Koninklijke Philips Electronics N.V. or their respective owners. TP Vision Netherlands B.V. reserves the right to change products at any time without being obliged to adjust earlier supplies accordingly. PHILIPS and the PHILIPS’ Shield Emblem are used under license from Koninklijke Philips Electronics N.V.
& Notes: drivers. • Figures can deviate due to the different set executions. Table 2-1 Described Model Numbers and Diversity Block Mechanics Diagrams Schematics 24PFK5211/12 10.1 10.2 10.3 11.1 24PFT5211/12 10.1 10.2 10.3 11.1 24PFT5211/60 10.1...
Page 3
Technical Specs, Diversity, and Connections TPN16.1E LA EN 3 Connections Rear Connectors Side Connectors HDM I2 HDMI 1 AUDIO IN VGA / DVI S CART (RGB/CVBS) TV ANTENNA SERV .U (Optional) 20060_001.eps Figure 2-1 Connection overview Note: The following connector colour abbreviations are used 5 - PC IN:VGA (acc.
Page 4
EN 4 TPN16.1E LA Technical Specs, Diversity, and Connections - D1+ Data channel 8 - Cinch: Digital Audio - Out - Shield BK - Coaxial 0.4 - 0.6V / 75 W - D1- Data channel - D0+ Data channel 9 - Service / UART - Shield - Ground - D0-...
Spare Parts the following points: • Route the wire trees correctly and fix them with the For the latest spare part overview, consult your Philips Spare mounted cable clamps. Part web portal. • Check the insulation of the Mains/AC Power lead for external damage.
Page 6
EN 6 TPN16.1E LA Precautions, Notes, and Abbreviation List result in sets which have the same CTN (Commercial Type 6 = play 16 : 9 format, 12 = play 4 : 3 Number; e.g. 28PW9515/12) but which have a different B.O.M. format number.
Page 7
6.5 MHz. L' is Band (VESA standard for communication I, L is all bands except for Band I channel and display). Using E-DDC, LG.Philips LCD (supplier) the video source can read the EDID Loudspeaker information form the display.
Page 8
SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4-wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board Spread Spectrum Clocking, used to reduce the effects of EMI...
Mechanical Instructions TPN16.1E LA EN 9 4. Mechanical Instructions Index of this chapter: Notes: 4.1 Cable Dressing • Figures below can deviate slightly from the actual situation, 4.2 Service Positions due to the different set executions. 4.3 Assembly/Panel Removal (for 24"Pxx5211) 4.4 Set Re-assembly Cable Dressing CN9101...
Page 10
Assembly/Panel Removal (for 24"Pxx5211) For easy servicing of a TV set, the set should be put face down Instructions below apply to the 24PFK5211/12, but will be on a soft flat surface, foam buffers or other specific workshop similar for other 24"Pxx5211 series models.
Page 11
Mechanical Instructions TPN16.1E LA EN 11 4.3.2 Rear Cover 1. At the indicated areas [5] the cover is securd by clips. Be very careful with releasing those. 2. Gently lift the rear cover from the TV. Make sure that wires Refer to Figure 4-3 for details.
Page 12
EN 12 TPN16.1E LA Mechanical Instructions 4.3.3 Speaker 2. Release the connectors [2] and [3] that connect speake with the SSB. Refer to Figure 4-4 for details. 3. Gently lift the Speaker from the TV. Make sure that wires Refer to Figure 4-4 for details.
Page 13
Mechanical Instructions TPN16.1E LA EN 13 4.3.5 IR/LED Board Refer to Figure 4-6 for details. 1. Remove the area clips [1] from the stand bracket, pull out the assy from the set. Refer to Figure 4-6 for details. 2. Carefully Releas the cover secured by clips, then unplug the connector [2] from the IR/LED board.
EN 14 TPN16.1E LA Service Modes, Error Codes, and Fault Finding 5. Service Modes, Error Codes, and Fault Finding Index of this chapter: Display Option Code Selection 5.1 Service Modes When after an SSB or display exchange, the display option 5.2 Stepwise Start-up code is not set properly, it will result in a TV with “no display”.
