Page 1: Colour Television
All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Published by EL 0770 BU CD Customer Service...
Page 2: Overview
EN 2 Q528.1A LA Technical Specifications, Connections, and Chassis Overview 1. Technical Specifications, Connections, and Chassis Overview Index of this chapter: 1.1.3 Multimedia 1.1 Technical Specifications 1.2 Connections Supported file formats : JPEG 1.3 Chassis Overview : MP3 : Slideshow (.alb) Notes: •...
Page 3: Rear Connectors
Technical Specifications, Connections, and Chassis Overview Q528.1A LA EN 3 Connections Side Rear connectors MONITOR DIGITAL AUDIO ANALOG AUDIO IN SERVICE AV 3 VGA / HDMI 1 / HDMI 2 UART VIDEO AUDIO AUDIO DISPLAY VIDEO AUDIO SYNC. DISPLAY SYNCHRONIZED AV 2 VIDEO AUDIO...
Page 4 EN 4 Q528.1A LA Technical Specifications, Connections, and Chassis Overview AV1: S-Video (Hosiden): Video Y/C - In Wh - Audio L 0.5 V / 10 kohm - Ground Y Ye - Video CVBS / 75 ohm - Ground C - Video Y / 75 ohm AV1: Cinch: Video YPbPr - In - Video C...
Page 5 Technical Specifications, Connections, and Chassis Overview Q528.1A LA EN 5 SMALL SIGNAL BOARD DFI PANEL DISPLAY SUPPLY STANDBY/AUDIO PANEL PANEL KEYBOARD CONTROL PANEL SIDE I/O PANEL IR & LED PANEL H_16790_075.eps 111007 Figure 1-6 PWB/CBA locations 42" Aurea styling sets DFI PANEL DISPLAY SUPPLY PANEL...
Page 6: Safety Instructions, Warnings, And Notes
Be careful during measurements in the high voltage by the workshop during a repair: section. • Use only lead-free soldering tin Philips SAC305 with order • Never replace modules or other components while the unit code 0622 149 00106. If lead-free solder paste is required, is switched “on”.
Page 7: Directions For Use
2006 week 17). The 6 last digits contain the It is easy to do, and is a good service precaution. serial number. 3. Directions for Use You can download this information from the following websites: http://www.philips.com/support http://www.p4c.philips.com...
Page 8: Mechanical Instructions
EN 8 Q528.1A LA Mechanical Instructions 4. Mechanical Instructions Index of this chapter: • Figures below can deviate slightly from the actual situation, 4.1 Cable Dressing due to the different set executions. 4.2 Service Positions • Follow the disassemble instructions in described order. 4.3 Assy/Panel Removal ME7 styling They apply to the 47"...
Page 9 Mechanical Instructions Q528.1A LA EN 9 H_16790_058.eps 220807 Figure 4-2 Cable dressing 42” ME7 styling sets H_16790_076.eps 111007 Figure 4-3 Cable dressing 42" Aurea styling sets...
Page 10 EN 10 Q528.1A LA Mechanical Instructions H_16790_060.eps 220807 Figure 4-4 Cable dressing 47" sets Service Positions The foam bars (order code 3122 785 90580 for two pieces) can be used for all types and sizes of Flat TVs. See figure “Foam bars”...
Page 11 Mechanical Instructions Q528.1A LA EN 11 Important: For (older) FTV sets without these “mushrooms”, it Warning: Most sets have additional doors located in the rear is obligatory to use the provided screws, otherwise it is possible cover. These are meant for disconnecting the flat cables to the to damage the monitor inside! AmbiLight units in the rear cover, before the rear cover is lifted from the set.
Page 12 EN 12 Q528.1A LA Mechanical Instructions 4.3.2 Side I/O Board Refer to figure “Side I/O Board” for details. 1. Unplug connectors [1]. 2. Remove screw [2]. 3. Push brackets [3], lift the PWB and slide it to the left out of its casing.
Page 13 Mechanical Instructions Q528.1A LA EN 13 During re-assembly, refer to figure “Cable dressing 47" sets” earlier in this chapter for the correct cable dressing! H_16770_089.eps 130707 Figure 4-14 Speakers 4.3.6 Display Supply Panel - 42" sets Refer to figure “Display Supply Panel - 42" sets” for details. 1.
Page 14 EN 14 Q528.1A LA Mechanical Instructions 4.3.9 Small Signal Board (SSB) 4.3.10 AmbiLight Unit Caution: it is mandatory to remount all different screws at their The AmbiLight Units are located in the back cover. Refer to original position during re-assembly. Failure to do so may result figure “AmbiLight Unit”...
Page 15 Mechanical Instructions Q528.1A LA EN 15 H_16770_095.eps 130707 Figure 4-21 LCD Panel -1- H_16770_096.eps 120707 Figure 4-22 LCD Panel -2-...
Page 16 EN 16 Q528.1A LA Mechanical Instructions H_16770_097.eps 130707 Figure 4-23 Central Sub-frame...
Page 17 Mechanical Instructions Q528.1A LA EN 17 Assy/Panel Removal Aurea Styling Refer to next figures for details. Note: Pictures in this section are taken from European chassis (only difference: use of another Small Signal Board). 4.4.1 Rear Cover Warning: Disconnect the mains power cord before you remove the rear cover.
Page 18 EN 18 Q528.1A LA Mechanical Instructions 4.4.3 Stand Removal Refer to next figures for details. 1. Place the set in the service position. 2. Remove the screws [1] and pull the stand downwards out of its support. 3. Remove the screws [2] and lift out the support. H_16801_106.eps 270807 Figure 4-27 Stand removal [1/2]...
Page 19 Mechanical Instructions Q528.1A LA EN 19 4.4.5 Ambilight LED Panel Removal 1. Unplug the connectors [1]. 2. Remove the screws [2] and [3]. 3. Pull the panel forward and lift them from the sub-frame. The set contains two different Ambilight LED panels. A four When defective, replace the whole unit.
Page 20 EN 20 Q528.1A LA Mechanical Instructions 4.4.6 Subframe Removal Refer to next figure for details. 1. Do NOT forget to unplug the LVDS connector [1] from the SSB. Important: Be careful, as this is a very fragile Before the Subframe can be removed, please remove the connector! Ambilight Reflector and Low-range Speaker as described 2.
Page 21 Mechanical Instructions Q528.1A LA EN 21 4.4.7 Rim removal 4.4.8 IR & LED Board For replacing the Keyboard Control Board, the IR & LED board, For replacing the IR & LED Board, the Subframe and the Rim the Tweeters and the LCD panel, the Subframe and Rim have have to be removed first.
Page 22 EN 22 Q528.1A LA Mechanical Instructions 4.4.10 Tweeters removal Caution: The tweeters should never be connected or disconnected when the set is playing! This can damage the amplifiers on the Audio/Standby Board. For replacing the IR & LED Board, the Subframe and the Rim have to be removed first.
Page 23 Mechanical Instructions Q528.1A LA EN 23 1. Unplug the LVDS connector [1]. Caution: be careful, as this is a very fragile connector! 2. Unplug the connectors [2]. 3. Remove the screws [3]. 4. Remove the parker screws [4]. 5. Remove the tapping screws [5]. The SSB can now be taken out of the set.
Page 24 EN 24 Q528.1A LA Mechanical Instructions 4.4.15 Audio and Ambilight supply panel Refer to next figures for details. 1. Unplug the connectors [1]. 2. Remove the screws [2]. The Audio and Ambilight supply panel can now be taken out of the set.
Page 25: Service Modes, Error Codes, And Fault Finding
Service Modes, Error Codes, and Fault Finding Q528.1A LA EN 25 5. Service Modes, Error Codes, and Fault Finding Index of this chapter: – Picture mute (blue mute or black mute). 5.1 Test Points – Automatic volume levelling (AVL). 5.2 Service Modes –...
Page 26 Contents of SAM: Code • Hardware Info. – A. SW Version. Displays the software version of the main software (example: Q581E-1.2.3.4 = 39mm PHILIPS AAAAB_X.Y.W.Z). MODEL: • AAAA= the chassis name. 32PF9968/10 PROD.SERIAL NO: • B= the region: A= AP, E= EU, L= LatAm, U = US.
