Koninklijke Philips Electronics N.V. or their respective owners. TP Vision Netherlands B.V. reserves the right to change products at any time without being obliged to adjust earlier supplies accordingly. PHILIPS and the PHILIPS’ Shield Emblem are used under license from Koninklijke Philips Electronics N.V.
Page 2
Notes: software & drivers. • Figures can deviate due to the different set executions. Table 2-1 Described Model Numbers and Diversity Mechanics Schematics 43PUH6101/88 & 4-10 4-11 & 4-12 9.1 10.1 10.5 10.6...
Technical Specs, Diversity, and Connections TPL16.1E LA EN 3 Connections Side Connectors Rear Connectors SCART (RGB/CVBS) AUDIO IN DVI USB 3 SERV .U USB 2 HDMI 4 ARC/MHL NETWORK TV ANTENNA DIGITAL HDMI 1 HDMI 2 USB1 AUDIO OUT HDMI 3 ARC (Optional) 20110_001.eps Figure 2-1 Connection overview...
Page 4
EN 4 TPL16.1E LA Technical Specs, Diversity, and Connections 5- HDMI ARC: Digital Video - In, Digital Audio with ARC - 8 - Cinch: Video YPbPr - In, Audio - In In/Out Gn - Video - Y / 75 W Bu - Video - Pb 0.7 V / 75 W...
Page 5
Technical Specs, Diversity, and Connections TPL16.1E LA EN 5 13 - Easylink/CEC Control channel - D1+ Data channel 14 - n.c. - Shield 15 - DDC_SCL DDC clock - D1- Data channel 16 - DDC_SDA DDC data - D0+ Data channel 17 - Ground - Shield 18 - +5V...
Spare Parts the following points: • Route the wire trees correctly and fix them with the For the latest spare part overview, consult your Philips Spare mounted cable clamps. Part web portal. • Check the insulation of the Mains/AC Power lead for external damage.
Page 7
Precautions, Notes, and Abbreviation List TPL16.1E LA EN 7 result in sets which have the same CTN (Commercial Type 6 = play 16 : 9 format, 12 = play 4 : 3 Number; e.g. 28PW9515/12) but which have a different B.O.M. format number.
Page 8
6.5 MHz. L' is Band (VESA standard for communication I, L is all bands except for Band I channel and display). Using E-DDC, LG.Philips LCD (supplier) the video source can read the EDID Loudspeaker information form the display.
Page 9
SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4-wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board Spread Spectrum Clocking, used to reduce the effects of EMI...
EN 10 TPL16.1E LA Mechanical Instructions 4. Mechanical Instructions Index of this chapter: Notes: 4.1 Cable Dressing • Figures below can deviate slightly from the actual situation, 4.2 Service Positions due to the different set executions. 4.3 Assembly/Panel Removal(for 6101 & 6121 series) 4.5 Set Re-assembly Cable Dressing ECN701...
Page 11
Mechanical Instructions TPL16.1E LA EN 11 ECN701 CN8101 CN9101 CN701 CN412 MAIN POWER SUPPLY (1054) (1053) KEYBOARD CONTROL (1057) LOUDSPEAKER LOUDSPEAKER WIFI MODULE (1184) (1184) WiFi01 IR/LED BOARD (1056) 20112_100.eps Figure 4-2 Cable dressing (43" 6201 series) CN8101 ECN701 CN412 CN701 MAIN POWER SUPPLY (1054)
Page 12
EN 12 TPL16.1E LA Mechanical Instructions CN8101 ECN701 ECN701 CN701 CN412 MAIN POWER SUPPLY (1054) ECN408 (1053) ECN601 KEYBOARD CONTROL (1057) LOUDSPEAKER LOUDSPEAKER (1184) (1184) IR/LED BOARD (1056) 20110_102.eps Figure 4-4 Cable dressing (55" 6101 series) CN8101 ECN701 CN701 CN412 MAIN POWER SUPPLY (1054) (1053)
Page 13
Mechanical Instructions TPL16.1E LA EN 13 ECN701 CN8602 CN9201 CN9101 CN701 CN412 MAIN POWER SUPPLY (1054) (1053) KEYBOARD CONTROL (1057) LOUDSPEAKER WIFI MODULE LOUDSPEAKER (1184) WiFi01 (1184) IR/LED BOARD (1056) 20112_102.eps Figure 4-6 Cable dressing (65" 6121 series) Service Positions For easy servicing of a TV set, the set should be put face down on a soft flat surface, foam buffers or other specific workshop tools.
Page 14
EN 14 TPL16.1E LA Mechanical Instructions M4 × 14 M3× 6 M3 × 6 Q3× 8 20110_103.eps Figure 4-7 Rear cover removal[1] 20110_104.eps Figure 4-8 Rear cover removal[2] back to 2016-Sep-23 div.table...
