All manuals and user guides at all-guides.com SAFETY PRECAUTIONS 1. Before returning an instrument to the customer, always make a safety check of the entire instrument, including, but not limited to, the following items. a. Be sure that no built-in protective devices are defective and/or have been defeated during servicing. (1) Protective shields are provided on this chassis to protect both the technician and the customer.
Page 4
All manuals and user guides at all-guides.com SAFETY PRECAUTIONS 4. Hot Chassis Warning—a. Some Monitor chassis are electrically connected directly to one conductor of the AC power cord and may be safely serviced without an isolation transformer only if the AC power plug is inserted so that the chassis is connected to the ground side of the AC power source.
All manuals and user guides at all-guides.com BLOCK DIAGRAM PDP Socket Diagram JA2_1 Audio Amplifier AV Module JP1_1 Board Ass'y Pin[1:10] Pin[1:32] Board(with JA1_1 Tuner) JP2_1 Pin[1:12] Assy Pin[1:32] LA03_1 Logic Board Ass'y Pin[1:31] Image Board Ass'y J1_1 PANEL Power Pin[1:31] Supply Ass'y (LVDS)
Page 6
All manuals and user guides at all-guides.com BLOCK DIAGRAM Image Board Socket Data Im age Board ← → Panel Im age Board ← → AV Module Board Im age Board ← → AV Module Board Im age Board As s 'y Im age Board AV Module Board Content...
Page 7
All manuals and user guides at all-guides.com BLOCK DIAGRAM Image Board Signal Block Diagram SDRAM (PAGE4) 6630/6730 VIDEO MAIN Video RGB IN RGB OUT Processor S-VIDEO TA8551CH (PAGE3) SWITCH SDRAM VIDEO 6630/6730 (PAGE12) (PAGE2) SUB Video Porcessor SCALE IC (PAGE5) LVDS YCBCR MULTIPLEX...
Page 8
All manuals and user guides at all-guides.com BLOCK DIAGRAM Image board Power Block Diagram SB5V (USB5V, SB5V_M , SB5V_IO, SB5V_CPU) SB5V_V SB5V_VO R376 +9VT (+9V) DVI_5V +5VSB P5V_COLOR V33SB +24V P24V +5V1 USB3V (5V_OSD) (VDD33) VCCPLL VCCBF CON8009 +5VA V33P VIP711 (VDRAM ) V33TMP...
Page 9
All manuals and user guides at all-guides.com BLOCK DIAGRAM PDP Sound Block Diagram ICS1 ICS2 SUB_WOOFER M UT E OUT PUT PAGE2 FROM AV SELECT OR Q1/Q2 ICA1/ICA2 AV_ OUT PUT INPUT BUFFER M UT E ICR1 ICA3 SRS SURROUND FIXED/VARIBLE PROCESSOR OUT PUT...
Page 10
All manuals and user guides at all-guides.com BLOCK DIAGRAM Tuner Signal Block Diagram POWER BLOCK 7809 9V_T IC201 NE555 IC241 SCL2 FROM IM AGE BOARD CPU SDA2 7805 2SC2482 IC202 Q241 T V_L OUT UPC 1854ACT T U201 RF M ODULE T U201 PIF M ODULE AUDIO OUT M T S...
All manuals and user guides at all-guides.com FACTORY ADJUSTED METHOD 1. PANEAL voltage adjuetment The power volage should be adjueted and clecked when changing the panel or power board. POWER VOLTAGE ADJUST FOR SAMSUNG TTL PANEL POWER BOARD VA VSC VS VR VSET DIGITAL BOARD EXT INT CN01...
Page 12
All manuals and user guides at all-guides.com FACTORY ADJUSTED METHOD 2. Color temperature adjuetment Push the factory service key to into the adjuetment mode. The picture will appear as follow 5400ºk X=335 Y=343 GAIN Bias Use the AV key to select the color to adjust and or key to adjust the leuel. The sequired equipments are CA-100,Vp300.
All manuals and user guides at all-guides.com TROUBLE SHOOTING GUIDES NO POWER SET POWER ON AC Master Power Switch Board DPWB11398-1G--- Power Input Module LJ92-00579A Replace Power Input Module LJ92-00579A Panel Power Supply LJ44-00025A Replace Panel Power Supply LJ44-00025A - 11 -...
Page 14
All manuals and user guides at all-guides.com TROUBLE SHOOTING GUIDES No picture No picture AV Module Board (with Tuner) DPWB11372-1G-T- Replace AV Module Board (with Tuner) DPWB11372-1G-T- Image Board DPWB11393-1G--S Replace Image Board DPWB11393-1G--S PDP Panel Module VVEPP42SD001F-- Replace PDP Panel Module VVEPP42SD001F-- - 12 -...
Page 15
All manuals and user guides at all-guides.com TROUBLE SHOOTING GUIDES Vertical Line fail Vertical Line Interface Board-Z LJ92-00568B Replace Interface Board-Z LJ92-00568B PDP Panel Module Aeesmbly VVEPP42SD001F-- Replace PDP Panel Module Aeesmbly VVEPP42SD001F-- - 13 -...