Page 15
Service Modes, Error Codes, and Fault Finding TPN16.1E LA EN 15 Table 5-1 SAM mode overview Main Menu Sub-menu 1 Sub-menu 2 Description System Information Op Hour e.g. 00082 This represents the life timer. The timer counts normal operation hours, but does not count Stand-by hours.
Page 16
EN 16 TPN16.1E LA Service Modes, Error Codes, and Fault Finding Default value Item Item value 24" Description ORT_MODE ORT mode AGEING MODE Use this for aging a new LCD panel AUD_LIMITE_MODE Three modes,0: off, 1: adaptive mode, 2: fixed mode AUD_THRESHOLD_BYTE1 Limit threshold AUD_THRESHOLD_BYTE2...
Page 17
Service Modes, Error Codes, and Fault Finding TPN16.1E LA EN 17 After entering the Customer Service Mode, the following items software can be upgraded. As this software is consumer are displayed. upgradeable, it will also be published on the internet. •...
Page 18
It is possible for the user to upgrade the main software via the USB port. This allows replacement of a software image in a stand alone set. A description on how to upgrade the main software can be found in the DFU or on the Philips website. 5.4.2 Introduction 19080_207_110324.eps...
Page 19
Service Modes, Error Codes, and Fault Finding TPN16.1E LA EN 19 5.4.6 Content and Usage of the One-Zip Software File Example: – ERROR: 000 000 000 000 000: No errors detected – ERROR: 013 000 000 000 000: Error code 13 is the Below you find a content explanation of the One-Zip file, and last and only detected error instructions on how and when to use it.
Page 20
EN 20 TPN16.1E LA Service Modes, Error Codes, and Fault Finding automatically when the error/protection is monitored by the 5.7.6 No Picture via HDMI input standby processor. In case no picture is shown and there is no LED blinking, Check if HDCP key is valid. This can be done in CSM. read the logging to detect whether “error devices”...
Picture mode Screen size Green Blue signal strength of at least 1 mV and a frequency of Normal (9000K) 24PFK5211/12 61.25 MHz (channel 3). 24PFT5211/12 • LATAM models: an NTSC M TV-signal with a signal 24PFT5211/60 strength of at least 1 mV and a frequency of...
Page 22
Table 6-3 Display code overview PSU connector CN902 to the SSB connector CN701, will have the position number ECN902. CTN_ALT BOM# Panel Type Display Code 24PFK5211/12 TPM236WF1-HJJP02.N SC4M WH 022 24PFT5211/12 TPM236WF1-HJJP02.N SC4M WH 022 24PFT5211/60 TPM236WF1-HJJP02.N SC4M WH 022...
Circuit Descriptions TPN16.1E LA EN 23 7. Circuit Descriptions Index of this chapter: Introduction 7.1 Introduction The TPN16.1E LA is a new chassis launched in Europe in 7.2 Power Supply 2016. The whole range is covered by NT72453. 7.3 DC/DC Converters The major deltas versus its predecessor support DVB-TC;...
Page 24
EN 24 TPN16.1E LA Circuit Descriptions 7.1.3 SSB Cell Layout DC/DC COMMON INTERFACE NT72453 HDMI HDMI AUDIO IN Analog Input SPDIF OUT TUNER Headphone SERVICE CONNECTOR SCART Power Button 20100_200.eps Figure 7-1 SSB layout cells (top view) back to 2016-Mar-11 div.
Page 25
The following displays can be distinguished: specifications! This part is available in the regular market. • CCFL/EEFL backlight: power panel is conventional IPB Consult the Philips Service web portal for the order codes of the • LED backlight: boards. - side-view LED without scanning: PSL power panel - side-view LED with scanning: PSLS power panel Important delta’s with the TPN16.1E LA classis platform are:...
Page 26
EN 26 TPN16.1E LA Circuit Descriptions • +12V, input from the power supply for the panel Connector common(active mode) Number CN9101 CN8602 • +12V, input from the power supply for the AMP Description to SSB to panel • +1V5, from the power supply for the scaler IC NT72453 •...
Page 27
Circuit Descriptions TPN16.1E LA EN 27 7.3.1 Power layout SSB C626 PVDD(12V) L704,DV33 L703, +5V_STB L701, DV11 L702, DV15 U203, +3V3_Tuner U102, VCC_CI U705, AVDD1V2 20100_202.eps Figure 7-4 Power SSB Top View back to 2016-Mar-11 div. table...