Page 27 Service Modes, Error Codes, and Fault Finding Q528.1A LA EN 27 • Switch the set to STAND-BY via the RC-transmitter. - Seven last characters of the 12NC of the SSB itself. - the serial number of the SSB, which consists of seven digits.
Page 28 EN 28 Q528.1A LA Service Modes, Error Codes, and Fault Finding • HDMI key validity. Indicates if the HDMI keys (or HDCP keys) are valid or not. In case these keys are not valid and the customer wants to make use of the HDMI functionality, the SSB has to be replaced.
Page 29 Service Modes, Error Codes, and Fault Finding Q528.1A LA EN 29 Stepwise Start-up due to overvoltage. It is recommended to measure first the FET 7U01 on short-circuit before activating SDM via the service pads. There are two possible situations: one for protections detected When the TV is in protection state due to an error detected by by the stand-by software and one for protections detected by main software (MIPS protection) and SDM is activated via...
Page 30 EN 30 Q528.1A LA Service Modes, Error Codes, and Fault Finding Off/Stby to Semi Stand by or Protection Mains is applied Standby Supply starts running. All standby supply voltages become available . action holder: MIPS action holder: St-by st-by µP resets If the protection state was left by short circuiting the SDM pins, detection of a protection condition during autonomous action...
Page 31 Service Modes, Error Codes, and Fault Finding Q528.1A LA EN 31 The supply fault line is an OR SUPPLY-FAULT I/O line Supply fault error function of DCDC, DCDC5050 is High? and POD/CI supply switch. Enable the supply fault detection algorithm Set I²C slave address This will allow access to NVM and of Standby µP to (A0h)
Page 32 EN 32 Q528.1A LA Service Modes, Error Codes, and Fault Finding switch off the remaining DC/DC Log power-ok error and enter Power-ok display high ? converters protection Switch POD-MODE and ON-MODE 3-th try? I/O line high. Reset the Pacific by pulling LOW the Pacific hardware reset line during 100ms.
Page 33 Service Modes, Error Codes, and Fault Finding Q528.1A LA EN 33 action holder: AVC action holder: St-by autonomous action Semi Standby Wait until previous on-state is left more than 2 seconds ago. (to prevent LCD display problems) Assert RGB video blanking and audio mute Rewrite Pacific register 0x03 (output format) : this command is sometimes not processed properly by the...
Page 34 EN 34 Q528.1A LA Service Modes, Error Codes, and Fault Finding action holder: AVC action holder: St-by autonomous action Semi Standby Wait until previous on-state is left more than 2 seconds ago. (to prevent LCD display problems) Assert RGB video blanking and audio mute Setting the display related timings of the DFI is not needed: The display related timings are hardcoded in the DFI...
Page 35 Service Modes, Error Codes, and Fault Finding Q528.1A LA EN 35 action holder: AVC Active action holder: St-by autonomous action Mute all sound outputs via softmute Wait 100ms Set main amplifier mute (I/O: audio-mute) Force ext audio outputs to ground (I/O: audio reset) And wait 5ms switch off LCD backlight...
Page 36 EN 36 Q528.1A LA Service Modes, Error Codes, and Fault Finding action holder: MIPS Active action holder: St-by autonomous action Mute all sound outputs via softmute Wait 100ms Set main amplifier mute (I/O: audio-mute) Force ext audio outputs to ground (I/O: audio reset) And wait 5ms switch off LCD backlight...
Page 37 Service Modes, Error Codes, and Fault Finding Q528.1A LA EN 37 Semi Stand by action holder: MIPS action holder: St-by autonomous action If ambientlight functionality was used in semi -standby (lampadaire mode), switch off ambient light *) If this is not performed and the set is Delay transition until ramping down of ambient light is switched to standby when the switch off of finished.
Page 38 EN 38 Q528.1A LA Service Modes, Error Codes, and Fault Finding action holder: MIPS action holder: St-by autonomous action Log the appropriate error and set stand-by flag in NVM Redefine wake up reasons for protection state and transfer to stand-by µP. Switch off LCD lamp supply Wait 250ms (min.
Page 39: Error Codes
ComPair Note: If you encounter any problems, contact your local support desk. Introduction ComPair (Computer Aided Repair) is a Service tool for Philips 5.4.2 LVDS Tool Consumer Electronics products. and offers the following: 1. ComPair helps you to quickly get an understanding on how Support of the LVDS Tool has been discontinued.
Page 40 EN 40 Q528.1A LA Service Modes, Error Codes, and Fault Finding 5.5.4 Error Buffer blocked bus. The best way for further diagnosis here, is to use ComPair (e.g. read out the NVM content). Instead of error “3” it is possible you will see error “2” in the error In case of non-intermittent faults, clear the error buffer before buffer.
Page 41: The Blinking Led Procedure
Service Modes, Error Codes, and Fault Finding Q528.1A LA EN 41 The Blinking LED Procedure Protections 5.6.1 Introduction 5.7.1 Software Protections The blinking LED procedure can be split up into two situations: Most of the protections and errors use either the stand-by •...
Page 42 EN 42 Q528.1A LA Service Modes, Error Codes, and Fault Finding 5.8.3 • Symptom: +1V4 not present (even for a short while ~10ms) while +12V is okay (also across input capacitors 2U6S and 2U6R). When you activate CSM and there is a USB stick connected to 1.
Page 43 Service Modes, Error Codes, and Fault Finding Q528.1A LA EN 43 5.8.5 Exit “Factory Mode” When an “F” is displayed in the screen's right corner, this means that the set is in “Factory” mode, and it normally happens after a new SSB has been mounted. To exit this mode, push the “VOLUME minus”...
Page 44 EN 44 Q528.1A LA Service Modes, Error Codes, and Fault Finding 5.8.10 SSB Replacement Follow the instructions in the flowchart in case you have to exchange the SSB. See figure “SSB replacement flowchart”. START Set is still operating? Activate SAM and save the TV settings via “Upload to USB”...
Page 45 Service Modes, Error Codes, and Fault Finding Q528.1A LA EN 45 5.8.11 Display option code Caution: In case you have replaced the SSB, always check the display option code in SAM, even if you have picture. With a wrong display option code it is possible that you have picture, but that in certain conditions you have unwanted side-effects.
Page 46 1. Disconnect the TV from the Mains/AC Power. must be placed in the root of your USB stick. 2. Press the “CURSOR DOWN” button on a Philips DVD RC- How to upgrade: 6 remote control (it is also possible to use the TV remote in 1.
Page 47 Service Modes, Error Codes, and Fault Finding Q528.1A LA EN 47 5.9.3 Stand-by Software Upgrade 5.9.4 Content and Usage of the One-Zip Software File There are two methods now to upgrade stand-by software: Below you find a content explanation of the One-Zip file, and instructions on how and when to use it.
Page 48 EN 48 Q528.1A LA Service Modes, Error Codes, and Fault Finding Personal Notes: E_06532_012.eps 131004...
Page 49: Waveforms Wiring Diagram 32" Lcd
Block Diagrams, Test Point Overview, and Waveforms Q528.1A LA 6. Block Diagrams, Test Point Overview, and Waveforms Wiring Diagram 32” LCD WIRING 32” LCD (STYLING ME7) DISPLAY SUPPLY (1050) LCD DISPLAY (1004) lLVDS 8411 CONNECTOR 8402 8738 8150 1G50 1735 1P11 1M59 1P02...
