Introduction Your Civic GX runs on Compressed You will find important safety Natural Gas (CNG), a highly information in this supplement and pressurized version of the same in the owner’s manual. This clean-burning natural gas used in information alerts you to potential many homes.
Indicator Lights Malfunction Indicator Lamp MALFUNCTION INDICATOR LAMP LOW FUEL INDICATOR This indicator comes on for a few seconds when you turn the ignition switch ON (II). If it comes on at any other time, it indicates one of the engine’s emissions control systems may have a problem.
Page 5
Fuel System Has a Leak on page (II). system. Have the vehicle checked by of this supplement. an authorized Honda Civic GX dealer This light comes on as a reminder as soon as possible. that you must refuel soon. The approximate driving distance...
Gauges Fuel Gauge The gauge may show slightly more or less than the actual amount. The outside temperature, fill method and ambient conditions may affect the pressure and temperature of the natural gas. FUEL GAUGE This gauge shows how much fuel you have.
Rear Seat Unlike the standard Civic, only two people can ride in the rear seat. They should sit in the outer seating positions and wear the lap/shoulder belts. There is no center seat belt. Instruments and Controls...
The CNG fuel system in your Civic, Honda Civic GX dealer. including the tank and hose, has been designed to hold gas at this pressure. It has also been tested for safety.
Fuel, Refueling Procedure CNG Identification Refueling Procedure When refueling, you should use a There are two methods of refueling, fuel fill nozzle that complies with CNG LABEL fast filling or slow filling. ANSI/AGA NGV-1-1994 standards. Nozzles are designed according to Fast filling is normally used in fuel their maximum fill pressure: P24 for stations for natural gas vehicles.
Page 10
Refueling Procedure Filling the Fuel Tank The refueling procedure can vary with the refueling station. The following explains the typical refueling procedure with fast fill equipment. With slow fill equipment, or other types of refueling equipment, follow the instructions on the equipment.
Page 11
If it continues to leak, have an authorized Honda Civic GX dealer inspect the sealing O-ring in the receptacle for damage and wear. Securely connect the CNG fill...
Page 12
Refueling Procedure Put the receptacle dust cap on the Refueling Station Information fuel receptacle securely. To obtain information about the locations of Compressed Natural Gas Push the fuel receptacle door (CNG) refueling stations, contact the closed until it latches. Natural Gas Vehicle Coalition (NGVC) at (202) 824-7360, extension If you are not sure how to operate 1.
Fuel system components in the Civic CNG comply with NFPA-52 standards. Your vehicle is equipped with genuine Honda component parts that have been designed and approved for use in a compressed natural gas vehicle. Never modify or replace any original components or parts with...
Fuel Cutoff System Manual Shut-off Valve should be done only by an authorized The in-tank fuel shut-off valve is Honda Civic GX dealer. controlled by the ignition switch. MANUAL SHUT-OFF VALVE When the ignition switch is in the LOCK (0) or ACCESSORY (I) position, the valve is closed, shutting off fuel flow to the engine.
Fuel Cutoff System, Carrying Cargo To turn off the valve, turn the lever Carrying Cargo Do not carry large, heavy or pointed one-quarter turn clockwise. Turn it The maximum load you can carry in objects in the trunk. They may counterclockwise to turn the valve your vehicle is 700 lbs (317 kg).
Starting the Engine Apply the parking brake. If the engine does not start within Starting in Cold Weather at High 15 seconds, or starts but stalls Altitude (Above 5,000 feet/ In cold weather, turn off all right away, repeat step 5 with the 1,600 meters) electrical accessories to reduce accelerator pedal pressed half-way...
Shift Lever Position Indicator way to the floor and hold it there Transmission (CVT) while starting the engine. Do not Honda’s Continuously Variable hold the ignition key in START automatic transmission’s unique (III) for more than 15 seconds. design provides a smooth, constant When the engine starts, release flow of power.
Page 18
S to L transmission. Avoid rapid accelera- N to D tion and have the transmission D to N checked by an authorized Honda L to S Move the lever. dealer as soon as possible. D to S S to D R to N The shift lever has six positions.
Page 19
Automatic Transmission (CVT) If you have done all of the above and Neutral (N) Use Neutral if you still cannot move the lever out of need to restart a stalled engine, or if Park, see Shift Lock Release in the it is necessary to stop briefly with main Owner’s manual.
