Electrical / Ignition System; Battery Maintenance; Battery Off Season Storage; Battery Charging - Polaris RZR 900 2015 Service Manual

ELECTRICAL / IGNITION SYSTEM

BATTERY MAINTENANCE

Keep battery terminals and connections free of
corrosion. If cleaning is necessary, remove the corrosion
with a stiff wire brush. Wash with a solution of one
tablespoon baking soda and one cup water. Rinse well
with tap water and dry off with clean shop towels. Coat
the terminals with dielectric grease or petroleum jelly.
WARNING
CALIFORNIA PROPOSITION 65 WARNING:
Batteries, battery posts, terminals and related
accessories contain lead and lead compounds, and
other chemicals known to the State of California to
cause cancer and birth defects or other reproductive
harm.
WASH HANDS AFTER HANDLING.
WARNING
Battery electrolyte is poisonous. It contains sulfuric
acid. Serious burns can result from contact with skin,
eyes or clothing. Antidote:
• External: Flush with water.
• Internal: Drink large quantities of water or milk.
Follow with milk of magnesia, beaten egg, or
vegetable oil. Call physician immediately.
• Eyes: Flush with water for 15 minutes and get
prompt medical attention.
Batteries produce explosive gases.
Keep sparks, flame, cigarettes, etc. away. Ventilate
when charging or using in an enclosed space. Always
shield eyes when working near batteries.
KEEP OUT OF REACH OF CHILDREN.
NOTE
Batteries must be fully charged before use or battery
life will be reduced by 10-30% of full potential. Charge
battery according to "Charging Procedure", page
not use the vehicle's stator/alternator to charge a new
battery.
9926814 R08 -
Manual
© Copyright Polaris Industries Inc.

BATTERY OFF SEASON STORAGE

Whenever the vehicle is not used for a period of two
months or more, remove the battery from the vehicle,
ensure that it is fully charged and store it out of the sun in
a cool, dry place. Check battery voltage each month
during storage or and recharge as needed to maintain a
full charge.
Battery charge can be maintained by using a Polaris
battery tender charger or by charging once a month to
make up for normal discharge. Battery tenders can be
left connected during the storage period and will
automatically charge the battery if the voltage drops

BATTERY CHARGING

If battery voltage is less than 12.6 Vdc, the battery may
need recharging. When using an automatic charger, refer
to the charger manufacturer's instructions for recharging.
Do not exceed 6 amps when charging the battery.
Charge the battery using an automatic charger that will
not exceed 14.6 Vdc. An automatic charger will signal
Allow the battery to stand disconnected for at least 1-2
hours after being properly charged. If the voltage drops
below 12.6 volts, charging was ineffective or the battery
An overheated battery could explode, causing severe
injury or death. Always watch charging times carefully.
Stop charging if the battery becomes very warm to the
touch. Allow it to cool before resuming charging.
. Do
STATE OF
CHARGE
100%
75% -
100%
50% - 75%
2015-2016 RZR 900
MAINTENANCE
NOTE
below a pre-determined point.
NOTE
when charging is complete.
needs to be replaced.
WARNING
VOLTAGE
ACTION
(DC)
None, check
12.8 or
again in 3
more
months
May need
12.6 - 12.8
slight charge
Needs
12.3 - 12.6
Charge
2016 RZR S 1000 Service
2
CHARG-
E TIME
None
Required
3 - 6 hrs
5 - 11 hrs
2.35