Page 50: Wiring Diagram 42" Lcd
Block Diagrams, Test Point Overview, and Waveforms Q528.1A LA Wiring Diagram 42” LCD WIRING 42” LCD + DFI + AMBI LIGHT (STYLING ME7) LCD DISPLAY (1004) 8316 8682 8509 8402 8590 DFI PANEL DISPLAY SUPPLY 1M09 1319 LVDS LVDS 8609 1317 8252 8250...
Page 51 Block Diagrams, Test Point Overview, and Waveforms Q528.1A LA Wiring Diagram 47” WIRING 47” LCD + DFI + AMBI LIGHT (STYLING ME7) LCD DISPLAY (1004) 8316 8682 8509 8402 8590 DFI PANEL 1M12 1317/1321 1M90 13P14 LVDS LVDS 1316/1319 8609 8252 8250 8659...
Page 52: Wiring Diagram 42" (Aurea)
Block Diagrams, Test Point Overview, and Waveforms Q528.1A LA Wiring Diagram 42” (AUREA) WIRING 42” LCD + DFI + AMBI LIGHT Styling AUREA 1M80 1M80 1M80 1M81 1M81 1M81 AMBILIGHT MODULE AMBILIGHT MODULE AMBILIGHT MODULE (1045) (1046) (1045) 8000 8000 LCD DISPLAY (1004) 8681...
Page 53 Block Diagrams, Test Point Overview, and Waveforms Q528.1A LA Block Diagram Supply 32” DISPLAY SUPPLY + PLATFORM SUPPLY 32" MAINS FILTER + STANDBY SUPPLY MAINS FILTER + STANDBY 3057 7002 TCET1102 BIAS SUPPLY 3100 5401 5403 1450 5405 3810 3000 6079 6077 3033...
Page 54 Block Diagrams, Test Point Overview, and Waveforms Q528.1A LA Block Diagram Supply 37” - 42” SUPPLY 37”- 42" MAINS FILTER + STANDBY SUPPLY DC-DC 3057 3065 3407 +12V 5401 7402 7002 TCET1102 BIAS SUPPLY 5305 2327 7401 3000 3075 5306 3318 6304 5017...
Page 55 Block Diagrams, Test Point Overview, and Waveforms Q528.1A LA Block Diagram Supply 47” SUPPLY 47"- 52” SANKEN 1308 Mains connected. 1P10 Mains separated 1M12 1317/1321 1 VAC_Neutral 1 DIM-control 2 VAC_Live 2 Power Good 1P15 1M09: Mains separated 3 ON/OFF 1316/1319 1M90 1 +12Va...
Page 56: Block Diagram Supply Audio & Ambilight
Block Diagrams, Test Point Overview, and Waveforms Q528.1A LA Block Diagram Supply Audio & AmbiLight AUDIO AND AMBIENT SUPPLY (ONLY FOR AUREA SET) AUDIO AND AMBIENTLIGHT SUPPLY AP2A AUDIO: LEFT / RIGHT 5P40 1P22 1P03 5P16 6P10 1P06 +12-15V 5P06 5P10 5P20 AP2b...
Page 57: Block Diagram Video
Block Diagrams, Test Point Overview, and Waveforms Q528.1A LA Block Diagram Video VIDEO B03B B05C B06C B06A MAIN TUNER PNX85xx PNX5050: VIDEO PACIFIC 3 PACIFIC 3: LVDS 1G50 7C00 7GE2 7H00 PNX5050EH/M1 T6TF4HFG PNX8537E/M2A VDISP 10-bit YUV 10-bit RGB B04K ANALOGUE AV B04O DIGITAL...
Page 58: Block Diagram Audio
Block Diagrams, Test Point Overview, and Waveforms Q528.1A LA Block Diagram Audio AUDIO B03B B04Q MAIN TUNER PNX85xx PNX85xx: FLASH 7J00 7T57 PNX8537E TDA9898HL 1T65 B04K ANALOGUE AV IF-FILTN3 IF3-B 7HA0 IF-FILTP3 PNX85xx NAND512W3A2BN6E IF3-A 1T04 SAW 38MHz9 Audio AP TD1716F/IHXP B04F CONTROL...
Page 59: Block Diagram Control & Clock Signals
Block Diagrams, Test Point Overview, and Waveforms Q528.1A LA Block Diagram Control & Clock Signals CONTROL + CLOCK SIGNALS B05B PNX5050: SDRAM PNX 85xx: B04G PNX 85xx SDRAM B08F HDMI SWITCH 7H00 7CA0 PNX8537E 7J27 K4D551638F SDRAM 7C00 B04G AD8191ASTZ 7CA1 PNX5050EH/M1 K4D551638F...
Page 60 Block Diagrams, Test Point Overview, and Waveforms Q528.1A LA SSB: Test Points (Overview Top Side) I133 D4 I148 D3 I238 G2 I240 G2 I737 D4 I738 E2 I739 E3 I740 E2 I741 E2 I742 E3 I743 E1 I744 F2 I745 E2 I746 A5 I747 A5 I748 E2...
Page 61 Block Diagrams, Test Point Overview, and Waveforms Q528.1A LA SSB: Test Points (Part 1 Top Side) Part 1 H_16800_081a.eps 070507...
Page 62 Block Diagrams, Test Point Overview, and Waveforms Q528.1A LA SSB: Test Points (Part 2 Top Side) Part 2 H_16800_081b.eps 030507...
Page 63 Block Diagrams, Test Point Overview, and Waveforms Q528.1A LA SSB: Test Points (Overview Bottom Side) F179 E4 F289 D1 FE80 G2 FHP3 E3 FU00 D2 I177 E2 I287 B3 I397 D4 I507 B1 I617 G3 I727 E1 ID13 B1 IEA9 F2 IH91 E3 IHV5 E5 IP02 A4...
Page 64 Block Diagrams, Test Point Overview, and Waveforms Q528.1A LA SSB: Test Points (Part 1 Bottom Side) Part 1 H_16800...
Page 65 Block Diagrams, Test Point Overview, and Waveforms Q528.1A LA SSB: Test Points (Part 2 Bottom Side) Part 2 H_16800_082b.eps 070507...
Page 66: I2C Ic Overview
Block Diagrams, Test Point Overview, and Waveforms Q528.1A LA I2C IC Overview I²C B04E PNX8535: CONTROL B08F HDMI SWITCH B08D HDMI B06C PACIFIC 3 B03A CHANNEL DECODER B03B MAIN TUNER +3V3-PER 3HPJ 9T21 AJ27 SDA3 SDA-SSB SDA-SSB1 I2C3-SDA 3HPH 9T22 AJ28 SCL3 SCL-SSB...
Page 67: Supply Lines Overview
Block Diagrams, Test Point Overview, and Waveforms Q528.1A LA Supply Lines Overview SUPPLY LINES OVERVIEW B06A PACIFIC 3: LVDS B10A USB 2.0 AB06 FPGA DFI B01A SUPPLY B02B DC / DC B04F PNX85xx: CONTROL 2B48 VDISP +3V3 +3V3 2V5-DDR2 2V5-DDR2 VDISP B06b B02a...
Page 68 Circuit Diagrams and PWB Layouts Q528.1A LA 7. Circuit Diagrams and PWB Layouts Display Supply (32”): Part 1 1006 F3 9811 D12 1011 A6 9812 F12 1308 C1 9813 D12 DISPLAY SUPPLY: PART1 1317 G2 9814 D12 1319 G3 9816 G8 1320 G3 F401 G3 1400 C2...
Page 69 Circuit Diagrams and PWB Layouts Q528.1A LA Display Supply (32”): Part 2 1002 G13 3064 F3 F299 B8 1004 H10 3065 E4 F300 F9 DISPLAY SUPPLY: PART2 1005 F9 3066 F2 I001 B8 1009 H10 3067 H1 I002 C8 COLD GROUND 2000 E9 3068 H3 I003 C7...
Page 70 Circuit Diagrams and PWB Layouts Q528.1A LA Layout Display Supply Panel (32”) (Top Side) 1002 A7 1320 A10 1M90 C10 2005 A7 2022 A9 2403 B1 2806 B5 3017 C7 3082 A9 3451 A3 5007 B6 5026 A10 5406 C10 6032 B11 7005 C6 9005 B3...
Page 71 Circuit Diagrams and PWB Layouts Q528.1A LA Layout Display Supply Panel (32”) (Bottom Side) 2001 B1 2019 A6 2030 A2 2047 A5 2064 A5 2807 B7 3007 A6 3019 C5 3029 C6 3038 A2 3048 A6 3066 A6 3077 A1 3424 A8 3803 B7 6005 A5...
Page 72 Circuit Diagrams and PWB Layouts Q528.1A LA Display Supply (42”): Mains Filter & Standby 1003 B4 1303 C4 1350 C9 2301 C4 2309 E13 2315 C12 2320 D12 2327 B10 3300 C3 3305 C4 3310 B13 3316 D6 3321 E10 3326 H9 5303 D6 5308 D12...
Page 73 Circuit Diagrams and PWB Layouts Q528.1A LA Display Supply (42”): Supply 1109 F12 3025 E12 6043 F13 I019 H7 1110 F13 3026 E12 6044 E13 I020 F3 1113 F12 3027 G2 6045 H8 I021 E1 SUPPLY 1114 A3 3028 G4 6069 G13 I022 F2 1115 H9...
Page 74 Circuit Diagrams and PWB Layouts Q528.1A LA Display Supply (42”): DC - DC 1400 E7 I617 D1 2401 B4 I618 D2 DC-DC 2402 B4 I619 D2 2403 D3 I620 D1 2404 E4 I621 D5 2405 C7 I622 B3 2406 B8 I623 E7 2407 C5 I624 C5...
Page 75 Circuit Diagrams and PWB Layouts Q528.1A LA Layout Display Supply (42”) (Top Side) 1003 E2 1310 D10 1400 E9 2000 B7 2020 F8 2070 A9 2311 D3 2323 E2 3018 F5 3084 A10 3308 F3 5001 E4 5011 A7 5027 E6 5401 E9 6074 D9 7305 B5...
Page 76 Circuit Diagrams and PWB Layouts Q528.1A LA Layout Display Supply (42”) (Bottom Side) 1114 F4 2018 C2 2030 B2 2042 C2 2053 D6 2064 B2 2332 A3 2410 E1 3008 E6 3021 C6 3035 D6 3045 D6 3056 E5 3069 E1 3095 F1 3321 C6 3401 E1...
Page 77 Circuit Diagrams and PWB Layouts Q528.1A LA DFI Panel: DC - DC 1M09 E13 1U13 D14 2U06 A9 2U13 C7 2U20 D5 2U27 E8 2U34 G2 2U41 A8 3U07 B3 3U14 C3 3U21 B5 3U28 F11 3U36 D6 3U46 E8 3U62 F7 3U73 G10 5U05 C12...
Page 78 Circuit Diagrams and PWB Layouts Q528.1A LA DFI Panel: Video Flow 1F50 C1 2F06 F6 2F0F C6 2F0P B12 2F0Z D12 2F1J F12 2F1T H12 2F82 H6 2F9B B3 2FGK D3 3F57 F5 3F61 B5 3F6A D5 3F7N H11 3F8C B11 3F8M C11 3F8W E11 3F96 D3...
Page 79 Circuit Diagrams and PWB Layouts Q528.1A LA DFI Panel: Clock 2FD1 C3 2FD2 C6 CLOCK AB03 AB03 2FD3 F3 2FD4 G5 3F26 C4 3FA9 D4 3FH0 C4 3FH1 C4 3FHV C7 3FHY C7 3FJA F2 3FJB G3 3FJC F6 5F20 B6 5F21 E3 5F22 F6 5F80 B3...