Page 15
Mechanical Instructions TPL16.1E LA EN 15 4.3.2 Keyboard Control unit 3. Gently take the keyboard out. Refer to Figure 4-9 details. When defective, replace the whole unit. 1. Unplug the connector [2] from the keyboard control panel. 2. Remove the fixation screws [1] that secure the keyboard 20110_105.eps Figure 4-9 Keyboard removal 4.3.3...
Page 16
EN 16 TPL16.1E LA Mechanical Instructions 4.3.4 IR/LED Board 3. Take the speakers out. When defective, replace the both units. Refer to Figure 4-11 Figure 4-12 for details. 1. Remove the fixation screws [1] from the stand bracket, pull 4.3.7 LCD Panel out the assy from the set.
Page 17
Mechanical Instructions TPL16.1E LA EN 17 M4 × 14 M3× 6 M3 × 6 Q3× 8 20112_103.eps Figure 4-13 Rear cover removal[1] 20112_104.eps Figure 4-14 Rear cover removal[2] back to 2016-Sep-23 div.table...
Page 18
EN 18 TPL16.1E LA Mechanical Instructions 4.4.2 AmbiLight Panel 1. Gently release the clamps and unplug the two connectors [5] that secure the ambilight panels. Release the clips from the FFC connector that connect with the keyboard [4]. Refer to Figure 4-15 for details.
Page 19
Mechanical Instructions TPL16.1E LA EN 19 4.4.5 IR/LED Board 3. Take the speakers out. When defective, replace the both units. Refer to Figure 4-17 Figure 4-18 for details. 1. Remove the fixation screws [1] from the stand bracket, pull 4.4.8 LCD Panel out the assy from the set.
EN 20 TPL16.1E LA Service Modes, Error Codes, and Fault Finding 5. Service Modes, Error Codes, and Fault Finding Index of this chapter: • X is the main version number: this is updated with a major 5.1 Service Modes change of specification (incompatible with the previous 5.2 Stepwise Start-up software version).
Page 21
Service Modes, Error Codes, and Fault Finding TPL16.1E LA EN 21 Main Menu Sub-menu 1 Sub-menu 2 Description Clear Codes Press [OK] to clean the Error Codes Erases the contents of the error buffer. Select this menu item and press the MENU immediately RIGHT key on the remote control.
Page 22
EN 22 TPL16.1E LA Service Modes, Error Codes, and Fault Finding Default value Item Item value 43" 49" 55" 65" Description NVM COPY TV to USB Press OK Use this to store the NVM data to the REPAIR folder of a FAT formatted USB memory stick.
Page 23
Service Modes, Error Codes, and Fault Finding TPL16.1E LA EN 23 • 1.4b Option Code 2 Gives the option codes of option • 3.2 Child lock Not active / active. This is a combined item group 2 as set in SAM. for locks.
Page 24
It is possible for the user to upgrade the main software via the USB port. This allows replacement of a software image in a stand alone set. A description on how to upgrade the main software can be found in the DFU or on the Philips website. 5.4.2 Introduction 19080_207_110324.eps...
Page 25
Service Modes, Error Codes, and Fault Finding TPL16.1E LA EN 25 5.4.6 Content and Usage of the One-Zip Software File Example: – ERROR: 000 000 000 000 000: No errors detected – ERROR: 013 000 000 000 000: Error code 13 is the Below you find a content explanation of the One-Zip file, and last and only detected error instructions on how and when to use it.
Page 26
EN 26 TPL16.1E LA Service Modes, Error Codes, and Fault Finding LAYER 1 LAYER 2 I²C Description Monitored Error in error Device Defective board error error address buffer Prot. Blinking I²C BUSS ES DSP bus (00) BL/EB Audio DSP AMP bus (01) BL/EB Audio DSP SSB bus (0F)
Page 27
Service Modes, Error Codes, and Fault Finding TPL16.1E LA EN 27 • Before any fault finding actions, check if the correct options to insure that the cooling is guaranteed, otherwise the Class are set. D-IC could break down in short time. 5.7.1 NVM Editor 5.7.9...
Picture mode Screen size Green Blue signal strength of at least 1 mV and a frequency of Normal (9000K) 43PUH6101/88 128 61.25 MHz (channel 3). 43PUS6101/12 126 • LATAM models: an NTSC M TV-signal with a signal 43PUT6101/12 127 strength of at least 1 mV and a frequency of 43PUT6101/60 125 61.25 MHz (channel 3).
Page 29
6-3. After resetting Colour temperature the Display Code, restart the set immediately. Picture mode Screen size Green Blue Cool (11000K) 43PUH6101/88 118 Table 6-3 Display code overview 43PUS6101/12 117 43PUT6101/12 116 43PUT6101/60 118 CTN_ALT BOM# Panel Type Display Code 43PUS6201/12 125 43PUH6101/88 TPT430U3-EQYSHM.G S1G...
