Summary of Contents for Land ECOD-AT
- Page 1 SHIPBOARD ELECTRIC CONVECTION OVEN ECOD-AT, ECODL-AT ECOF-AT, ECOFL-AT Installation and Operation Instructions 2M-W483 Rev. E 3/18/13 ECOF-AT...
- Page 2 SAFETY SYMBOL These symbols are intended to alert the user to the presence of important operating and maintenance instructions in the manual accompanying the appliance. FOR YOUR SAFTEY DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND LIQUIDS IN THE VICINTIY OF THIS OR ANY OTHER APPLIANCE.
-
Page 3: Table Of Contents
Single Stack ECO-6M ECOD-AT 380 - 50 11.5 12.5 ECO-7M ECOF-AT 440 - 50/60 480 - 50/60 208 - 50/60 Double Stack 240 - 50/60 ECO-8M ECOD-AT, ECODL-AT 380 - 50 31.5 ECO-9M ECOF-AT, ECOFL-AT 440 - 50/60 480 - 50/60... -
Page 4: Equipment Description
ITEMS FURNISHED (Listed by Model Number) DOUBLE STACKED UNITS SINGLE STACKED UNITS ECOD-AT ECOD-AT, ECODL-AT or ECOF-AT, ECOFL-AT ECO-8 or ECO-8M (Previouse Model) ECO-6 or ECO-6M (Previouse Model) 1 ea. Oven, Type I, Size 2 2 ea. Oven, Type II, Size 2 4 ea. -
Page 5: Installation
ITEMS REQUIRED An adequate supply of wire suitable for the loads and application specified on the data sheet must be provided. The data sheet is on Page 4 of this manual. TOOLS AND TEST EQUIPMENT REQUIRED For Installation: 1 set – Open End Wrenches – Flat Blade Screwdriver – Phillips Screwdriver – Wire Cutter/Stripper – AMP Probe –... -
Page 6: Leg Installation
INSTALLATION INSPECTION AND INSTALLATION Upon receipt of the oven(s) any damage should be noted on the Bill of Lading and countersigned by the carrier. If concealed damage is discovered the carrier should be notified. All claims must be filed with the carrier. Move the crate(s) containing the oven(s) as close to the place of installation as possible before removing the protective crating. Uncrate the oven(s) and move them as close as practical to the final installation site. -
Page 7: Operation
OPERATING INSTRUCTIONS NOTICE: During the first few hours of operation you may notice a small amount of smoke coming off the oven, and a faint odor from the smoke. This is normal for a new oven and will disappear after the first few hours of use. ALWAYS KEEP THE AREA NEAR THE APPLIANCE FREE FROM COMBUSTIBLE MATERIALS. -
Page 8: Maintenance & Troubleshooting Procedures
MAINTENANCE Wash the stainless interior & exterior often with a solution of hot water and mild detergent to prevent grease build-up and preserve the oven’s appearance. The oven racks, slides and stainless steel oven liners are removable for easier cleaning of the oven interior. NOTE: Wipe up spillage as soon as possible. Never use scouring powder. It is difficult to remove completely and a residue build-up can damage the oven. - Page 9 MAINTENANCE and TROUBLESHOOTING CONT’D PERFORMANCE AND INSPECTION A periodic check of thermostat calibration should be performed. To check oven calibration attach a thermocouple to the mid-point of the thermostat bulb in the oven cavity. Turn the temperature dial to 350°F and turn the oven ON. Wait approximately 20 minutes until the oven temperature has stabilized.
- Page 10 MAINTENANCE and TROUBLESHOOTING CONT’D MOTOR REPLACEMENT: The motor is located inside the oven cavity. To replace the motor, remove the baffle at the back of the oven. This will expose the blower wheel and motor shaft to plain view and allow easy access. Remove the blower wheel as described in “BLOWER WHEEL REPLACEMENT”. Next, remove the bolts holding the motor plate to the back wall of the oven cavity.
- Page 13 This page intensionally left blank, so the following pages face each other.
- Page 14 SEE DETAIL SEE DETAIL Figure 6a Model: ECOF-AT1M Electric Marine Convection Oven SK2257 Rev. - 6/12/07 ECO-7M Electric Marine Convection Oven...
-
Page 15: Parts List
PARTS LIST March 18, 2013, Rev E Model No: ECOD-AT, ECODL-AT, ECOF-AT, ECOFL-AT SHIPBOARD ELECTRIC CONVECTION OVEN Part Number Number Description Q9-ECO-471 TOP-TOP DECK ECOF Q9-ECO-472 TOP-BOTTOM DECK ECOFL Q9-ECO-477 TOP-TOP-DECK DEEP OVEN ECOD Q9-ECO-478 TOP-BOTTOM DECK DEEP ECODL Q9-ECO-471-1... - Page 16 Front SEE DETAIL Figure 6b Model: ECOF-AT1M Electric Marine Convection Oven SK2258 Rev. - 6/12/07 ECO-7M Electric Marine Convection Oven...
- Page 17 PARTS LIST March 18, 2013, Rev E Model No: ECOD-AT, ECODL-AT, ECOF-AT, ECOFL-AT SHIPBOARD ELECTRIC CONVECTION OVEN Part Number Number Description Q9-ECO-423 VENTS ASSY Q9-ECO-435 VENT CAP - MILITARY Q9-ECO-449 DAMPER ROD B ASSY Q9-ECO-391 MOTOR MOUNT ASSY 440/480V 440V/480V...
- Page 18 63.1 SEE DETAIL Figure 6c DETAIL Typical Door Assy SK2260a...
- Page 19 PARTS LIST March 18, 2013, Rev E Model No: ECOD-AT, ECODL-AT, ECOF-AT, ECOFL-AT SHIPBOARD ELECTRIC CONVECTION OVEN Part Number Number Description 2C-20109-25 SCRW S/S 10-32 X 3/4 T/H 2C-20201-07 WSHR FLT 1/4 SAE PLTD 2C-20301-29 NUT HEX ACORN 1/4-20 S/S 2C-20102-04 SCRW PHD ST 8-32X.5 PLTD...
- Page 20 DETAIL Motor Mount Assy SK2259a Figure 6d...
- Page 21 PARTS LIST March 18, 2013, Rev E Model No: ECOD-AT, ECODL-AT, ECOF-AT, ECOFL-AT SHIPBOARD ELECTRIC CONVECTION OVEN Part Number Number Description 2U-30200-16 MTR 1/3HP 460V/1/60HZ 2SP 480V 2U-30200-17 MTR 1/3HP208/240V 1PH 2SPD 208V 2U-30200-60 MTR 1/3HP380V1PH50HZ2SP 380V 2C-20118-01 SCRW CARRAGE PLT 5/16X.75...
- Page 22 DETAIL DETAIL Typical Door Stop Assy Figure 6e SK2261a...
- Page 23 PARTS LIST March 18, 2013, Rev E Model No: ECOD-AT, ECODL-AT, ECOF-AT, ECOFL-AT SHIPBOARD ELECTRIC CONVECTION OVEN Part Description Number Number 2E-30705-01 CONTC 2-SPD MTR-COIL 240 2E-30700-03 CONTC 3POLE 40A208-240VAC 2E-31400-04 XFRMR 480/240VAC 100VA 2E-30500-09 TRM BLOCK 3 POLE SMALL 95...
- Page 24 STAR INTERNATIONAL HOLDINGS INC. COMPANY Star - Holman - Lang - Wells - Bloomfield - Toastmaster 10 Sunnen Drive, St. Louis, MO 63143 U.S.A. (314) 678-6303 www.star-mfg.com...