Troubleshooting; Troubleshooting Chart - Yamaha AR210 Owner's/Operator's Manual

T
ROUBLESHOOTING
If any trouble happens on your boat, use this section to check for possible cause. If you cannot
find the cause or if the procedure for replacement or repair is not described in this owner's man-
ual, ask your Yamaha Boat dealer or qualified mechanic for the proper service.
The Troubleshooting Chart contains "TROUBLE," "POSSIBLE CAUSE," "REMEDY," "REFER
PAGE."
Check the possible cause and remedy, and also the referred page for the maintenance steps to
solve the trouble.

TROUBLESHOOTING CHART

TROUBLE
• Starter motor • Fuse
does not turn
over
• Battery
• Jet pump
• Starter
• Shift lever
• Starter motor • Engine shut-off
turns over/
engine does
not start
• Fuel
• Fuel tank
• Spark plug
• Spark plug cap
• Crankcase
• Fuel filter
• Choke

TROUBLESHOOTING

POSSIBLE CAUSE
Burned out
Run down
Poor terminal
connections
Not latched
cleanout hatch
Faulty
component
Not in Neutral
Clip on cord is not
switch in place
Empty
Stale or
contaminated
Water or dust
collected
Built-up pressure
Fouled or defective
Not fitted or loose
Filled with fuel
Filled with water
Clogged or water
collected
Knob automatically
returns
& S P
PECIAL
REMEDY
• Replace the fuse and
check wiring
• Recharge
• Tighten as required
• Latch securely
• Have serviced at
Yamaha dealer
• Shift to Neutral
• Install clip in engine
shut-off switch
• Refill as soon as possible*
• Have serviced at
Yamaha dealer
• Have service at
Yamaha dealer
• Open the fuel tank filler
cap and release pressure
• Clean or replace
• Fit properly
• Have serviced at
Yamaha Dealer
• Crank engine with
spark plug out until clean
• Have serviced at
Yamaha Dealer
• Tighten the choke cable
tension, adjust nut
5-1
ROCEDURES
Page
4-15
4-17
4-17
3-14
4-15
5
5-5
2-7
2-5
3-3
4-7
4-7