Page 80 Circuit Diagrams and PWB Layouts Q528.1A LA DFI Panel: Supply 2F17 B3 2F18 B4 2F19 B3 2F21 B3 7F35 A3 7F36 B3 9F13 A2 IF10 A2 IF1U A3 Personal Notes: SUPPLY AB04 AB04 7F35 LD3985M25 IF10 9F13 +2V5-STAB +3V3 IF1U 7F36 RES LD1117DT25 +12V...
Page 81 Circuit Diagrams and PWB Layouts Q528.1A LA DFI Panel: FPGA: Power & Control 1F00 F13 IFA2 B9 1F05 C12 IFA3 C9 FPGA: POWER + CONTROL 2FGF B5 IFA4 D9 AB05 AB05 2FGG B5 IFA5 C1 2FGH B5 IFA6 I10 2FGJ B6 IFA7 G8 2FGM B6 IFA9 G7...
Page 82 Circuit Diagrams and PWB Layouts Q528.1A LA DFI Panel: FPGA: DFI 2F36 F8 2F37 F10 FPGA DFI AB06 AB06 2F38 F12 2F39 F13 2F40 I8 2F41 I10 2F42 I12 2F43 I13 +2V5-DDR2 +2V5-DDR2 3F40 E1 3F49 E1 +1V2-PLL +2V5out-FPGA 3FA0 E1 7F18-2 7F18-1 3FA1 E3...
Page 83 Circuit Diagrams and PWB Layouts Q528.1A LA DFI Panel: DDR A 2F5A B2 2F5B B2 DDR A AB07 AB07 2F5C B5 2F5D B5 2F5E B5 2F5F B5 2F5G B7 2F5H B7 2F5J B7 2F5K B8 2F5L B10 2F5M B11 2F5N C10 2F5P C2 +2V5-DDR1 +2V5-DDR1...
Page 84 Circuit Diagrams and PWB Layouts Q528.1A LA DFI Panel: DDR B 2CBC B5 DDR B 2CBD B5 AB08 AB08 2CBH B7 2CBK B7 2FGA H7 2FGB H7 2FGC H8 2FGD H8 2FGE H8 2FLW H6 2FLY H6 2FLZ H7 2V00 C2 +2V5-DDR2 +2V5-DDR2 +2V5-DDR2...
Page 85 Circuit Diagrams and PWB Layouts Q528.1A LA DFI Panel: Display Interfacing 1F04 D11 2F2A D5 2F2G F6 2F2Q F11 2F45 F12 3F15 H12 3F1Y D4 3F24 B11 3F2B E5 3F2V E5 3F3B F11 3FH5 D11 5F0L B6 5F14 F13 6F05 B12 7F08 C5 9F26 H12 9F2H B11...
Page 86 Circuit Diagrams and PWB Layouts Q528.1A LA DFI Panel: FPGA Ambilight 1F02 E12 7F01 C2 1F03 I5 7F60 E5 2F10 B3 7F61 H13 2F11 B4 7F62 G3 FPGA AMBILIGHT 7F65-2 AB10 AB10 XC3S250E-4FTG256C 2F12 B4 7F65-1 F7 Φ 2F13 B4 7F65-2 A7 2F14 G9 7F65-3 A10...
Page 87 Circuit Diagrams and PWB Layouts Q528.1A LA Layout DFI Panel (Top Side) 1F00 C1 3CE2 B3 3F7A B1 5F0J A4 1F02 C2 3F05 C1 3F7B C1 5F0K A3 1F03 A1 3F14 C3 3F7G C1 5F0L A3 1F04 A4 3F15 C3 3F7H C1 5F0M A3 1F05 C3...
Page 88 Circuit Diagrams and PWB Layouts Q528.1A LA Layout DFI Panel (Bottom Side) 1U01 C1 2F5G B4 2FJA A3 3F43 C3 5F33 C3 1U02 C1 2F5H B4 2FJB B3 3F46 C3 5F34 B3 2CBC B2 2F5J B4 2FJC A3 3F47 C3 5F51 B2 2CBD B2 2F5K B4...
Page 89 Circuit Diagrams and PWB Layouts Q528.1A LA AmbiLight Panel (5 LED) 0100 I4 3151 H10 I062 E12 0101 I3 3152 H12 I063 F10 2001 E1 3153 H12 I065 F11 2002 E6 3160 F10 I066 F12 AMBILIGHT 5 LED 2003 E11 3161 F11 I067 F12 2004 H6...
Page 90 Circuit Diagrams and PWB Layouts Q528.1A LA AmbiLight Panel (5 LED) 1004 E2 F020 A1 AMBILIGHT 5 LED 1010 B7 F021 A1 1M00 C4 F022 A2 +3V3 +3V3 +3V3 +3V3 1M80 A1 F023 A2 1M81 B1 F024 A2 2028 2019 B5 F025 B2 1M80 F019...
Page 91 Circuit Diagrams and PWB Layouts Q528.1A LA Layout AmbiLight Panel (5 LED) (Overview Top Side) 1004 -- 2007 -- 2022 -- 2032 -- 2050 -- 3001 -- 3011 -- 3021 -- 3032 -- 3042 -- 3054 -- 3082 -- 3092 -- 3106 -- 3116 -- 3130 --...
Page 92 Circuit Diagrams and PWB Layouts Q528.1A LA AmbiLight Panel (3 Side 4 LED) 0100 F10 6014 H7 0101 G10 7001-1 A2 AMBILIGHT 3 SIDE 4 LED 2001 E2 7001-2 B12 7005-1 UE-HP660XAB-16T 2002 E7 7002-1 A4 2004 H6 7002-2 C12 GREEN 2007 F2 7003-1 A7...
Page 93 Circuit Diagrams and PWB Layouts Q528.1A LA AmbiLight Panel (3 Side 4 LED) 1004 E2 F021 A1 1010 B8 F022 A2 AMBILIGHT 3 SIDE 4 LED 1M00 C4 F023 A2 1M80 A1 F024 A2 1M81 B1 F025 B2 +3V3 +3V3 +3V3 +3V3 2019 B5...
Page 94 Circuit Diagrams and PWB Layouts Q528.1A LA Layout AmbiLight Panel (3 x 4 LED) (Overview Top Side) 1010 2010 2025 2036 2054 3005 3014 3036 3046 3057 3067 3076 3087 3100 3109 3118 3142 3185 3203 6006 7004 7068 9004 9020 9101 1M00 --...
Page 95 Circuit Diagrams and PWB Layouts Q528.1A LA Audio & AL Supply Panel: Supply 0P01 G15 1P01 G4 1P22 B1 2P06 E10 2P15 C2 2P24 D15 2P33 H6 2P42 C12 2P51 H14 3P02 B13 3P14 D2 3P36 B6 3P50 C8 3P63 F12 3P75 F9 5P05 D9 5P14 C11...
Page 96 Circuit Diagrams and PWB Layouts Q528.1A LA Audio & AL Supply Panel: Audio 1735 G12 5D27 H13 1736 B12 7D00-1 C8 2D00 C7 7D00-2 G8 AUDIO: LEFT / RIGHT AP2A AP2A 2D01 C8 7D05 B9 2D02 C9 7D06 B9 2D03 D8 7D07 B9 2D04 D8 7D08 C9...
Page 97 Circuit Diagrams and PWB Layouts Q528.1A LA Audio & AL Supply Panel: Protection 0002 H12 1737 A11 AUDIO: PROTECTION / MUTE CONTROL 1738 C11 AP2B AP2B 2DD2 D7 2DD4 G6 2DD7 E5 2DF0 C4 2DF2 B5 2DF3 C5 2DF9 H11 1737 3DD0 H8 FD04...
Page 98 Circuit Diagrams and PWB Layouts Q528.1A LA Audio & AL Supply Panel: Subwoofer 1741 B10 2D52 C2 2D58 D1 2D64 D2 2D74 F6 2D80 F9 2D87 F8 3DK4 C11 3DL0 D6 3DL8 D9 3DM6 E3 3DN2 F3 3DN8 F4 5D12 C15 5D18 B9 7DK2 C4 7DL0-1 C12...
Page 99 Circuit Diagrams and PWB Layouts Q528.1A LA Audio & AL Supply Panel: Centre Input 2D89 D6 AUDIO: CENTRE INPUT / SW FILTER 2D90 B6 AP2D AP2D 2D95 B6 2D98 C6 2DC0 B7 2DC1 B7 3D51 D5 3D52 D6 3D81 B5 3D82 B6 7D40-1 B6 7D40-2 D7...
Page 100 Circuit Diagrams and PWB Layouts Q528.1A LA Layout Audio & AmbiLight Supply Panel (Top Side) 0002 A9 1M18 E4 1P07 C9 2D38 A9 2P10 D2 2P28 C9 3D15 B8 3P28 C4 3P60 C4 5D13 B6 5P02 A3 5P12 D7 5P30 E5 6P11 E7 9D07 B8 9D24 B7...
Page 101 Circuit Diagrams and PWB Layouts Q528.1A LA Layout Audio & AmbiLight Supply Panel (Bottom Side) 2D00 B2 2D17 A2 2D33 A1 2D49 A5 2D71 A4 2D89 B5 2DF3 B3 2P32 E2 2P50 E7 3D12 A2 3D29 B2 3D46 A3 3DF5 B3 3DH0 B3 3DK7 B5 3DM8 A4...
Page 102 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: Supply 1B10 E1 3B70 C4 IB52 E4 1B11 E7 3B71 B2 IB53 F4 SUPPLY 1B30 A3 3B72 B9 IB54 E5 B01A B01A 1B31 B3 3B73 B9 IB55 E6 1B32 A1 3B74 C9 IB56 E6 IB75 2B51...
Page 103 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: Supply 1B20 B4 1B21 B4 SUPPLY B01B B01B 1B22 B4 1B23 B4 1B24 C4 1B25 C4 1B26 C4 1B50 C6 1M59 F3 1P11 B3 2B20 B5 2B21 B5 2B22 B5 2B23 B5 2B24 C5 2B25 C5 BACKLIGHT-OUT...
Page 104 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: DC / DC 2U00 A3 2U10 B10 2U20 D6 2U30 F6 2U41 E11 3U00 A3 3U10 E13 3U21 C13 3U31 D6 3U41 D10 3U51 E13 3U61 E3 3U71 G9 3UA3 B8 5U03 E11 6U10 E4 7U10-1 E3 7U27 D13...
Page 105 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: DC / DC DC / DC B02B B02B 3U94 +5VS +5V-STANDBY +5V-STANDBY 2U38 7U02-1 7U02-2 IU70 +12V IU71 3U79 3U80 SI4936ADY SI4936ADY FU80 +12VS 100K 220K IU78 +5V-ON IU43 IU47 IU79 7U19 7U20 3U93 BC817-25W...
Page 106 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: DC / DC 2U59 B5 FU8A F12 2U60 C2 IU15 F2 DC/DC 2U61 C2 IU22 B3 B02C B02C 2U62 D2 IU37 F10 2U63 C1 IU69 E10 2U64 C2 IU6A E6 2U65 B3 IU6E B4 2U66 C4 IU6F D2...
Page 107 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: Channel DEcoder 2T01 B5 2T04 D5 2T05 D5 2T07 D8 CHANNEL DECODER B03A B03A 2T08 D9 2T09 D9 2T12 D11 2T13 D11 2T14 D11 2T15 D12 2T16 D11 2T17 E4 2T18 E8 2T19 E8 2T20 F6 2T21 F6...
Page 108: Main Tuner
Circuit Diagrams and PWB Layouts Q528.1A LA SSB: Main Tuner 1HE0 A14 1T71 E14 2T48 B9 2T60 F14 2T67 F1 2T74 G14 2T81 G11 2T88 F11 2T95 F11 3T42 C8 3T49 D9 3T57 F14 3T67 A9 3T76 E14 3T85 I9 6T41 C10 7T55 I10 9T52 G5...
Page 109 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: PNX85xx: Standby Controller 1HF0 A3 7H14 E3 2H00 B3 7H16 H10 PNX 8535: STANDBY CONTROLLER B04A B04A 2H01 D3 7H18 H11 2H05 G13 7H21 F13 2H06 C14 7H22 F12 2H07 C14 7H90 F4 2H08 F4 7H91 H4 +3V3-STANDBY...
Page 110 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: PNX85xx: Debug SSB: PNX85xx: NVM / UART Switch 9H20 A3 9H23 B3 9H26 B3 9H29 B3 9H32 B3 9H35 B3 9H38 C3 9H41 C3 9H44 C3 9H21 A3 9H24 B3 9H27 B3 9H30 B3 9H33 B3 9H36 B3...
