Page 1
No.9006E DV-W1U SERVICE MANUAL SPECIFICATIONS AND PARTS ARE SUBJECT TO CHANGE FOR IMPROVEMENT DVD PLAYER . CD RECORDER Digital Media Products Division, Tokai 2000 Get other manuals https://www.bkmanuals.com...
Page 2
Leakage Current Hot Check are issued from time to time. For the latest information, always consult the current HITACHI Service Manual. A Plug the AC line cord directly into a AC120V, 60Hz subscription to, or additional copies for, HITACHI Service...
Page 3
Notes When Using Service Manual The following shows the contents to be noted when using service manual: 1. Value units used in parts list 3. Identifications of sides A/B in circuit board diagrams Certain symbols are indicated below for value units of resistors, capacitors and coils in parts list.
2. Comparison with Previous Model DV-W1U DV-P250U Dimension 435mm(W) × 330mm(D) × 81mm(H) 434mm(W) × 315mm(H) × 98mm(D) Weight 4.8kg 3.9kg Region Code OSD languages 3 (English,French,Spanish) 3 (English,French,Spanish) Playing Default English English Power Requirement (Common Power Supply) 120V 60Hz...
Page 7
Virtual Surround (Wide)2ch Source Analog Analog Surround Select by Remote Controller on/off Dynamic Range Compression(only AC-3) MP3 Read — — Audio Input Connector — Digital Audio Input-Optical — Digital Audio Input-Coaxial — Playback Features Jog/Shuttle on Front Panel — New Disc Navigation 1 moving video without audio Multi Speed Scan (Forward) Forward 1/2,1/8, 1×...
3. Troubleshooting 3-1. VIDEO CIRCUIT NO IMAGE ARE SIGNALS CHECK SIGNAL OUTPUT FROM VIDEO CABLE/ MONITOR OUTPUT TERMINAL? ARE SIGNALS CHECK VIDEO OUTPUT OUTPUT FROM PG2201 SECTOR (PG1302/ J1307/ J1302/ pins 17, 15, 13, 11, 9, 7, J1306/ J1361) OF JAK PWB ARE SIGNALS OUTPUT FROM CHECK IC3301/ IC3302 of...
3-2. AUDIO CIRCUIT NO SOUND IS THERE BREAKDOWN BEFORE IC1201 AN IMAGE? ARE IC1501 ARE IC1505 pins 8, 9, 15, 20 CHECK IC1505 OR +8V LINE ETC. pin 3 +5V & pin 1 +8V BREAKDOWN OF IC1506 ARE THERE SIGNALS AT IC1501 pins 1, 2, 3, 5 AND BREAKDOWN OF IC1201 IC1507 pins 40, 41, 45,...
3-3. RECORDER AUDIO CIRCUIT NO SOUND ARE THERE SIGNALS BREAKDOWN CRD-RA1 AT PG1304 pins 1, 3? ARE IC1512 pins 6, 12 CHECK Q3510, Q3511 AND Q3512 AND IC1513 pins 6, 12 ARE THERE SIGNALS CHECK IC1512 AND IC1513 AT IC1507 pins 5, 10 AND IC1508 pins 5, 10? CHECK IC1507, IC1508,...
4. Instructions on Use (The following are extracts from the instruction manual. ) FRONT FRONT <Display> Remaining disc playback time Lights when the stop position or recordable time is in memory. Lights when the input level exceeds Playback control 0 dB during dubbing or recording. Lights when the angle Double-speed dubbing (x2) Repeat play...
Page 12
REAR SIDE Audio input jacks Audio output jacks Coaxial digital audio output jack Surround audio output jacks Coaxial digital audio input jack Video output jack Optical digital audio output connector S-video output connector Component video Optical digital audio input connector output jacks VIDEO CENTER...