Page 28
EN 28 TPN16.1E LA Circuit Descriptions C707,+5V_SW 20060_209.eps Figure 7-5 Power SSB Bottom View Front-End Analogue and DVB-T, DVB-C; ISDB-T reception ST42CS-2-E 7.4.1 DVB-T/C DTV part The Front-End for DVB-T/C DTV part consist of the following key components: IF_AGC IF_AGC •...
Page 29
Circuit Descriptions TPN16.1E LA EN 29 7.4.2 DVB-T2 DTV part HDMI Refer to figure 7-9 HDMI input configuration for the application. The Front-End for DVB-T2 DTV part consist of the following key components: • TUNER EUROPE system ST42CS-2-E NT72453MBG • SCALER NT72453MBG-BA/B TFBGA-466 •...
EN 30 TPN16.1E LA IC Data Sheets 8. IC Data Sheets This chapter shows the internal block diagrams and pin configurations of ICs that are drawn as “black boxes” in the electrical diagrams (with the exception of “memory” and “logic” ICs).
Page 31
IC Data Sheets TPN16.1E LA EN 31 Diagram 10-2-1 System Power, B01, M5723B (IC U701) Block diagram Current Sense Current Sense M5723B HDRV HDRV VREF VREF 100mΩ 100mΩ 0.6V 0.6V CONTROL CONTROL LDRV LDRV 80mΩ 80mΩ UVLO UVLO Compensation Compensation Thermal Thermal PGND...
Page 32
EN 32 TPN16.1E LA IC Data Sheets Diagram 10-2-7 NT72453_STBC/FLASH, B07, MX30LF1G08AA (IC U405) Block diagram MX30LF1G08AA High Voltage Circuit Memory Array Control Logic Page Buffer Address Y-DEC R/B# Counter Data IO[7:0] Buffer Pinning information R/B# 19790_300.eps Figure 8-3 Internal block diagram and pin configuration back to 2016-Mar-11 div.
Page 33
IC Data Sheets TPN16.1E LA EN 33 Diagram 10-2-8 NT72453_USB/GPIO, B10, Si2166-B22 (IC U201) Block diagram Si2166 1.2, 3.3V RESETB DiSEqC DSP & CTRL GPIO SYNCHRO TS_ERR/ S_ADC_IP GPIO_1 QPSK / 8PSK S_ADC_IN ADC (I) VITERBI Satellite TS_SYNC S_ADC_QP QPSK TS_VAL ZIF Tuner ADC (Q)
Page 35
IC Data Sheets TPN16.1E LA EN 35 Diagram 10-2-11 SPK AMP/HP OUT, B11, AD87588 (IC U601) Block diagram AD87588 Pinning information 19790_301.eps Figure 8-6 Internal block diagram and pin configuration back to 2016-Mar-11 div. table...
Page 36
EN 36 TPN16.1E LA IC Data Sheets Personal Notes: 10000_012_090121 back to 2016-Mar-11 div. table...
Circuit Diagrams and PWB Layouts TPN16.1E LA EN 42 10.2 B 715G6947 SSB 10-2-1 System Power System Power Backlight ON/OFF Control BL_DIMMING_912 DV33 BL_DIMMING_912 18 AUDIO_12V AUDIO_12V 14 PWR_12V NC/1K PWR_12V 13,17 +5V_STB R738 +5V_STB DC POWER INPUT +5V_SW DV33SB +5V_STB +5V_SW 9,11,13,16,17,18...
Circuit Diagrams and PWB Layouts TPN16.1E LA EN 59 10.3 J 715G8009 IR/LED Panel 10-3-1 IR & LED & Light Sensor IR & LED & Light Sensor Light Sensor St andby LED 3V3SB CN201 LED_R DVD3V3 DVD3V3 C222 NC/ 1uF 10V RC-IR R201 R224...
Page 60
Circuit Diagrams and PWB Layouts TPN16.1E LA EN 60 10-3-2 IR/LED board layout Layout IR/LED panel (top side) CN201 U201 Q201 Layout IR/LED panel (bottom side) R224 R223 LED201 2015-08-27 IR/LED panel 715G8009 layout top/bottom 20050_527.eps back to 2016-Mar-04 div.table...