Table of Contents
Advertisement
WarNING
WarNING
Never reMOve, aDJuSt, Or LOOSeN tHe BOLtS, ScreWS aND/Or LaG
ScreWS ON tHe cOuNterBaLaNce (eND Or ceNter BearING BracketS)
SySteM Or BOttOM BracketS OF tHe DOOr. tHeSe BracketS are cON-
NecteD tO tHe SPrING(S) aND are uNDer extreMe teNSION. tO avOID
POSSIBLe Severe Or FataL INJury, Have aNy SucH WOrk PerFOrMeD
By a traINeD DOOr SySteMS tecHNIcIaN uSING PrOPer tOOLS aND
INStructIONS.
tOrQueMaSter
PLuS SPrINGS: Pawl knob(s) (located on the TorqueMaster
®
above the door) should be engaged to prevent the door from rapidly descending in case of
spring failure or forceful manual operation.
tOrSION SPrINGS: The torsion springs (located above the door) should only be adjusted by a
trained door systems technician. DO NOT attempt to repair or adjust torsion springs yourself.
exteNSION SPrINGS: A restraining cable or other device should be installed on the extension
spring (located above the horizontal tracks) to help contain the spring if it breaks.
2. DOOr BaLaNce: Periodically test the balance of your door. If you have a garage door opener,
use the release mechanism so you can operate the door by hand when doing this test. Start with
the door in the fully closed position. Lift the door to check its balance. Adjust Torquemaster
Extension spring(s), if door lifts by itself (hard to pull down) or if door is difficult to lift (easy to
pull down). DO NOT attempt to repair or adjust Torsion Springs yourself. To adjust Torquemaster
or Extension spring(s), refer to your installation instructions and owner's manual. If in question
about any of the procedures, do not perform the work. Instead, have it adjusted by a trained door
systems technician.
3. LuBrIcatION: The door should open and close smoothly. Ensure the door rollers are rotating
freely when opening and closing the door. If rollers do not rotate freely, clean the door tracks, re-
moving dirt and any foreign substances. Clean and lubricate (use a non-silicon based lubricant)
hinges, steel rollers and bearings. DO NOT lubricate plastic idler bearings, nylon rollers, door
track. DO NOT oil a cylinder lock, if actuation is difficult use a graphite dust to lubricate.
warranty
Lifetime Limited Warranty
Model 6100
Subject to the terms and conditions contained in this Lifetime Limited Warranty, Wayne-
Dalton ("Manufacturer") warrants the steel sections of the door, which is described at the top of
this page, for as long as you own the door against:
i)
The door becoming inoperable due to rust-through of the steel skin from the core of
the door section, due to cracking, splitting, or other deterioration of the steel skin, or
due to structural failure caused by separation or degradation of the foam insulation.
ii) Peeling of the original paint on the door as a result of a defect in the original paint or
in the application of the original paint coating, in cases where the door sections and
the original paint: (a) have not been subjected to adverse atmospheric conditions or
contaminates (such as salt water or other marine environment, or to toxic or abrasive
substances, including those in the air); (b) have been maintained in compliance with
Manufacturer's recommendations; and (c) have not been subject to physical abra-
sion, impacted by a hard object, or punctured (including without limitation "paint rub"
occurring in metal to metal contact and movement).
The Manufacturer warrants the factory applied wood overlay of the above-described
door, against defects in material and workmanship for a period of ONe (1) year from the date
of installation, provided all exterior surfaces and edges of the wood overlay are properly painted
according to Wayne-Dalton's Maintenance and Painting Instructions found in your Installations
Instructions and Owner's Manual. Bowing, checking and/ or cracking of the door overlay compo-
nents is not considered a defect, but is an uncontrollable characteristic of wood.
The Manufacturer warrants the garage door hardware (except springs) and the tracks of
the above-described door, for as long as you own the door, against defects in material and
workmanship, subject to all the terms and conditions below.
The Manufacturer warrants those component parts of the door not covered by the pre-
ceding provisions of this Lifetime Limited Warranty against defects in material and workmanship
for a period of ONe (1) year from the date of installation.
The Manufacturer warrants the factory-applied finish and the factory attached Decatrim
against fading and cosmetic changes from the time of installation for tWO (2) yearS. If the
sectional steel portion of door is re-stained or re-painted, the tWO (2) yearS warranty for the
factory-applied finish is void. The Model 6100 factory attached Decatrim is warranted against
warping, peeling, chalking, or delamination from the time of installation for tWO (2) yearS.
After a period of tWeNty (20) yearS, from time of installation, replacement of
Lifetime Limited Warranty materials will be pro-rated at 50 per cent of Manufacturer's published
list pricing at time of claim, and you must pay this amount.