Page 30
EN 30 TPL16.1E LA Alignments 715Axxxx-Nnn-MMM-OOOO • 715 main category, Printed Wiring Board • Axxxx sub category, sequential coding number • Nnn Version code • N Development number • nn Production number • MMM Mounting variation code • OOOO Optional variation code Make sure when replacing an SSB the SSB identification codes match the replacement panel.
Circuit Descriptions TPL16.1E LA EN 31 7. Circuit Descriptions Index of this chapter: Introduction 7.1 Introduction The TPL16.1E LA is a new chassis launched in Europe in 7.2 Power Supply 2016. The whole range is covered by MT55936L. 7.3 DC/DC Converters The major deltas versus its predecessor support DVB-C;...
Page 32
EN 32 TPL16.1E LA Circuit Descriptions 7.1.3 SSB Cell Layout COMMON INTERFACE DC/DC MT5596 SCART ANALOG I/O HDMI TUNER HDMI NETWORK SPDIF OUT Headphone 20110_200.eps Figure 7-1 SSB layout cells (top view) back to 2016-Sep-23 div.table...
Page 33
7.2.2 Diversity specifications! This part is available in the regular market. Consult the Philips Service web portal for the order codes of the The diversity in power supply units is mainly determined by the boards. diversity in displays.
Page 34
EN 34 TPL16.1E LA Circuit Descriptions Connector Number CN9101 CN8602 CN9101 CN8603 CN9101 CN8602 Description to SSB to panel to SSB to panel to SSB to panel 3D_ON -VLED1 3D_ON n.c. -VLED1 -VLED1 VLED- -VLED1 -VLED1 VLED- -VLED1 -VLED2 -VLED2 -VLED2 -VLED2 +12VA/16VA...
Page 35
Circuit Descriptions TPL16.1E LA EN 35 7.3.1 Power layout SSB L803, VCC0.9V_FRC L803,+5V_USB L702, +5V_STB FB7056,+5V_SW L707,DVDD3V3 /AVDD3V3 /VCC3.3V_FRC L701, DDRV, 1.5V L703, VCCK, 1.0V C1113,+5V-USB 20110_208.eps Figure 7-4 Power SSB Top View back to 2016-Sep-23 div.table...
Page 36
EN 36 TPL16.1E LA Circuit Descriptions D4012,WI-FI_VCC FB106,CI2_VCC U102,TUNER3.3V 20110_209.eps Figure 7-5 Power SSB Bottom View Front-End Analogue and DVB-T/T2, DVB-C, DTV-S2 reception SUT-RE231ZN 7.4.1 Front-End Analogue and DVB T/C reception The Front-End for analogue tuner consist of the following key components: IF_AGC IF_AGC...
Page 37
Circuit Descriptions TPL16.1E LA EN 37 7.4.2 DTV T2 reception HDMI Refer to figure 7-9 HDMI input configuration for the application. The Front-End for DVT part consist of the following key components: • TUNER EUROPE SUT-RE231ZN • SCALER MT5596LGIJ HSBGA-757 MT5596L •...
Page 38
EN 38 TPL16.1E LA Circuit Descriptions The MT5596L enables consumer electronics manufacturers to build high quality, low cost and feature-rich DTV. The MT5596L family supports Full-HD MPEG1/2/4/H.264 /DiviX/VC1/RM/AVS/VP6/VP8 and H.264/AVC, H.265/HEVC video decoder standards, and JPEG. The MT5596L also supports Media Tek MDDi de-interlace solution which can reach very smooth picture quality for motions.
IC Data Sheets TPL16.1E LA EN 39 8. IC Data Sheets This chapter shows the internal block diagrams and pin configurations of ICs that are drawn as “black boxes” in the electrical diagrams (with the exception of “memory” and “logic” ICs).
Page 40
EN 40 TPL16.1E LA IC Data Sheets Diagram 10-5-18 MST7470DY Power 2, B18, MST7484GC (IC U801) Block diagram MST7484GC 20110_301.eps Figure 8-2 Internal block diagram and pin configuration back to 2016-Sep-23 div.table...
Page 41
IC Data Sheets TPL16.1E LA EN 41 Diagram 10-5-1 Power 1, B01, SY8366QNC (IC U708) Block diagram SY8366QNC Pinning information 20110_302.eps Figure 8-3 Internal block diagram and pin configuration back to 2016-Sep-23 div.table...
Page 42
EN 42 TPL16.1E LA IC Data Sheets Diagram 10-5-2 System Power, B02, RT8079GQW (IC U705) Block diagram RT8079GQW Internal pull up Over Temperature current Protection UVLO Enable Comparator Shutdown Current EN Threshold Control Sense BOOT RT/SYNC Oscillator Control Driver Slope Logic Compensation Comparator...
