Page 1
Savannah™VG / XL VG Copyright I.C.P. 2002 Savannah™ is registered trademark solely owned by ICP srl and their use in any form is strictly forbidden. The content of the present manual is the sole property of I.C.P. srl and cannot be reproduced by third parties in any form whatsoever without ICP’s previous written authorization.
Page 2
Number Pages First version 06/06 Effective also for XL 11/08 Point 34, general change. 5/2/2009 1000h/1500h 27/2/2009 TABLE OF CONTENTS ICP Srl – S.P.16 km 15,150-14022 Castelnuovo Don Bosco (AT) Issue 1/Revision 04 Phone +39-0119927503 • Fax +39-0119927266 August 2011...
1000 hours flight time/72 months calendar time 1500 hours inspection (Engine overhaul) every 1.500 hours flight time 1.2 MAINTENANCE HISTORIC REPORT ICP Srl – S.P.16 km 15,150-14022 Castelnuovo Don Bosco (AT) Issue 1/Revision 04 Phone +39-0119927503 • Fax +39-0119927266 August 2011...
Page 5
48 m 54 m 60 m 1.000 64 m 1.025 1.050 1.075 1.100 68 m 1.125 1.150 1.175 1.200 72 m ICP Srl – S.P.16 km 15,150-14022 Castelnuovo Don Bosco (AT) Issue 1/Revision 04 Phone +39-0119927503 • Fax +39-0119927266 August 2011...
I.C.P. Srl does not take any responsability of eventual damage to persons and things due to lack of application of Rotax prescriptions. ICP Srl – S.P.16 km 15,150-14022 Castelnuovo Don Bosco (AT) Issue 1/Revision 04 Phone +39-0119927503 • Fax +39-0119927266...
Page 9
Parachute: if installed, check for security, bridles condition, that ICP Srl – S.P.16 km 15,150-14022 Castelnuovo Don Bosco (AT) Issue 1/Revision 04 Phone +39-0119927503 • Fax +39-0119927266...
Page 10
Rotax service informations Fuel system: visually inspect pipes, clamps, fuel filter, electric pump and mechanical pump; clean and inspect float chambers and ICP Srl – S.P.16 km 15,150-14022 Castelnuovo Don Bosco (AT) Issue 1/Revision 04 Phone +39-0119927503 • Fax +39-0119927266...
Page 11
Check the exhaust system for cracks, loose fasteners, springs in place and oxidation Thoroughly clean both the engine and its accessories Check for condition of the air-box support spring ICP Srl – S.P.16 km 15,150-14022 Castelnuovo Don Bosco (AT) Issue 1/Revision 04 Phone +39-0119927503 • Fax +39-0119927266 August 2011...
Check the brakes operating effectiveness; clean or replace the pads as required Change oil filter Change oil with recommended type ICP Srl – S.P.16 km 15,150-14022 Castelnuovo Don Bosco (AT) Issue 1/Revision 04 Phone +39-0119927503 • Fax +39-0119927266 August 2011...
Page 13
NOTE: if a skin panel crack is found, before next fly, please contact the manufacturer DESCRIPTION MECH. CER. ST. ICP Srl – S.P.16 km 15,150-14022 Castelnuovo Don Bosco (AT) Issue 1/Revision 04 Phone +39-0119927503 • Fax +39-0119927266 August 2011...
Page 14
15 mm long over each 1 m wing span; they could slightly affect the in-flight aircraft’s trimming; periodically check for a crack that could arise ICP Srl – S.P.16 km 15,150-14022 Castelnuovo Don Bosco (AT) Issue 1/Revision 04 Phone +39-0119927503 • Fax +39-0119927266...
Page 15
Drain and refill the coolant fluid in the cooling system Replace the spark plugs Remove, clean and reinstall the oil reservoir Check carefully the silencer ICP Srl – S.P.16 km 15,150-14022 Castelnuovo Don Bosco (AT) Issue 1/Revision 04 Phone +39-0119927503 • Fax +39-0119927266 August 2011...
1.3.8 1.500 HOURS INSPECTION (ENGINE OVERHAUL) NOTE: the engine overhaul must be carried out by the engine manufacturer only. In this case replace the Aluminium engine support. ICP Srl – S.P.16 km 15,150-14022 Castelnuovo Don Bosco (AT) Issue 1/Revision 04 Phone +39-0119927503 • Fax +39-0119927266...
NGK DCPR8E (Rotax 912 ULS) The content of the present manual is the sole property of I.C.P. srl and cannot be reproduced by third parties in any form whatsoever without ICP’s previous written authorization. Copyright I.C.P.2002 ICP Srl – S.P.16 km 15,150-14022 Castelnuovo Don Bosco (AT) Issue 1/Revision 04 Phone +39-0119927503 •...