Page 16
All manuals and user guides at all-guides.com TROUBLE SHOOTING GUIDES Horizontal Line fail Horizontal Line Interface Board-Y LJ92-00569B Replace Interface Board-Y LJ92-00569B Y Amp Board-Upper LJ92-00570A Y Amp Board-Lower LJ92-00571A Replace Y Amp Board- Upper LJ92-00570A Y Amp Board- Lower LJ92-00571A PDP Panel Module Assembly...
Page 17
All manuals and user guides at all-guides.com TROUBLE SHOOTING GUIDES NO Remote Control SET POWER ON Remote Control Replace Replace Battery BRC-2 Front Button Control Board DPWB11372-1G-K- Replace Front Button Control Board DPWB11372-1G-K- Image Board DPWB11393-1G--S Replace Image Board DPWB11393-1G--S - 15 -...
Page 18
All manuals and user guides at all-guides.com TROUBLE SHOOTING GUIDES Front Button Fail SET POWER ON Front Button Control Board DPWB11372-1G-K- Replace Front Button Control Board DPWB11372-1G-K- Image Board DPWB11393-1G--S Replace Image Board DPWB11393-1G--S - 16-...
All manuals and user guides at all-guides.com SPECIFICATION SCOPE: These specifications describe all the characteristics of the 42 inch color monitor. ELECTRICAL REQUIREMENTS: 2.1. Display panel: Specification a. Screen size Diagonal 42 inch b. Aspect ratio 16:9 wide c. Number of pixels 852(Horizontal, RGB Trio ) X 480(Vertical)pixels d.
Page 20
All manuals and user guides at all-guides.com SPECIFICATION 2.3.4 RGB Signal: a. Type b. Polarity Positive or Negative c. Amplitude RGB: 0.7Vp-p d. Frequency H: support to 31K~91KHz V: support to 50~85Hz 2.3.5 DVI Signal: a. Type Digital b. Polarity Positive or Negative c.
Page 21
All manuals and user guides at all-guides.com SPECIFICATION 2.3.9 RGB/DVI For VESA Standard: Vertical Horizontal Refresh Horizontal Vertical Mode No Resolution Sync Sync Dot rate Rate Frequency Frequency Polarity Polarity (Hz) (K Hz) (Hz) (TTL) (TTL) (MHz) 640(VGA)×480 31.5 59.94 25.175 640(VGA)×480 37.9...
Page 22
All manuals and user guides at all-guides.com SPECIFICATION 2.4. Display Performance Requirements: The data of display performance are measured based on the following. Conditions unless otherwise specified. a. Ambient temperature 25±5 ℃ b. Warm up period 30 minutes Min. c. Line input voltage : 100 Vac ~ 240 Vac (50 / 60 Hz) d.
Page 23
All manuals and user guides at all-guides.com SPECIFICATION Width 1040mm 1040mm Height 648 mm 690mm Depth 95mm 375 mm 3.1. Package Dimensions: Width 1230 mm Height 960 mm Depth 470 mm 3.2. Weight: Net weight 79.4lbs/36 Kgs (w/o stand) 83.8lbs/ 38Kgs (w/ stand) Gross weight 115lbs/52 Kgs ENVIRONMENT:...
Page 24
All manuals and user guides at all-guides.com SPECIFICATION RF Sensitivity (Peak) CH 2 ~ CH 13 30dB Max. CH 14 ~ CH 69 30dB Max. CATV CH A-5 ~ CH W+29 30dB Max. AFT Pull-In Range CH 2 ~ CH 13 ±0.6MHz Min.
Page 25
All manuals and user guides at all-guides.com SPECIFICATION Drop Test 200mm max. Vibration Test Forward and backward 30 minutes 1000 c.p.m Right and left 30 minutes 1000 c.p.m Up and down 30 minutes 1000 c.p.m Power Management: Mode H-sync V-sync Video Power dissipation Normal...
Page 26
All manuals and user guides at all-guides.com SPECIFICATION APPENDIX A : Preset Timing Chart (Video) (Sync) Item Description: Total time Active display area including borders Active display area excluding borders Left/Top border Right/bottom border Blanking time Front porch Sync-width Back porch Mode No Resolution &...
Page 27
All manuals and user guides at all-guides.com SPECIFICATION(Preliminary) Mode No Resolution 1024 1024 1024 1024 1280 1280 1280 & 1024 1024 1024 Refresh Rate Pixel 78.75 94.5 157.5 25.175 25.175 MHz Horizontal visible 1024 1024 1024 1024 1280 1280 1280 Dots Horizontal total 1344...
All manuals and user guides at all-guides.com P.C. BOARD TOP VIEW MODULE NAME PARTS NO. IMAGE BOARD ASS'Y DPWB11393-1G--S - 27 -...
Page 30
All manuals and user guides at all-guides.com P.C. BOARD TOP VIEW MODULE NAME PARTS NO. DPWB11398-1G--- AC MASTER POWER SWITCH B/D ASS'Y - 28 -...