D I S A S S E M B L Y CHAPTER 2 1. Before Starting Disassembly 1) Unplug the power cord from the AC outlet. SW-CDR FLHP 2) [Removal procedure] (CDR-SWITCH) (LCD DISPLAY) If a special procedure is required when dismantling BOARD BOARD any component, it is indicated using numbers.
Disassembly Procedure Diagrams Item Parts to remove Side cover (L), (R) and Top cover REMOVE THE SCREW SIDE COVER (L) TOP COVER SIDE COVER (R) REMOVE SEVEN SCREWS REMOVE SCREW Fig. 2-1 Rear panel REMOVE REAR PANEL EIGHT SCREWS Fig. 2-2 2 - 2 Get other manuals https://www.bkmanuals.com...
Item Parts to remove JAK board and REG board REMOVE BOARD FOUR SCREWS DISCONNECT FIVE CONNECTOR REMOVE TWO SCREWS REG BOARD DISCONNECT FIVE CONNECTOR Fig. 2-3 Front cover, IF, FLHP, SW-DVD and SW-CDR board SW-CDR BOARD REMOVE FRONT COVER SCREWS DISONNECT TWO CONNECTORS FLHP BOARD...
Item Parts to remove DVD-ROM and DEC board Note: To open the tray of DVD-ROM drive, insert a DISCONNECT Philips screwdriver into hole (A), and turn it REMOVE FIVE FOUR clockwise. CONNECTORS SCREWS Close the tray when removing the DVD-ROM REMOVE FOUR SCREWS drive.
CHAPTER 3 E X P L O D E D V I E W 1. CABINET SECTION SW-DVD [DVD SWITCH] P.C.B FLHP [LCD DISPLAY] P.C.B SW-CDR [CDR SWITCH] P.C.B JAK [REAR JACK] P.C.B [INTERFACE] REG[REGULATOR] P.C.B P.C.B [DECK] P.C.B 3 - 1 Get other manuals https://www.bkmanuals.com...
Page 29
DEC CIRCUIT BOARD DEC [DECK] -SIDE A- DEC [DECK] -SIDE B- [PATTERN No.JA1755-4] 6 - 16 6 - 17 6 - 18 Get other manuals https://www.bkmanuals.com...
Page 30
IDENTIFICATION OF PARTS LOCATION SW-DVD CIRCUIT BOARD Symbol Parts Symbol Parts Symbol Parts Symbol Parts Symbol Parts Symbol Parts Symbol Parts Location Location Location Location Location Location Location C1514 B-1A C2242 B-5B Q1505 B-3A R1691 B-2D R3220 B-4D RA1602 A-2E C1111 A-5D C1515...
Page 31
JAK CIRCUIT BOARD IDENTIFICATION OF PARTS LOCATION Symbol Parts Symbol Parts Symbol Parts Symbol Parts Symbol Parts Location Location Location Location Location C1586 B-3E C3521 B-3F R1316 B-1D R1577 A-3E BL1303 B-3F C1589 B-2B C3522 B-1F R1317 B-1D R1578 A-3E BL1307 B-1F C1590...
Page 32
IF, REG CIRCUIT BOARDS IDENTIFICATION OF PARTS LOCATION Symbol Parts Symbol Parts Symbol Parts Symbol Parts Location Location Location Location D0053 R0007 C1903 BL0001 D0054 R0008 CN1901 C1904 BL0002 D0055 R0009 C1909 BL0003 D0056 R0010 C1911 BL0004 D0057 R0011 C1914 BL0052 D0061 R0012...
Page 33
FLHP CIRCUIT BOARD IDENTIFICATION OF PARTS LOCATION FLHP Symbol Parts Symbol Parts Location Location R1718 B-1E C1701 A-1B R1719 B-1B C1703 B-1C R1720 B-2C C1704 B-2A R1721 B-2A C1705 A-1A R1722 B-1D C1707 B-1A R1723 B-1D C1709 B-1B R1724 B-1D C1710 B-2B R1725...