Page 20
Automatic Transmission (CVT) Second (S) Selecting Second Maximum Allowable Speeds shifts the transmission into a lower The CVT shifts automatically to range of ratios for better accelera- maintain proper engine speed in any tion and increased engine braking. shift position. Use Second when you are going down a steep hill, or in stop-and-go When the vehicle reaches the...
Service your vehicle according to the required, take your vehicle to an intervals shown in the maintenance time and mileage periods on one of authorized Honda Civic GX dealer, schedule assume you will use your the Maintenance Schedules on the or a qualified NGV technician.
Page 22
Driving with a roof rack, or driving We recommend the use of Honda warranties. However, Honda in mountainous conditions. parts and fluids whenever you have recommends that all maintenance maintenance done.
Page 23
Service at the indicated distance miles x 1,000 or time whichever comes first. km x 1,000 months Replace engine oil Inspect fuel filter (high pressure) Replace fuel filter element (low pressure) Rotate tires (Check tire inflation and condition at least once per month) Replace engine oil filter Inspect front and rear brakes Check parking brake adjustment...
Page 24
Service at the indicated distance or time, whichever comes first. Refer to page to determine which schedule to use. 10,000 mi/16,000 km/1 yr Do items in A. Replace engine oil. 20,000 mi/32,000 km/1 yr Rotate tires. Do items in A, B. 30,000 mi/48,000 km Do item in D.
Page 25
150,000 mi/240,000 km/8 yrs Do items in A, C. See Spark Plug on page for inspection information. 160,000 mi/256,000 km/8 yrs Do items in A, B. See Dust and Pollen Filter in the Civic Sedan owner’s manual for 170,000 mi/272,000 km/9 yrs Do items in A.
Page 26
Service at the indicated distance miles x 1,000 or time whichever comes first. km x 1,000 months Replace engine oil Replace every 5,000 miles (8,000 km) or 6 months Replace engine oil filter Rotate tires (Check tire inflation and condition at least once per month) Inspect fuel filter (high pressure) Replace fuel filter element (low pressure)
Page 27
Service at the indicated distance or time, whichever comes first. Refer to page to determine which schedule to use. 5,000 mi/8,000 km/6 mos Do item in A. Replace engine oil. 10,000 mi/16,000 km/1 yr Do items in A, B. Replace engine oil filter. 15,000 mi/24,000 km Do item in E.
Page 28
6 yrs Replace brake fluid (independent of mileage). See Spark Plug on page for inspection information. Replace timing belt , inspect auto- 110,000 mi/176,000 km/7 yrs See Timing Belt in the Civic Sedan owner’s manual to determine tensioner, and water pump. need for replacement.
Required Maintenance Record (for Normal and Severe Schedules) You or the servicing dealer can record all completed maintenance here, whether you follow the schedule for normal conditions (page ) or severe conditions (page ). Keep the receipts for all work done on your vehicle. 5,000 mi Signature or dealer stamp 35,000 mi...
Page 30
Required Maintenance Record (for Normal and Severe Schedules) 65,000 mi Signature or dealer stamp 95,000 mi Signature or dealer stamp mi/km mi/km 104,000 km 152,000 km Date Date 70,000 mi 100,000 mi mi/km mi/km 112,000 km 160,000 km (or 5 years) Date Date 75,000 mi...
Page 31
Required Maintenance Record (for Normal and Severe Schedules) 120,000 mi Signature or dealer stamp 150,000 mi Signature or dealer stamp mi/km mi/km 192,000 km 240,000 km (or 6 years) Date Date 125,000 mi 155,000 mi mi/km mi/km 200,000 km 248,000 km Date Date 130,000 mi...
Engine Oil 5W-20 oil is formulated for year- Engine Coolant The SAE number tells you the oil’s round protection of your Honda, to Refer to the primary owner’s manual viscosity or weight. Select the oil for improve cold weather starting, and for engine coolant adding and your vehicle according to this chart.
Transmission Fluid Continuously Variable Transmission (CVT) The engine and transmission must be at normal operating temperature before checking the fluid level. Drive the vehicle at least 10 miles (16 kilometers) before checking. Park the vehicle on level ground. Insert the dipstick all the way into Shut off the engine.
Page 34
Have the to the time and distance recommen- transmission flushed and refilled dations in the maintenance schedule. with genuine Honda ATF-Z1 as soon as it is convenient. If you drive at high speed in high temperatures [above 95°F (35°C)],...
