Sealey SA841.V2 Instructions

Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions,
and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
Refer to Wear eye
instruction protection
manual
1. SAFETY
Familiarise yourself with the application and limitations of the air hose reel, as well as the specific hazards.
9
WARNING! Disconnect the air hose reel from the air supply before servicing or performing any maintenance.
‰
Maintain the air hose reel in good condition (use an authorised service agent).
9
Replace or repair damaged parts. Use recommended parts only. Unauthorised parts may be dangerous and will invalidate the
9
warranty.
Locate and fix the air hose reel in a suitable working area, ensure that the correct fixings are used to secure the unit to the wall.
9
DO NOT position the hose in direct sun light, or in areas of extreme heat or cold.
8
DO NOT mount inside spray booth/oven.
8
Ensure that there is adequate lighting.
9
WARNING! Ensure maximum air pressure is not exceeded.
‰
WARNING! DO NOT over extend the hose as this will cause the mechanism to malfunction, preventing the hose from retracting.
‰
Keep extended air hose away from heat, oil and sharp edges.
9
Check hose for wear before each use and ensure all connections are secure.
9
Keep the unwound air hose away from wet, damp, oily surfaces.
9
WARNING! Always wear approved eye protection when operating the air hose reel.
‰
Maintain correct balance and footing. Ensure the floor is not slippery and wear non-slip shoes.
9
Remove ill fitting clothing. Remove ties, watches, rings, other loose jewellery and contain and/or tie back long hair.
9
Keep children and unauthorised persons away from the working area.
9
DO NOT operate the air hose reel if any parts are damaged or missing as this may cause failure and/or personal injury.
8
DO NOT use the air hose reel for any purpose other than that for which it is designed.
8
DO NOT operate the air hose reel when you are tired or under the influence of alcohol, drugs or intoxicating medication.
8
DO NOT direct air from the air hose at yourself or others.
8
When not in use, ensure the air supply is turned off and tools disconnected. Disconnect from the air supply and retract the hose into
9
case.
WARNING! DO NOT dismantle the hose reel casing. To do so may result in damage to the appliance and/or personal injury and will
‰
invalidate the warranty. Internal maintenance, which will require the opening of the casing, must only be undertaken by an authorised
service agent.
2. INTRODUCTION
Heavy-duty steel construction with corrosion resistant powder coated finish. 9-Position guide arm with four non-snag rollers. Multi-
position ratchet lock. L-Shaped bracket enables the unit to be floor or wall mounted. A variety of different hose types and lengths for
many applications, refer to specific models for specification.
3. SPECIFICATION
Model No:
Hose Size (ID/OD)
Hose Type
Inlet Size
Length
Maximum Pressure
Outlet Size
Optional Accessories
© Jack Sealey Limited
RETRACTABLE AIR HOSE METAL REEL 15MTR
Ø10MM ID HIGH VISIBILITY TPR HOSE
MODEL NO:
SA84.V2 SA841.V2
Ø10/17mm. Ø10/17mm.
Rubber Rubber
3/8"BSP 3/8"BSP
8m 15m
300psi. 300psi.
1/4"BSP. 1/4"BSP.
Swivel Mounted Swivel Mounted
Plate.- SA85SP. Plate.- SA85SP.
Original Language Version
SA84.V2, SA841.V2, SA841HV.V2,
SA85.V3, SA841HY
SA841HV.V2
Ø10/17mm.
TPR (PVC Outer)
3/8"BSP
15m
300psi.
1/4"BSP.
Swivel Mounted
Plate.- SA85SP.
SA84.V2, SA841.V2/HV.V2, SA85.V3,SA841HY Issue:1 19/04/23
SA85.V3 SA841HY
Ø10/17mm. Ø10/17mm.
Rubber Hybrid - PVC and
Rubber blend
3/8"BSP 3/8"BSP
20m 15m
300psi. 300psi.
1/4"BSP. 1/4"BSP.
Swivel Mounted Swivel Mounted
Plate.- SA85SP. Plate.- SA85SP.