Page 111 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: PNX85xx: Miscellaneous 2HD0 D2 PNX 85xx: MISCELLANEOUS 3HD0 D2 B04D B04D 3HD2 C3 3HD3 C2 3HDJ C5 3HDK C6 3HDL C6 3HDM C6 3HDN C7 3HDP C6 6HD0 C7 6HD1 C7 7HD0 C3 7HD1 C4 7HD6-1 C5 7HD6-2 C6...
Page 112 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: PNX85xx: Control 1HP0 D4 2HF2 C1 PNX85xx: CONTROL 2HF5 C7 B04E B04E +3V3-PER 2HF6 D7 2HF7 D8 2HF8 D8 2HP1 E4 3HF0 B5 3HF2 C7 7H00-4 RESET-SYS-DETECT 3HF3 A6 PNX85xx 3HF4 C7 MIPS C0NTROL 3HF9 B6 JTAG-TD-PNX8535-F E...
Page 113 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: PNX85xx: Control 3HES C7 PNX 85xx: CONTROL 3HET C7 B04F B04F 3HEU C5 3HEV B8 3HF5 B2 3HFA B7 3HFB B8 3HFC B7 3HFD B7 3HFE B7 3HFF B7 3HFZ C7 7H00-5 A3 9HF4 C7 7H00-5 9HF5 C7...
Page 114 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: PNX85xx: SDRAM 2HG0 E3 3HJ3 A12 PNX 85xx: SDRAM 2HG1 E3 3HJ4 B12 B04G B04G 2HG2 E3 3HJ5 A4 2HG3 E3 3HJ6 A1 3HJ5 IHG0 7H00-2 2HG4 E3 3HJ7 A1 +1V8 PNX85xx 2HG5 E4 3HJ8 A1 2HG6 E4...
Page 115 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: PNX85xx: Digital Video In Personal Notes: 3HK0 C2 7H00-3 B2 PNX 85xx: DIGITAL VIDEO IN B04H B04H 9HK0 C2 IHSM C2 7H00-3 PNX8535 HDMI RX2- RX_0 RX2+ HOT-PLUG HOT_PLUG RX1- RX1+ RX_1 RX0- RX0+ RX_2...
Page 116 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: PNX85xx: Audio 2HM3 D4 PNX 85xx: AUDIO B04I B04I 2HM4 D4 2HM5 E4 2HM8 E4 2HMG D2 2HMH D2 2HMJ A10 2HMN B10 AUDIO-VDD 2HMP C9 2HMT E9 2HMJ 2HMW G9 IHMY 2HMY H8 100n 2HMZ I9...
Page 117 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: PNX85xx: Analogue AV 2HA2 C4 3HSK A12 2HA3 C4 3HSL A10 PNX 85xx: ANALOGUE AV 2HA4 D4 3HSM B12 B04K B04K 2HA5 D4 3HSN B10 2HKL F4 3HSP C10 2HRZ A8 3HSQ C8 2HS0 A10 3HSR D10 2HS1 A8...
Page 118 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: PNX85xx: Audio 2HP4 E9 2HP5 E8 2HP6 E8 PNX 85xx: AUDIO 2HP7 E8 B04L B04L 2HP8 E7 2HPA E10 2HPB E9 2HR0 C4 2HR1 C5 2HR2 C4 2HR3 C5 2HR4 C4 2HR5 C4 2HR6 D4 2HR7 D4 2HR8 D4...
Page 119 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: PNX85xx: Audio 2HV2 C4 2HV3 D2 PNX 85xx: AUDIO B04M B04M 2HV4 C4 2HV6 C1 2HV7 B8 2HV9 C2 2HVA C1 2HVB B3 2HVC B3 2HVD C2 2HVE C1 2HVG D6 3HV3 D7 3HV4 B8 +3V3 3HV7 C8...
Page 120 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: PNX85xx: Video Streams 3HWK D2 3HWM C7 PNX 85xx: VIDEO STREAMS B04N B04N 3HWN C7 3HWP C7 3HWR C7 3HWS C7 3HWT C7 3HWU C7 3HWV B7 3HWW B7 3HWY B7 3HWZ B7 7H00-10 B5 9HW0 D2 IHW0 D2...
Page 121 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: PNX85xx: Digital Video 1F00 B7 3HP9 C5 PNX85xx: DIGITAL VIDEO OUT / LVDS B04O B04O 7H00-7 B4 7H00-8 A1 9HP9 B6 9HW3 B2 9HW4 B2 9HW5 B2 9HW6 D2 9HW7 D2 9HW8 D2 9HW9 D2 9HWA C2 7H00-8...
Page 122 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: PNX85xx: Power 2HH6 B4 IHY8 D8 PNX 85xx: POWER 2HH7 C4 IHY9 E1 B04P B04P 2HH8 C5 IHYA B13 2HH9 B5 2HK0 C2 2HK1 C3 2HK2 E4 2HK3 E3 2HK4 E3 7H00-11 2HK5 E3 PNX85xx 2HK6 E3...
Page 123 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: PNX85xx: Flash 2HA0 B7 2HA1 B7 PNX 85xx: FLASH B04Q B04Q 3HA0 B2 3HA2 C9 3HA3 B8 3HA4 B4 3HA5 B4 3HA6 B4 3HA7 B4 3HA8 B4 3HA9 B4 3HAA C4 3HAB C4 5HA0 IHSR 3HAC D4...
Page 124 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: PNX5050: Control 1C05 D2 2C00 D2 PNX5050: CONTROL 2C01 D2 B05A B05A 2C02 B4 2C03 C2 3C00 D13 3C01 D13 3C02 D13 3C03 D14 3C04 E13 3C05 E14 3C06 D13 3C07 G1 +3V3-D +3V3-D 3C08 G1...
Page 125 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: PNX5050: SDRAM 2CA0 B2 2CA1 G3 PNX5050: SDRAM 2CA2 G4 B05B B05B 2CA3 G4 2CA4 H1 2CA5 H2 2CA6 H2 2CA7 H3 2CA8 H4 2CA9 H4 2CAA H4 2CAB H4 2CAC H4 2CAD H5 7C00-3 2CAE H5...
Page 126 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: PNX5050: Video 2C50 A8 2C51 A8 PNX5050: VIDEO 3C48 D3 B05C B05C 3C49 D5 3C50 E8 3C51 E8 3C53 D5 3C54 E5 3C55 E5 3C56 E5 2C50 2C51 7C00-5 3C57 E5 PNX505x(PNX1702) 3C58 E5 Φ...
Page 127 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: PNX5050: Supply 2CD0 C7 2CD1 C8 PNX5050: SUPPLY B05D B05D 2CD2 C8 7C00-2 PNX505x(PNX1702) 2CD3 C8 2CD4 C8 2CD5 C8 2CD6 C9 2CD7 C9 2CD8 C9 2CD9 C9 AB17 2CDA C10 AB12 2CDB C10 AB11 2CDC C10...
Page 128 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: Pacific 3: LVDS 1G50 A13 2G00 B9 PACIFIC 3: LVDS B06A B06A 2G01 B9 2G02 C9 2G03 C9 2G04 C9 2G05 C9 2G06 D9 2G07 D9 1G50 2G08 D9 FG00 2G09 D9 Single / Dual LVDS input only 2G10 E9 2G11 E9...
Page 129 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: Pacific 3: Display & Interfacing 1D42 B7 7G51 D10 2G50 H4 7G52 B2 PACIFIC 3: DISPLAY-INTERFACING 2G51 H3 7G53 E11 B06B B06B 2G61 2G54 B4 7G54 B3 RESERVED IG55 +3V3-STANDBY +5V-STANDBY 2G55 E10 7G55 C4 470p 2G57 C2...
Page 130 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: Pacific 3 1GE0 F10 5GE5 D4 1GE1 B11 5GE6 D4 PACIFIC 3 B06C B06C 2GE0 A2 6GE0 G8 2GE1 A3 6GE1 H9 2GE2 A3 6GE2 H8 2GE3 A3 6GE3 I8 +2V5-PF +2V5-P3 +2V5-PF +2V5-PLL 5GE0...
Page 131 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: UART 1J11 A3 1M15 B4 2J12 B3 3J12 B3 6J11-2 B2 9J09 B1 FJ12 A3 IJ01 A2 Personal Notes: 1J12 B3 2J11 A3 3J11 A3 6J11-1 A2 9J08 B1 FJ11 B3 FJ13 A4 IJ02 B2 UART B08A...
Page 132 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: SPDIF 1X02 E1 2J31 B2 2J33 B2 2J35 C3 3J31 B3 3J33 B4 3J35 C6 7J30-1 B3 7J30-3 D3 7J30-5 C3 9J01 E4 9J03 E4 9J05 E4 IJ30 B3 IJ32 C5 IJ34 B2 2J30 B2 2J32 B2 2J34 C5...
Page 133 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: Externals A 1C00 D2 FJ53 A1 1C01 B6 FJEA F13 1C02 D6 FJEB G13 EXTERNALS B08C B08C 1C03 A2 FJEC E11 1HE1 F14 FJED F13 1HE2 F14 FJEE F13 5J40 IJ40 1J15 B7 FJEF I13 1J16 C7 FJEG I13...
Page 134 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: HDMI 1B01 A1 FJB0 A4 1B02 A8 FJB1 B4 HDMI 1B03 F1 FJB3 B9 B08D B08D 1J40 G3 FJB4 B9 1J41 G3 FJB5 C9 1J42 G4 FJB6 C9 1J43 I5 FJB7 C12 1JB0 B3 FJB8 C9 1JB1 B3...
Page 135 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: Debug 1J03-A C5 DEBUG 1J03-B C6 B08E B08E 1J03-C C7 1J03-D C9 PCI-CLK-DEBUG PCI-CBE3 1J03-A 1J03-B 1J03-C 1J03-D PCI-AD0 PCI-AD1 PCI-AD2 PCI-AD3 PCI-AD4 PCI-AD5 PCI-CBE0 PCI-AD6 PCI-AD7 PCI-AD13 PCI-AD8 PCI-CBE1 PCI-AD14 PCI-AD9 PCI-PAR PCI-AD15 PCI-AD10...
Page 136 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: HDMI Switch 2JA8 C6 2JA9 C7 HDMI SWITCH B08F B08F 2JB0 C7 2JB1 D6 2JB2 D7 2JB3 D7 2JB4 D7 2JB5 D7 2JB6 D7 2JB7 D8 2JB8 D8 2JB9 D8 2JC0 D7 7J27 2JC1 D7 AD8191ASTZ...
Page 137 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: Analogue Externals 1006-1 F5 9E22 D3 1006-2 H5 9E23 D3 1006-3 I5 9E70 B7 1007 G5 9E72 C7 ANALOQUE EXTERNALS B09A B09A 1008-1 D5 9E73 E7 1008-2 C5 9E74 C2 1008-3 B5 FE00 B8 EXTERNAL I/O 3 1009-1 C9...
Page 138 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: Analogue Externals Personal Notes: 1M36 B2 ANALOQUE EXTERNALS 2E90 A1 B09B B09B 2E91 A2 2E92 B2 2E93 B2 2E94 C2 IE90 9E90 2E95 D2 FRONT_C 3E92 A2 9E91 IE91 FRONT_Y-CVBS 3E93 A2 5E01 C2 3E92 IE92...
Page 139 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: USB 2.0 1N01 D5 2N05 C8 2N07 A6 2N09 C5 2N11 C6 2N13 D9 2N15 B6 2N17 B6 2N19 C9 2N21 D9 2N23 D5 3N01 E2 3N04 B2 3N10 E5 3N14 F2 3N16 G2 3N18 E2 3N20 G2...