Page 43
IC Data Sheets TPL16.1E LA EN 43 Diagram 10-5-7 Speaker/Headphone, B07, AD87588 (IC U601) Block diagram AD87588 Pinning information 19790_301.eps Figure 8-5 Internal block diagram and pin configuration back to 2016-Sep-23 div.table...
Page 44
EN 44 TPL16.1E LA IC Data Sheets Diagram 10-5-10 Tuner, B10, CXD2844ER (IC U101) Block diagram CXD2844ER Pinning information 20110_304.eps Figure 8-6 Internal block diagram and pin configuration back to 2016-Sep-23 div.table...
Page 45
IC Data Sheets TPL16.1E LA EN 45 Diagram 10-5-11 Silabs DEMODInput, B11, MP8124GD (IC U202) Block diagram MP8124 Pinning information 20030_305.eps Figure 8-7 Internal block diagram and pin configuration back to 2016-Sep-23 div.table...
Page 46
EN 46 TPL16.1E LA IC Data Sheets Personal Notes: 10000_012_090121.eps 110804 back to 2016-Sep-23 div.table...
Page 50
Circuit Diagrams and PWB Layouts TPL16.1E LA EN 50 10-1-3 Main Power Main Power COLD 12VS U9106 L9102 NC/L78L12ABUTR 12VA/16VA C9128 R9145 Q9107 100KOHM T9101 MTB15P04J3 100N 50V SY NC C9141 POWER X'FMR R9143 470UF 25V 33K +-1% 1/4W U9105 C9135 C9136 C9132...
Circuit Diagrams and PWB Layouts TPL16.1E LA EN 97 10.7 J 715G8527 IR/LED Panel 10-7-1 IR & 3D & Light sensor & LOGO IR &3D&Light sensor&LOGO 3V3SB IR Receiver 3V3SB 3V3SB LED_R St andby LED LOGO R234 CN201 10K 1/10W 5% R201 R202 100R 1/16W 5%...
Page 98
Circuit Diagrams and PWB Layouts TPL16.1E LA EN 98 10-7-2 IR/LED board layout Layout IR/LED panel (top side) LED201 R234 ZD205 U201 LED205 LED206 LED207 LED208 SEN4 Layout IR/LED panel (bottom side) Q201 CN201 Q207 SEN1 IR/LED panel 715G8527 layout top/bottom 20112_501.eps back to 2016-Sep-23...
Circuit Diagrams and PWB Layouts TPL16.1E LA EN 99 10.8 J 715G8521 IR/LED Panel 10-8-1 IR & 3D & Light sensor & LOGO IR &3D&Light sensor&LOGO 3V3SB IR Receiver 3V3SB 3V3SB St andby LED R234 2.2K OHM R201 R202 LED_R 100R 1/16W 5% LOGO CN201...
Page 100
Circuit Diagrams and PWB Layouts TPL16.1E LA EN 100 10-8-2 IR/LED board layout Layout IR/LED panel (top side) CN201 Q207 U201 Q201 Layout IR/LED panel (bottom side) CN201 Q207 U201 Q201 2016-4-25 IR/LED panel 715G8521 layout top/bottom 20112_503.eps back to 2016-Sep-23 div.table...
Circuit Diagrams and PWB Layouts TPL16.1E LA EN 101 10.9 E 715G7088 Keyboard control panel 10-9-1 CN01 CN01 KEY1 CONN CONN 0.1uF 50V 0.1uF 50V TACT SW 6P TACT SW 6P SW01 SW01 Right Center Down Left 2014-05-28 Keyboard control panel 715G7088 19791_502.eps back to...
Page 102
Circuit Diagrams and PWB Layouts TPL16.1E LA EN 102 10-9-2 Key board layout Layout Keyboard control panel (top side) SW01 Layout Keyboard control panel (bottom side) 2014-06-06 Keyboard control panel 715G7088 layout top/bottom 19791_503.eps back to 2016-Sep-23 div.table...
Circuit Diagrams and PWB Layouts TPL16.1E LA EN 103 10.10 E 715G8555 Keyboard control panel 10-10-1 Joystick key define CONN TO SSB JOYSTICK Direction switch Key function Resistance Voltage Range Center 2-5 short Menu 0.0 to 0.22 V CN01 CN04 Right 1-5 short 0.5V...
Page 104
Circuit Diagrams and PWB Layouts TPL16.1E LA EN 104 10-10-2 Key board layout Layout Keyboard control panel (top side) SW01 Layout Keyboard control panel (bottom side) 2016-08-09 Keyboard control panel 715G8555 layout top/bottom 20112_505.eps back to 2016-Sep-23 div.table...