter 2. “How-To” Maintenance 1. Unscrew the air filter cover; Element Holder Engine Oil Change 2. Remove filter element and wash Element well in solvent; 1. Drain oil by removing the drain Oil Gauge 3. Pour a small amount of oil onto the plug and the oil gauge while filter element and gently squeeze out engine is warm. -
Page 14: Trouble Shooting
TROUBLE SHOOTING NOTE If your generator experiences a low engine oil condition, the engine will automatically shut off. Please check the oil first if you cannot start the generator. Condition Cause Corrective Action Loose spark plug Tighten plug properly Insufficient Loose cylinder head bolt Tighten bolt properly compression... -
Page 15: Specification
SPECIFICATION MODEL NO. MBG1200 MBG3500 MBG5500 Alternator Type / Voltage regulation: Brush/AVR Brush/AVR Brush/AVR Frequency: 60 Hz 60 Hz 60 Hz Voltage: 120 V 120/240 V 120/240 V Rated Watts: 1000 W 2800 W 5000 W Starting Watts: 1200 W... -
Page 16: Limited Warranty
LIMITED WARRANTY This Mitsubishi engine product carries a guarantee of 24 months. If 1. Problems caused by parts that are not original parts. your product develops a fault within this period, DO NOT return to store, you should, in the first instance contact our customer 2.