This Limited Warranty is extended only to the person who purchased the product
and continues to own the premises (where the door is installed) as his/her primary residence
("Buyer"). This Limited Warranty does not apply to residences other than primary, or to com-
mercial or industrial installations, or to installations on rental property (even when used by a
tenant as a residence). This Limited Warranty is not transferable to any other person (even when
the premises is sold), nor does it extend benefits to any other person. As a result this Limited
Warranty does NOT apply to any person who purchases the product from someone other than
an authorized Wayne-Dalton dealer or distributor.
The Manufacturer will not be responsible for any damage attributable to improper stor-
age, improper installation, or any alteration of the door or its components, abuse, damage from
corrosive fumes or substances, salt spray or saltwater air, fire, Acts of God, failure to properly
maintain the door, or attempt to use the door, its components or related products for other than
®
end brackets
Please Do Not Return This Product To The Store. Contact your local Wayne-Dalton dealer. To find your local Wayne-Dalton dealer,
refer to your local yellow pages business listings or go to the Find a Dealer section online at www.Wayne-Dalton.com
its intended purpose and its customary usage. This Limited Warranty does not cover ordinary
wear. This Limited Warranty will be voided if the original finish is painted over, unless Manufac-
turer's preparation and painting instructions are followed explicitly. This Limited Warranty will be
voided if any holes are drilled into the door, other than those specified by the Manufacturer.
THIS LIMITED WARRANTY COVERS A CONSUMER PRODUCT AS DEFINED BY THE
MAGNUSON-MOSS ACT. NO WARRANTIES, ExPRESS OR IMPLIED (INCLUDING BUT NOT
LIMITED TO THE WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE)
WILL ExTEND BEYOND THE TIME PERIOD SET FORTH IN uNDerScOreD BOLD Face tyPe IN
THIS LIMITED WARRANTY, ABOVE.
•
Some States do not allow limitations on how long an implied warranty lasts, so the
above limitations may not apply to you.
Any claim under this Limited Warranty must be made in writing, within the applicable
warranty period, to the dealer from which the product was purchased. Unless the dealer is no
longer in business, a written claim to the Manufacturer will be the same as if no claim had been
made at all.
At the Manufacturer's option, a service representative may inspect the product on site,
or Buyer may be required to return the product to the Manufacturer at Buyer's expense. Buyer
agrees to cooperate with any representative of the Manufacturer and to give such representative
full access to the product with the claimed defect and full access to the location of its installa-
tion.
If the Manufacturer determines that the claim is valid under the terms of this Limited
Warranty, the Manufacturer will repair or replace the defective product. The decision about
or
®
the manner in which the defect will be remedied will be at the discretion of the Manufacturer,
subject to applicable law. THE REMEDY WILL COVER ONLY MATERIAL. THIS LIMITED WARRANTY
®
DOES NOT COVER OTHER CHARGES, SUCH AS FIELD SERVICE LABOR FOR REMOVAL, INSTAL-
LATION, PAINTING, SHIPPING, ETC.
Any repairs or replacements arranged by Manufacturer will be covered by (and subject
to) the terms, conditions, limitations and exceptions of this Limited Warranty; provided, however,
that the installation date for the repaired or replaced product will be deemed to be the date the
original product was installed, and this Limited Warranty will expire at the same time as if there
had been no defect. If a claim under this Limited Warranty is resolved in a manner other than
described in the immediately preceding paragraph, then neither this Limited Warranty nor any
other warranty from the Manufacturer will cover the repaired or replaced portion of the product.
THE REMEDIES FOR THE BUYER DESCRIBED IN THIS LIMITED WARRANTY ARE ExCLU-
SIVE and take the place of any other remedy. The liability of the Manufacturer, whether in con-
tract or tort, under warranty, product liability, or otherwise, will not go beyond the Manufacturer's
obligation to repair or replace, at its option, as described above. THE MANUFACTURER WILL
NOT UNDER ANY CIRCUMSTANCES BE LIABLE FOR SPECIAL, INCIDENTAL, OR CONSEQUENTIAL
DAMAGES, including (but not limited to) damage or loss of other property or equipment, personal
injury, loss of profits or revenues, business or service interruptions, cost of capital , cost of
purchase or replacement of other goods, or claims of third parties for any of the foregoing.
•
Some States do not allow the exclusion or limitation of incidental or consequential dam-
ages, so the above limitation or exclusion may not apply to you.
No employee, distributor, dealer, representative, or other person has the authority to
modify any term or condition contained in this Limited Warranty or to grant any other warranty
on behalf of or binding on the Manufacturer, and anyone's attempt to do so will be null and void.
Buyer should be prepared to verify the date of installation to the satisfaction of the
Manufacturer.
The rights and obligations of the Manufacturer and Buyer under this Limited Warranty
will be governed by the laws of the State of Ohio, USA, to the extent permitted by law.
11
Advertisement
Table of Contents
