Sealey SA84.V2 Instructions

Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these
instructions, and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
Refer to Wear eye
instruction protection
manual
1. SAFETY
Familiarise yourself with the applications, limitations and specific hazards of the air hose reel.
9
WARNING! Disconnect the air hose reel from the air supply before changing accessories, servicing or performing any
ˆ
maintenance.
Maintain the air hose reel in good condition (use an authorised service agent).
9
Replace or repair damaged parts. Use recommended parts only. Unauthorised parts may be dangerous and will invalidate the
9
warranty.
Mount the air hose reel in a suitable work area. DO NOT position the hose in direct sunlight, or in areas of extreme heat or cold
9
and ensure that there is adequate lighting.
WARNING! Ensure that the maximum air pressure is not exceeded.
ˆ
Keep extended air hose away from heat, oil and sharp edges. Check hose for wear before each use and ensure that all
9
connections are secure.
Unreel only sufficient hose for the task. DO NOT have excess hose coiled on the floor.
9
WARNING! Always wear approved eye or face protection when operating with compressed air.
ˆ
Maintain correct balance and footing. Ensure the floor is not slippery and wear non-slip shoes.
9
Remove ill fitting clothing. Remove ties, watches, rings and other loose jewellery and contain and/or tie back long hair.
9
Keep children and unauthorised persons away from the work area.
9
DO NOT operate the air hose reel if any parts are damaged or missing as this may cause failure and/or personal injury.
8
DO NOT use the air hose reel for any purpose other than that for which it is designed.
8
DO NOT pull the hose from the air supply.
8
DO NOT operate the air hose reel when you are tired or under the influence of alcohol, drugs or intoxicating medication.
8
DO NOT direct air from the air hose at yourself or others.
8
When not in use ensure that the air supply is turned off and tools disconnected. Retract the hose onto the reel.
9
WARNING! DO NOT dismantle the hose reel, or attempt to remove any nuts or bolts, except as described in these Instructions. To
ˆ
do so may result in damage to the reel and/or personal injury and will invalidate the warranty. Internal maintenance must only be
undertaken by an authorised service agent.
2. INTRODUCTION
Heavy-duty steel construction with corrosion resistant powder coated finish. Nine-position guide arm with four non-snag rollers. Multi-position
ratchet lock. L-Shaped bracket enables the unit to be wall, floor or ceiling mounted.(SA814HV.V2: High visibility TPR air hose for added
safety around the workshop).
3. SPECIFICATION
Model no: . . . . . . . . . . . . . . . . . . . . . . . . . . SA84.V2 . . . . . . . . . . . . . . . . SA841.V2/HV.V2. . . . . . . . . .SA85.V3
Hose length: . . . . . . . . . . . . . . . . . . . . . . . . 8mtr . . . . . . . . . . . . . . . . . . . 15mtr. . . . . . . . . . . . . . . . . . . . 20MTR
Hose size (ID/OD) . . . . . . . . . . . . . . . . . . . . Ø10/17mm . . . . . . . . . . . . . . Ø10/17mm . . . . . . . . . . . . Ø10/17mm
Maximum pressure:. . . . . . . . . . . . . . . . . . . 300psi. . . . . . . . . . . . . . . . . . 300psi . . . . . . . . . . . . . . 300psi300psi
Hose type:. . . . . . . . . . . . . . . . . . . . . . . . . . Rubber . . . . . . . . . . . . . . . . . Rubber/TPR . . . . . . . . . . . . . . Rubber
Inlet-outlet: . . . . . . . . . . . . . . . . . . . . . . . . . 3/8"-1/4"BSP. . . . . . . . . . . . . 3/8"-1/4"BSP . . . . . . . . . 3/8"-1/4"BSP
© Jack Sealey Limited
INSTRUCTIONS FOR:
RETRACTABLE AIR HOSE STEEL REEL
Ø10MM ID
SA84.V2, SA841.V2/HV.V2, SA85.V3
MODEL NO'S:
Original Language Version
SA84.V2 SA841.V2/HV.V2 SA85.V3 Issue:1 - 07/11/17