Adjusting The Throttle Cable Free Play; Lubricating The Rear Suspension; Replacing The Headlight Bulbs; Checking And Charging The Battery - Yamaha 2009 YZF-R1 (Y) Service Manual

Replace damaged outer cable and inner
cables as soon as possible.
1. Check:
• Outer cable
Damage → Replace.
2. Check:
• Cable operation
Rough movement → Lubricate.
Recommended lubricant
Engine oil or a suitable cable
lubricant
TIP
Hold the cable end upright and pour a few
drops of lubricant into the cable sheath or use
a suitable lubricating device.
EAS20630
ADJUSTING THE THROTTLE CABLE FREE
PLAY
TIP
Prior to adjusting the throttle cable free play,
the engine idling speed and carburetor syn-
chronization should be adjusted properly.
1. Check:
• Throttle cable free play "a"
Out of specification → Adjust.
Throttle cable free play
3.0–5.0 mm (0.12–0.20 in)
2. Adjust:
• Throttle cable free play
▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼
a. Loosen the locknut "1".
b. Turn the adjusting nut "2" in direction "a" or
"b" until the specified throttle cable free
play is obtained.
PERIODIC MAINTENANCE
Direction "a"
Throttle cable free play is increased.
Direction "b"
Throttle cable free play is decreased.
c. Tighten the locknut "1".
EWA14B1016
WARNING
After adjusting the throttle cable free play,
start the engine and turn the handlebars to
the right and to the left to ensure that this
does not cause the engine idling speed to
change.
▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲
EAS21740

LUBRICATING THE REAR SUSPENSION

Lubricate the pivoting point and metal-to-metal
moving parts of the rear suspension.
Recommended lubricant
Lithium-soap-based grease
EAS21760

CHECKING AND CHARGING THE BATTERY

Refer to "ELECTRICAL COMPONENTS" on
page 8-117.
EAS21770

CHECKING THE FUSES

Refer to "ELECTRICAL COMPONENTS" on
page 8-117.
EAS21790

REPLACING THE HEADLIGHT BULBS

The following procedure applies to both of the
headlight bulbs.
1. Remove:
• Headlight bulb cover "1"
3-34