Page 140 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: USB 2.0 1H01 C8 1H03 C8 2N30 A3 2N31 A4 2N32 B7 5N30 B6 7N30 B3 9N05 B4 9N30 A3 FN30 C8 FN31 C7 FN32 C8 FN33 B2 FN34 B2 FN35 B2 FN36 B2 FN37 C7 IN30 A3...
Page 141 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: LED Panel Connector 1M01 C5 2N51 A4 2N53 B4 2N55 C4 3N51 B4 3N53 B4 3N56 C4 9N50 B4 FN54 C5 FN56 B4 FN58 C5 IN50 B3 IN52 B3 IN54 C4 1M20 B5 2N52 B4 2N54 C4 2N56 C4...
Page 142 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: Audio Left / Right 1735 F11 1D55 F12 2D06 F13 2D13 D3 2D20 C13 2D27 F10 2D34 D10 2D57 G3 3D03-4 D5 3D10 B10 3D14-2 H11 3D19 C11 3D27 D3 3D36 G12 3D55-3 H6 5D01 A6 5D10 B6...
Page 143 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: Audio Protection/Mute Control 2D72 B3 2D73 A5 AUDIO: PROTECTION/MUTE CONTROL B11C B11C 2D74 F9 3D62 B3 +3V3-STANDBY +3V3-STANDBY 3D63 B2 2D73 3D64 A6 3D71 C3 3D73 E5 3D74 D4 3D75 D5 3D76-1 D6 FD65 AUDIO-PROT 3D76-2 E6...
Page 144 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: SRP List Explanation Example 1.1. Introduction Net Name Diagram +12-15V AP1 (4x) +12-15V AP4 (4x) SRP (Service Reference Protocol) is a software tool that creates a list with all references to signal lines. The list contains +12-15V AP5 (12x) references to the signals within all schematics of a PWB.
Page 145 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: SRP List Part 1 Netname Schematic +5VS B08D AV1_Y B09A (1x) CRX1+ B08D (1x) DDR2-DQS3_N B04G (3x) EJTAG-DETECT B04B (1x) MM_A6 B05B (3x) +5VS B09A AV1_Y-CVBS B04K (1x) CRX1+ B08F (1x) DDR2-DQS3_P B04G (2x) EJTAG-TCK B03B (1x)
Page 146 Circuit Diagrams and PWB Layouts Q528.1A LA SSB: SRP List Part 2 Netname Schematic PCI-AD19 B04F (1x) PCI-CLK-OUT B04E (3x) RX0+ B04H (1x) RxP3R4 B06C (1x) Tx8535oE+ B04O (2x) Y-CVBS-MON-OUT B08C (1x) PCI-AD19 B05A (1x) PCI-CLK-PNX5050_CLK-MOP B04E (2x) RX0+ B08F (1x) RxP3R5 B05C (1x) B04C (1x)
Page 147 Circuit Diagrams and PWB Layouts Q528.1A LA Layout Small Signal (Overview Top Side) 1006 G3 2D30 B5 2HMG E3 2T12 G1 3B74 C5 3E75 F3 3HR1 E3 3U27 E4 6D63 B5 7U24 E4 1007 E3 2D31 C5 2HMH E3 2T13 G1 3B75 E5 3E92 G5 3HR2 E3...
Page 148 Circuit Diagrams and PWB Layouts Q528.1A LA Layout Small Signal (Part 1 Top Side) Part 1...
Page 149 Circuit Diagrams and PWB Layouts Q528.1A LA Layout Small Signal (Part 2 Top Side) Part 2 H_16790_047...
Page 150 Circuit Diagrams and PWB Layouts Q528.1A LA Layout Small Signal (Overview Bottom Side) 1B33 2G06 A1 2HMZ D3 2JB9 2U6I 3H02 E3 3HFP C3 3HP8 D4 3T22 3U7B C2 7G57 A1 9HWD D3 1B50 2G07 A1 2HP1 E3 2JC0 2U6M D2 3H03 E3 3HFR C3 3HP9 D3...
Page 151 Circuit Diagrams and PWB Layouts Q528.1A LA Layout Small Signal (Part 1 Bottom Side) Part 1 H_1679...
Page 152 Circuit Diagrams and PWB Layouts Q528.1A LA Layout Small Signal (Part 2 Bottom Side) Part 2 H_16790_048b.eps 200807...
Page 153 Circuit Diagrams and PWB Layouts Q528.1A LA Side I/O Panel 1301 A 1302-1 SIDE FACING SIDE AV 1302-2 1302-3 1303 E 1304 B 1308 D 1309 D 1301 1310 D YKF51-5564 2301 A SVHS 2302 A Y_CVBS 2303 A 2304 B I303 3303 3304...
Page 154 Circuit Diagrams and PWB Layouts Q528.1A LA Layout Side I/O Panel (Top Side) Personal Notes: 1301 1302 1303 1304 1308 1309 1310 G_16850_026.eps 3139 123 6229.1 120107 Layout Side I/O Panel (Bottom Side) 2301 A4 2307 A2 2313 A3 3305 A3 3311 A3 4302 A3 4309 A2...
Page 155 Circuit Diagrams and PWB Layouts Q528.1A LA Keyboard Control Panel Personal Notes: 1001 C1 1002 C1 KEYBOARD CONTROL 1003 C1 1004 C2 1005 C2 1011 C1 1012 C1 1013 C2 1014 C2 1015 C2 1016 C3 1M01 A4 2001 B3 3010 B1 3011 B2 3012 B2...
Page 156 Circuit Diagrams and PWB Layouts Q528.1A LA Layout Keyboard Control Panel (Top Side) 1011 A5 1012 A6 1013 A3 1014 A2 1015 A1 1016 A7 1M01 A8 G_16850_028.eps 3139 123 6219.1 120107 Layout Keyboard Control Panel (Bottom Side) 2001 A1 3011 A6 3013 A5 3015 A3...
Page 157 Circuit Diagrams and PWB Layouts Q528.1A LA Keyboard Control Panel (Aurea) Layout Keyboard Control Panel (Aurea) (Top Side) 1701 - - 1702 - - 1703 - - 1704 - - 1705 - - 1706 - - 1M01 CONTROL BOARD H_16800_089.eps 3104 313 6135.4 080507 1M01...
Page 158 Circuit Diagrams and PWB Layouts Q528.1A LA Front IR / LED Panel 1M01 I1 3010 A3 3015 E2 3020 H4 4012 F5 4017 C5 6002 B6 6014 G2 7012 D8 F012 H2 Personal Notes: 1M20 H1 3011 B3 3016 E4 3021 E5 4013 F5 4018 C7...
Page 159 Circuit Diagrams and PWB Layouts Q528.1A LA Layout Front IR / LED Panel (Top Side) Layout Front IR / LED Panel (Bottom Side) 2001 A1 1M01 A1 2002 A1 1M20 A1 3010 A1 1M21 A1 3011 A1 6001 A1 3012 A1 6002 A1 3013 A1 6010 A1...
Page 160: Led Panel
Circuit Diagrams and PWB Layouts Q528.1A LA IR & LED Panel (Aurea) Layout IR & LED Panel (Aurea) (Top Side) 1040 -- 3041 -- 3043 -- 3053 -- 3063 -- 3072 -- 3077 -- 3079 -- 6051 -- 7051 -- 7070 -- 1040 F2 3040 --...
Page 161: Alignments
Alignments Q528.1A LA EN 161 8. Alignments Index of this chapter: • Press MENU on the RC to switch back to the main menu. 8.1 General Alignment Conditions • Switch the set to stand-by mode. 8.2 Hardware Alignments 8.3 Software Alignments For the next alignments, supply the following test signals via a 8.4 Option Settings video generator to the RF input:...
Page 162: Option Settings
EN 162 Q528.1A LA Alignments Table 8-2 Tint settings which ICs to address. The presence / absence of these specific ICs (or functions) is made known by the option codes. Colour Temp. Notes: Cool • After changing the option(s), save them by pressing the OK Normal button on the RC before the cursor is moved to the left, Warm...
Page 163 Options Group 2 (code) 41609 03076 00343 13889 09079 00000 00000 00000 32PFL9432/98 42PFL9532/9x_1 41641 03590 00343 13889 09021 00000 00000 00000 42PFL9532/9x_2 41641 03590 00343 13889 09057 00000 00000 00000 42PFL9900/98_1 33497 09736 00343 13889 09057 00000 00000 00000...
Page 164: Circuit Descriptions, Abbreviation List, And Ic Data Sheets
EN 164 Q528.1A LA Circuit Descriptions, Abbreviation List, and IC Data Sheets 9. Circuit Descriptions, Abbreviation List, and IC Data Sheets Index of this chapter: 9.1 Introduction 9.3 Display Supply 9.4 On-Board Platform Supply 9.5 On-board DC/DC Converters 9.6 Front-End 9.7 PNX85xx 9.8 Back-end 9.9 Ambient Light...
Page 165 Circuit Descriptions, Abbreviation List, and IC Data Sheets Q528.1A LA EN 165 9.1.2 TV520 Architecture Overview For details about the chassis block diagrams refer to chapter “Block diagrams, Test Point Overview, and Waveforms”. An overview of the TV520 architecture can be found in next figure “Architecture of TV520 platform”.
Page 166 EN 166 Q528.1A LA Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.1.3 SSB Cell Layout AUDIO CLASS - D ON-BOARD PLATFORM SUPPLY DC - DC CONVERSION PNX5050 PNX85xx ANALOG I/O TUNER COMMON INTERFACE DIGITAL I/O HDMI SERVICE CONN. H_16790_061.eps 230707 Figure 9-2 SSB top view PACIFIC 3...
Page 167 Circuit Descriptions, Abbreviation List, and IC Data Sheets Q528.1A LA EN 167 Platform Power Management See figure “Platform Power Management” for details. STANDBY (0/4V) connector 1S01 pin 6 ON-MODE Platform POD-MODE +12VS Supply +5V5- Level shifter TUNER Power Management TV520/82 +5V- ±...
Page 168 EN 168 Q528.1A LA Circuit Descriptions, Abbreviation List, and IC Data Sheets Display Supply 9.3.1 32" Sets The 32" sets in this chassis come with a serviceable Display Supply Unit. This supply unit delivers the power for the display, AmbiLight unit and the optional panel (bold-on) for Dynamic Frame Insertion (DFI).