Page 31
All manuals and user guides at all-guides.com P.C. BOARD TOP VIEW MODULE NAME PARTS NO. DPWB11372-1G-S- AUDIO AMPLIFIER BOARD ASS'Y - 29 -...
Page 32
All manuals and user guides at all-guides.com P.C. BOARD TOP VIEW MODULE NAME PARTS NO. DPWB11372-1G-K- FRONT BUTTON CONTROL BOARD ASS'Y - 30 -...
Page 33
All manuals and user guides at all-guides.com P.C. BOARD TOP VIEW MODULE NAME PARTS NO. AV MODULE BOARD ASS'Y DPWB11372-1G-T- - 31 -...
Page 34
All manuals and user guides at all-guides.com P.C. BOARD TOP VIEW MODULE NAME PARTS NO. INTERFACE BOARD- Y A’SSY LJ92-00569B - 32 -...
Page 35
All manuals and user guides at all-guides.com P.C. BOARD TOP VIEW MODULE NAME PARTS NO. LOGIC BOARD ASS'Y LJ92-00573 - 33 -...
Page 36
All manuals and user guides at all-guides.com P.C. BOARD TOP VIEW MODULE NAME PARTS NO. PANEL POWER SUPPLY ASS'Y LJ44-00025A - 34 -...
Page 37
All manuals and user guides at all-guides.com P.C. BOARD TOP VIEW MODULE NAME PARTS NO. POWER INPUT MODULE ASS'Y LJ92-00579A - 35 -...
Page 38
All manuals and user guides at all-guides.com P.C. BOARD TOP VIEW MODULE NAME PARTS NO. INTERFACE BOARD- X ASS'Y LJ92-00568B - 36 -...
Page 39
All manuals and user guides at all-guides.com P.C. BOARD TOP VIEW MODULE NAME PARTS NO. LOGIC E-BUFFER ASS'Y LJ92-00581A - 37 -...
Page 40
All manuals and user guides at all-guides.com P.C. BOARD TOP VIEW MODULE NAME PARTS NO. Y AMP BOARD-UPPER ASS'Y LJ92-00570A - 38 -...
Page 41
All manuals and user guides at all-guides.com P.C. BOARD TOP VIEW MODULE NAME PARTS NO. Y AMP BOARD-LOWER ASS'Y LJ92-00571A - 39 -...
Page 42
All manuals and user guides at all-guides.com P.C. BOARD TOP VIEW MODULE NAME PARTS NO. LOGIC F-BUFFER ASS'Y LJ92-00582A - 40 -...
Page 43
All manuals and user guides at all-guides.com P.C. BOARD TOP VIEW MODULE NAME PARTS NO. PDP PANEL MODULE ASS'Y VVEPP42SD001F-- - 41 -...
Page 59
All manuals and user guides at all-guides.com SCHEMATIC DIAGRAM +24V 330uH P24V TO AUDIO PWB CP031C-EJST- C333 SB5V 220uF C380 C334 0.22uF 0.22uF CP031A-EJST- P[2] L_IN P[2] R_IN AO_SEL P[9] L_OUT SDA2 SDA2 P[1,2,3,5,9] 10uH RFILN1020-1---A R_OUT SCL2 SCL2 P[1,2,3,5,9] A_MUTEn P[9] SUB_WFR SURR1...
Page 60
All manuals and user guides at all-guides.com SCHEMATIC DIAGRAM L_IN 12V_0 FROM AV SELECTOR R_IN 120K 22uF 2 .2uF 1/16W 1/16W 2SC24 12KBQ SURR1 SURR1 MUTE_1 MUTE_1 SURR2 1/2 VCC SURR2 2 .2uF 220K 1/2 VCC 3.9K 1/16W 1/16W 120K 1.5K 10uF ICA1...
Page 61
All manuals and user guides at all-guides.com SCHEMATIC DIAGRAM 12V_0 12V_0 47uF ICS1 NJM4558M MUTE_1 MUTE_1 ICS2 1/2VCC TC4W53FU 1/2VCC 1/16W 1/16W 10uF SUB_WOOFER OUT SUB_WFR SUB_WFR 0.1uF 1/16W 1/16W 10uF 1/16W 1/16W 1/16W 0.047uF Title SUB_WOOFER Size Document Number DPWB11372-1G-S- Date: Monday , July 29, 2002...
Page 62
All manuals and user guides at all-guides.com SCHEMATIC DIAGRAM M1076-1---- L O/P J24A L_OUT P1159-1-4-C DVI L S2_C DVI_L 1000PF 1/8W FE30 CE25 RE25 CE31 N/75 ZDA1 1000PF 2.2uF 1/8W UDZ5.1B 1/8W 1/16W M1076-1---- R O/P P1177-1---- R_OUT J24C P1159-1-4-C 1000PF DVI R DVI_R...
Sub-Con Location Projected Projected Curren Designator / Part # y Per MTBF Final Revisio Assemb n Level 1 Image Board Sampo DPWB11393-1G--S 2 AC Master Power Switch Sampo DPWB11398-1G--- Board 3 Audio Amplifier Board Sampo DPWB11372-1G-S- 4 Front Button Control Sampo...