Fuel Tank The fuel tank meets the safety standards of NGV-2/NFPA-52/DOT HOOD FUEL TANK NHTSA FMVSS 304. The fuel tank should be inspected every three years after the production date of the fuel tank. Have a qualified technician inspect the fuel tank for damage or leaking.
Spark Plugs The spark plugs in your vehicle are a Specifications: SPARK PLUG special platinum-tipped design for NGK: PFR7N-D longer life. They only need to be replaced every 7 years or 105,000 Spark Plug Gap: miles (168,000 km), whichever 0.03 in (0.8 mm) 0.1mm comes first.
Tires The recommended cold tire Tire pressures for high speed driving pressures for most normal driving are shown below. Honda strongly conditions is shown below. recommends that you not drive faster than posted speed limits and Tire Size Cold Tire Pressure conditions allow.
Lights Replacing a High-mount Brake Push the new bulb straight into Light Bulb the socket until it bottoms. BULB Reinstall the socket. Turn it SCREW LINING clockwise until it locks. Make sure the new bulb is working. Reinstall the trunk lining. SOCKET Put the two fasteners into the holes on the upper part of the...
Lights, Storing Your Vehicle Storing Your Vehicle After storing your vehicle for an If you need to park your vehicle for extended period, and before starting an extended period, refer to the engine for the first time, open Storing in the primary owner’s the trunk and leave it open for Your Vehicle manual for information.
Changing a Flat Tire To change a flat tire, follow the Removing the Spare Tire Storing the Flat Tire instructions in the primary owner’s manual. Since your vehicle is TOOL KIT TRUNK FLOOR equipped with a fuel tank in the trunk, you should install the flat tire as described in this supplement.
Page 41
Changing a Flat Tire Remove the support plate and the wing bolt from the tool kit. Put the plate on the wing bolt. Secure the flat tire by putting the wing bolt through the hole in the center of the wheel, through the hole in the trunk lining, then screwing it into the divider.
(see Manual Shut-off Valve on page in this supplement). You cannot continue driving. Your vehicle should be towed to an authorized Honda Civic GX dealer (see in the Emergency Towing primary owner’s manual). Taking Care of the Unexpected...
Turn the manual shut-off valve to the OFF position and have your vehicle towed to an authorized Honda Civic GX dealer (see Emergency Towing in the primary owner’s manual). If the fuel system is not leaking or damaged, you can jump start the vehicle.
Specifications Dimensions Capacities Length 174.6 in (4,435 mm) Fuel tank service pressure 3,600 psi (24,800 kPa) at 70°F Width 67.3 in (1,710 mm) (21°C) Height 56.9 in (1,445 mm) Fuel tank capacity 3,000 psi: 7.2 gasoline gallons Wheelbase 103.1 in (2,620 mm) equivalent (GGE) Track Front...
Page 45
Specifications Air Conditioning Fuses Refrigerant type HFC-134a (R-134a) Interior Fuses in the primary owner’s Charge quantity 17.6 19.4 oz (500 550 g) manual. Lubricant oil type SP-10 Under-hood Fuses in the primary owner’s manual. Lights Headlights (HI/LO) 12 V 60/55 W (HB2) Alignment Front turn signal/side marker 12 V...
Incorporated. You can order in any of three ways: Service Manual Detach and mail the order form on the right half of this page 61S5A07 2001-2003 Honda Civic GX 4 Door $35.00 Call Helm Inc. at 1-800-782-4356 (credit card orders only)
Authorized Manuals Valid only for sales within the U.S. Canadian owners should contact their authorized Honda dealer. ORDER TOLL FREE: 1-800-782-4356 (NOTE: For Credit Card Holder Orders Only) Monday-Friday 8:00 A.M. 6:00 P.M. EST MINIMUM CREDIT CARD PURCHASE $10.00 By completing this form you can order the materials desired. You can pay by check or money order, or charge to your credit card.
Page 49
Authorized Manuals NOTE: Dealers and Companies please provide dealer or company name, and also the name of the person to whose attention the shipment should be sent. For purchases outside U.S.A. please write to the address shown below for a quotation. Customer Name Attention Apartment Number...
Page 50
ADDRESS The information and specifications STREET included in this publication were in effect at the time of approval for printing. Honda Motor Co., Ltd. CITY STATE/PROVINCE ZIP CODE/ reserves the right, however, to POSTAL CODE discontinue or change specifications V.