Page 169 Circuit Descriptions, Abbreviation List, and IC Data Sheets Q528.1A LA EN 169 9.3.2 42” Sets The 42” sets in this chassis come with a serviceable Power Supply Unit. This supply unit delivers the power for the display, AmbiLight unit and the optional panel (bold-on) for Dynamic Frame Insertion (DFI).
Page 170 EN 170 Q528.1A LA Circuit Descriptions, Abbreviation List, and IC Data Sheets • Power-Good (described above). • Light on_off: switches the LCD backlight (0 - 3.3 V). ON STATE • Boost (fixed: ór 3.3 V ór left “open” depending on commercial request or display specification).
Page 171 Circuit Descriptions, Abbreviation List, and IC Data Sheets Q528.1A LA EN 171 The supply is a Self Oscillating Power Supply (SOPS) and 9.4.6 Audio protection / DC protection working according to the Quasi Resonant Conversion (QRC) principle. Refer to diagrams B01A and B01B for details. For the When a fault occurs in the audio amplifiers (e.g.a short-circuit), on-board DC/DC converters refer to diagrams B02A, B02B and a voltage is sent via the AUDIO-PROT line which will trigger...
Page 172 EN 172 Q528.1A LA Circuit Descriptions, Abbreviation List, and IC Data Sheets (ENABLE-xVx) and +12VSW is present, therefore it is voltage, resulting into the boost voltage. The resistor 3U62/ ignored during start-up! 3UA1 limits the peak current through the rectifier diodes. •...
Page 173 Circuit Descriptions, Abbreviation List, and IC Data Sheets Q528.1A LA EN 173 9.6.1 Device specifications Tuner (TD1716) The tuner has the following specifications: • Hybrid tuner with symmetrical IF output. • Down conversion from RF to IF frequency (picture carrier 39.875 MHz at analogue reception, centre frequency 36.166 MHz at digital reception).
Page 174 EN 174 Q528.1A LA Circuit Descriptions, Abbreviation List, and IC Data Sheets Figure 9-12 PAL/SECAM video broadcast reception block diagram...
Page 175 Circuit Descriptions, Abbreviation List, and IC Data Sheets Q528.1A LA EN 175 Figure 9-13 PAL/SECAM audio broadcast reception block diagram...
Page 176 EN 176 Q528.1A LA Circuit Descriptions, Abbreviation List, and IC Data Sheets PNX85xx 9.7.1 Video Subsystem Refer to figure “Video flow diagram” for a clarification of the In this chassis, the PNX85xx is responsible for the audio/video blocks that are used in this device. source decode functions and video improvement processing on both digital and analogue sources.
Page 177 Baseband Audio Inputs. compressed streams such as MPEG and AC-3. This runs as SW Codecs on the AV-DSP. The Sony/Philips Digital Interface (SPDIF) input is used to get compressed data into the system memory. The multiplexer in 9.7.3 Audio-Video Codec Subsystem front of the block allows two possible sources of SPDIF signals.
Page 178 EN 178 Q528.1A LA Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.7.4 Control and Compute Subsystem Refer to figure “Control and compute subsystem” for a clarification of the blocks that are used in this device. DDR2-SDRAM PNX85xx I2C-3 I2C-DMA3 MIPS MTI-4KeC I2C-2...
Page 179 Circuit Descriptions, Abbreviation List, and IC Data Sheets Q528.1A LA EN 179 9.8.1 HD sets @ 50 / 100 Hz width modulated signal. An additional signal, coming from the PNX85xx, makes the selection between analogue and pulse- width modulation, depending on which display is used. In HD sets (50 / 100 Hz), the output signal coming from the Scanning Backlight displays require an analogue signal, and all PNX85xx is fed to the PNX5050 and then to the PACIFIC 3;...
Page 180 EN 180 Q528.1A LA Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.8.3 Full-HD sets @ 100 Hz - Dynamic Frame Insertion Full-HD sets 100 Hz with DFI panel” and diagram AB for details. All full-HD sets with a refresh rate of 100 Hz have an additional panel for upscaling the outcoming signal from the Pacific 3 to 100 Hz @ 1080p.
Page 181 Circuit Descriptions, Abbreviation List, and IC Data Sheets Q528.1A LA EN 181 7H00-8 PNX85xx H_16770_132.eps 240707 Figure 9-21 PNX85xx CMOS interface to PNX5050 or CYCLONE II (diagram B04O) 9.8.5 PNX5050 • Video input (CMOS). • Graphics input (PCI). • Video & Graphics (CMOS). The PNX5050 performs the following tasks: •...
Page 182 EN 182 Q528.1A LA Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.8.6 PACIFIC 3 (T6TF4HFG) The PACIFIC 3 interfaces: • Video input: – EU sets: CMOS from PNX5050 The PACIFIC 3 performs the following tasks: • Video output: LVDS (single or dual) to display or DFI panel. •...
Page 183: Ambient Light
Circuit Descriptions, Abbreviation List, and IC Data Sheets Q528.1A LA EN 183 9.8.7 Dynamic Frame Insertion (DFI) Panel To address a specific unit, the selection line has to be “low”. Refer to diagram AB for details. In case of 2-sided AmbiLight, 6 data bytes are used to address the units, 3 bytes for each lamp unit.
Page 184 EN 184 Q528.1A LA Circuit Descriptions, Abbreviation List, and IC Data Sheets Table 9-2 Two sided AmbiLight Byte selection C Selection1 C Selection2 Used bytes B1-B3 B4-B6 B4-B6 All LEDs on (preheating) 9.9.2 Three sided AmbiLight Addressing In case of three sided AmbiLight, 9 data bytes are used to address the units, 3 bytes for each lamp unit.
Page 185: Abbreviation List
Circuit Descriptions, Abbreviation List, and IC Data Sheets Q528.1A LA EN 185 9.10 Abbreviation List Dynamic Frame Insertion Directions For Use: owner's manual Digital Media Reader: card reader 0/6/12 SCART switch control signal on A/V Digital Natural Motion board. 0 = loop through (AUX to TV), 6 Digital Noise Reduction: noise = play 16:9 format, 12 = play 4:3 reduction feature of the set...
Page 186 Sync On Green non-linear resistor SOPS Self Oscillating Power Supply NTSC National Television Standard S/PDIF Sony Philips Digital InterFace Committee. Colour system mainly SRAM Static RAM used in North America and Japan. Small Signal Board Colour carrier NTSC M/N= 3.579545...
Page 187 Circuit Descriptions, Abbreviation List, and IC Data Sheets Q528.1A LA EN 187 640x480 (4:3) Variable Level out: processed audio output toward external amplifier Vestigial Side Band; modulation method WYSIWYR What You See Is What You Record: record selection that follows main picture and sound WXGA 1280x768 (15:9)
Page 188: Ic Data Sheets
EN 188 Q528.1A LA Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.11 IC Data Sheets This section shows the internal block diagrams and pin configurations of ICs that are drawn as "black boxes" in the electrical diagrams (with the exception of "memory" and "logic" ICs).
Page 189 Circuit Descriptions, Abbreviation List, and IC Data Sheets Q528.1A LA EN 189 9.11.3 Diagram B02A, NCP5422AD (IC 7U00) Block Diagram BIAS CURRENT SOURCE RAMP2 RAMP1 8.6 V − 7.8 V IS+1 CLK1 GATE(H)1 IS−1 CLK2 − − non−overlap Reset 70 mV IS+2 Dominant FAULT...
Page 190 EN 190 Q528.1A LA Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.11.4 Diagram B03A, TDA10048HN (IC7T17-1) Block Diagram AGC_TUN AGC_IF ANALOG ΣΛ STEP INTERFACE DIGITAL FRONT-END DUAL CHANNEL ESTIMATION AND OFDM AND CORRECTION DEMODULATION ΣΛ STEP INTERFACE DIGITAL DYNAMIC 2K / 4K / 8K TIMESHIFT CANCELLER...
Page 191 Circuit Descriptions, Abbreviation List, and IC Data Sheets Q528.1A LA EN 191 9.11.5 Diagram B03B, TDA9898HL (IC 7T57) Block Diagram 4 MHz reference input EXTERNAL SOUND BAND-PASS FILTER i.c. ADRSEL GNDD LFSYN2 GNDA EXTFILO EXTFILI FREF OPTXTAL 43, 44 40, 41 SYNTHESIZER 4 MHz FREQUENCY C-BUS...
Page 192 EN 192 Q528.1A LA Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.11.6 Diagram B04, PNX85xx (IC 7H00) Block Diagram DDR-II DDR-II 32 MB 32 MB PNX85xx Matrix Display 1368 × 768 A/V INPUTS MIPS32@240MHz TV control, Pixel OSD Source select 3D-Comb Digital color decoder Audio decoding...
Page 193 Circuit Descriptions, Abbreviation List, and IC Data Sheets Q528.1A LA EN 193 9.11.7 Diagram B05, PNX5050 (IC 7C00) Block Diagram DDR SDRAM PNX5050 MAIN MEMORY INTERFACE SD video ITU-R BT.656 PICTURE 4 : 2 : 2 VIDEO IN IMPROVEMENT 24-bit RGB/ HD video YUV ROUTER OUTPUT...
Page 194 EN 194 Q528.1A LA Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.11.8 Diagram B06C, T6TF4HFG (IC 7GE2) Block Diagram Contrast Reserve Input Proc Contr, Brightness & & Clip Measure MVL manager White-point corr Color LUT Color gamut & Dithering Sharpness mapping Contr.
Page 195 Circuit Descriptions, Abbreviation List, and IC Data Sheets Q528.1A LA EN 195 9.11.9 Diagram B08E, AD8191ASTZ (IC 7J27) Block Diagram Pin Configuration G_16840_098.eps 090207 Figure 9-37 Internal block diagram and pin configuration...
Page 196 EN 196 Q528.1A LA Circuit Descriptions, Abbreviation List, and IC Data Sheets 9.11.10 Diagram B10A, ISP1562BE (IC 7N00) Block Diagram PME# 77, 98, 100 CC(I/O)_AUX PCICLK GLOBAL CONTROL 10, 12 to 15, 20 to 22, AD[31:0] 26 to 31, 33, 34, 50 to 54, 56, 57, PCI CORE VOLTAGE...
Page 197: Spare Parts And Diversity List
8252 3104 311 14461 Cable 51p/350/51p 8316 3104 311 12981 Cable 12p/900/12pWh 8319 3104 311 10011 Cable 14p/480/14pWh 32PFL9432/98 (8670 000 25086) (ME7) 8402 3104 311 02151 Cable 2p3/1000/2p3 Bk 5213 3139 128 78511 Loudsp. 8Ω 20W L 8408 3104 311 08071 Cable 2P3/140 5214 3139 128 78251 Loudsp.
Page 198 EN 198 Q528.1A LA Spare Parts and Diversity List 2032 3198 017 32230 22nF 20% 25V 0603 3078 3198 021 32220 2.2kΩ 5% 0603 6003 3198 010 10630 BAS316 2034 2238 867 18101 100pF 1% 50V 0603 3080 2322 193 14122 1.2kΩ 5% 6004 3198 010 10660 BAT54 2035...
Page 199 Spare Parts and Diversity List Q528.1A LA EN 199 2023 2020 552 96205 470nF 10% 16V 0805 3028 3198 021 31020 1kΩ 5% 0.062W 0603 9028 3198 021 90030 Jumper 0603 2024 3198 017 31040 100nF 20% 50V 0603 3029 3198 021 33320 3.3kΩ...
Page 200 EN 200 Q528.1A LA Spare Parts and Diversity List 1F51 2422 025 20117 Conn. 51p f 0.5 smd 2F67 3198 035 21030 10nF 16V 0402 1F52 2422 025 18973 Conn. 41p f 0.5 smd 2F69 3198 035 21030 10nF 16V 0402 1M09 2422 025 18779 Connector 4p m 2F6A...
Page 201 Spare Parts and Diversity List Q528.1A LA EN 201 2FLP 3198 035 21030 10nF 16V 0402 3CC5 3198 031 02290 22Ω 5% 0.1W 0402 3F5F 3198 031 02290 22Ω 5% 0.1W 0402 2FLR 3198 035 21030 10nF 16V 0402 3CC6 3198 031 02290 22Ω...
Page 202 EN 202 Q528.1A LA Spare Parts and Diversity List 3F91 3198 031 01010 1Ω 5% 0402 3U48 3198 031 06890 68Ω 5% 0402 5U02 2422 536 00671 10μH 20% 3F92 3198 031 01810 180Ω 5% 0402 3U50 3198 031 01020 1kΩ 5% 0402 5U04 2422 549 44197 Bead 220Ω...
Page 203 Spare Parts and Diversity List Q528.1A LA EN 203 2035 3198 035 21040 100nF 16V 0402 3110 3198 031 06810 680Ω 5% 0.01W 0402 2036 3198 017 31040 100nF 20% 50V 0603 3111 3198 031 01030 10kΩ 5% 0402 2037 3198 017 31040 100nF 20% 50V 0603 3112 3198 031 08220 8.2kΩ...
Page 204 EN 204 Q528.1A LA Spare Parts and Diversity List 3085 2322 706 71003 10kΩ 5% 0402 7065 9336 787 70115 BC868 2D62 3198 017 31040 100nF 20% 50V 0603 3086 2322 706 74703 47kΩ 1% 0402 7066 9336 787 70115 BC868 2D63 3198 017 31030 10nF 20% 50V 0603 3088...
Page 205 Spare Parts and Diversity List Q528.1A LA EN 205 3D20 3198 021 31530 15kΩ 5% 0603 3DN5 3198 021 31040 100kΩ 5% 0.062W 0603 5P18 3198 018 73390 33μH 10% 3D23 3198 021 31530 15kΩ 5% 0603 3DN6 3198 021 31030 10kΩ 5% 0.062W 0603 5P19 3198 018 73390 33μH 10% 3D24...
Page 206 EN 206 Q528.1A LA Spare Parts and Diversity List 2B62 2222 780 15663 1μF 10% 0805 2CEK 3198 035 21030 10nF 16V 0402 Small Signal Board [B] 2B63 3198 017 31040 100nF 20% 50V 0603 2CEM 3198 035 21030 10nF 16V 0402 2C00 3198 034 02790 47pF 1% 50V 0402 2CF0...
Page 207 Spare Parts and Diversity List Q528.1A LA EN 207 2G09 3198 034 04780 4.7pF 50V NP0 0402 2HF1 3198 034 02790 47pF 1% 50V 0402 2HR9 2222 780 15663 1μF 10% 0805 2G10 3198 034 04780 4.7pF 50V NP0 0402 2HF2 3198 017 31040 100nF 20% 50V 0603 2HRB...
Page 208 EN 208 Q528.1A LA Spare Parts and Diversity List 2HVC 3198 017 31040 100nF 20% 50V 0603 2J34 3198 017 31040 100nF 20% 50V 0603 2T77 3198 034 02290 22pF 50V 0402 2HVD 2020 552 96448 1μF 10% 16V 0805 2J49 3198 034 02290 22pF 50V 0402 2T78...
Page 209 Spare Parts and Diversity List Q528.1A LA EN 209 2U94 2020 552 00158 47uF 20% 6.3V 1210 3C74 3198 031 03390 33Ω 1% 0402 3D27 3198 031 03920 3.9kΩ 5% 0402 3C75 3198 031 03390 33Ω 1% 0402 3D28 3198 031 01040 100kΩ 5% 0402 3C76 3198 031 03390 33Ω...
Page 210 EN 210 Q528.1A LA Spare Parts and Diversity List 3GG3 3198 031 01010 1Ω 5% 0402 3HA9 3198 031 01010 1Ω 5% 0402 3HHG 3198 031 03390 33Ω 1% 0402 3GH3 3198 031 01020 1kΩ 5% 0402 3HAA 3198 031 01010 1Ω 5% 0402 3HHH 3198 031 03390 33Ω...
Page 211 Spare Parts and Diversity List Q528.1A LA EN 211 3HRF 3198 031 01230 12kΩ 5% 0402 3J21 3198 031 01040 100kΩ 5% 0402 3T71 3198 031 06890 68Ω 5% 0402 3HRG 3198 031 02230 22kΩ 5% 0402 3J22 3198 031 01030 10kΩ 5% 0402 3T74 3198 031 04710 470Ω...
Page 212 EN 212 Q528.1A LA Spare Parts and Diversity List 3U7L 2322 706 71001 100Ω 1% 0402 9HG1 3198 031 90010 Jumper 0402 5B11 3198 018 90030 120Ω 100MHz 0603 3U7N 3198 031 01030 10kΩ 5% 0402 9HM1 3198 031 90010 Jumper 0402 5B12 3198 018 90030 120Ω...
Page 213 Spare Parts and Diversity List Q528.1A LA EN 213 5JA4 2422 549 44197 Bead 220Ω at 100MHz 6J47 9340 548 55115 PDZ6.8B 7HV0 9322 243 46668 TPA4411RTJ 5JA5 2422 549 44197 Bead 220Ω at 100MHz 6JA1 3198 010 10630 BAS316 7HV1 3198 010 42310 BC847BW 5N00...
Page 214 EN 214 Q528.1A LA Spare Parts and Diversity List 3009 3198 021 90030 Jumper 0603 3301 3198 021 37590 75Ω 5% 0603 3302 3198 021 37590 75Ω 5% 0603 3303 3198 021 31090 10Ω 5% 0.062W 0603 2001 3198 027 02290 Jumper 0603 3304 3198 021 31010 100Ω...
Page 215: Revision List
Revision List Q528.1A LA EN 215 11. Revision List Manual xxxx xxx xxxx.0 • First release. Manual xxxx xxx xxxx.1 • All Chapters: introduction of Aurea concept. • All Chapters: Added set: 42PFL9900/98. • Chapter 5: Section 5.2.3 (Customer Service Mode): changed descriptive text.

This manual is also suitable for:

42pfl9532/9x_1 47pfl9532/9x_1 47pfl9532/9x_2 42pfl9532/9x_2 42pfl9900/98_1 42pfl9900/98_2

Philips 32PFL9432/98 Service Manual

1 Technical Specifications, Connections, and Chassis Overview

2 Safety Instructions, Warnings, and Notes

3 Directions for Use

4 Mechanical Instructions

5 Service Modes, Error Codes, and Fault Finding

6 Block Diagrams, Test Point Overview, and Waveforms

7 Circuit Diagrams and PWB Layouts

8 Alignments

9 Circuit Descriptions, Abbreviation List, and IC Data Sheets

10 Spare Parts and Diversity List

11 Revision List

Quick Links

Colour Television

Related Manuals for Philips 32PFL9432/98

Summary of Contents for Philips 32PFL9432/98

This manual is also suitable for:

Table of Contents