Table of Contents
Advertisement
INSTALLER: LEAVE THIS MANUAL WITH THE APPLIANCE.
CONSUMER: RETAIN THIS MANUAL FOR FUTURE REFERENCE.
NEVER LEAVE CHILDREN OR OTHER AT RISK INDIVIDUALS ALONE WITH THE APPLIANCE.
CERTIFIED UNDER CANADIAN AND AMERICAN NATIONAL STANDARDS: CSA 2.22, ANSI Z21.50 FOR VENTED GAS FIREPLACES.
CERTIFIED FOR CANADA AND UNITED STATES USING ANSI/CSA METHODS.
SAFETY INFORMATION
WARNING
!
If the information in these instructions
are not followed exactly, a fi re or
explosion may result causing property
damage, personal injury or loss of life.
- Do not store or use gasoline or other fl ammable
vapors and liquids in the vicinity of this or any
other appliance.
- WHAT TO DO IF YOU SMELL GAS:
•
Do not try to light any appliance.
•
Do not touch any electrical switch; do not use
any phone in your building.
•
Immediately call your gas supplier from a
neighbour's phone. Follow the gas supplier's
instructions.
•
If you cannot reach your gas supplier, call the
fi re department.
- Installation and service must be performed by a
qualifi ed installer, service agency or the supplier.
This appliance may be installed in an aftermarket,
permanently located, manufactured home (USA
only) or mobile home, where not prohibited by
local codes.
This appliance is only for use with the type of gas
indicated on the rating plate. This appliance is
not convertible for use with other gases, unless a
certifi ed kit is used.
Decorative Product: Not for use as a heating appliance.
Phone (705)721-1212 • Fax (705)722-6031 • www.napoleonfi replaces.com • ask@napoleonproducts.com
$10.00
OPERATING INSTRUCTIONS
Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON, L4M 0G8 Canada /
103 Miller Drive, Crittenden, Kentucky, USA, 41030
INSTALLATION AND
NATURAL GAS
PROPANE
WARNING
!
IR3N-1
IR3P-1
HOT GLASS WILL CAUSE
BURNS.
DO NOT TOUCH GLASS UNTIL
COOLED.
NEVER ALLOW CHILDREN TO
TOUCH GLASS.
C E R T I F I E D
1.36C
W415-1198 / 05.24.13
EN
FR
PG
33
Advertisement
Table of Contents
Related Manuals for Napoleon IR3N-1
Summary of Contents for Napoleon IR3N-1
- Page 1 TOUCH GLASS. C E R T I F I E D Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON, L4M 0G8 Canada / 103 Miller Drive, Crittenden, Kentucky, USA, 41030 Phone (705)721-1212 • Fax (705)722-6031 • www.napoleonfi replaces.com • ask@napoleonproducts.com $10.00...
-
Page 2: Table Of Contents
TABLE OF CONTENTS INSTALLATION OVERVIEW INTRODUCTION DIMENSIONS MINIMUM CLEARANCE TO COMBUSTIBLES GENERAL INSTRUCTIONS GENERAL INFORMATION RATING PLATE INFORMATION INSTALLATION LEVELLING THE APPLIANCE CHIMNEY CONNECTION GAS INSTALLATION FINISHING MINIMUM MANTEL CLEARANCES DOOR REMOVAL AND INSTALLATION LOG PLACEMENT OPTIONAL ROCK PLACEMENT GLOWING EMBERS LOGO PLACEMENT BATTERY INSTALLATION ELECTRICAL INFORMATION... -
Page 3: Installation Overview
1.0 INSTALLATION OVERVIEW Venting, see “INSTALLATION - CHIMNEY CONNECTION” section. Rating Plate, see “RATING PLATE INFORMATION” section. Logs, see “FINISHING - LOG PLACEMENT” section. Batteries, see “BATTERY INSTALLATION” section. Receiver, see “PROGRAMMING” section. “ON/OFF” switch, see “TURNING ON THE APPLIANCE” section. W415-1198 / 05.24.13... -
Page 4: Introduction
2.0 INTRODUCTION WARNING • THIS APPLIANCE IS HOT WHEN OPERATED AND CAN CAUSE SEVERE BURNS IF CONTACTED. • ANY CHANGES OR ALTERATIONS TO THIS APPLIANCE OR ITS CONTROLS CAN BE DANGEROUS AND IS PROHIBITED. • Do not operate appliance before reading and understanding operating instructions. Failure to operate appliance according to operating instructions could cause fi... -
Page 5: Dimensions
DIMENSIONS ” (730.3mm) ” 21” (600.1mm) (533.4mm) ” ” (444.5mm) (336.6mm) ” (520.7mm) ” ” (241.3mm) (241.3mm) 12” ” (304.8mm) (752.5mm) ” (444.5mm) MINIMUM CLEARANCE TO COMBUSTIBLES This appliance must be recessed into a vented noncombustible wood-burning appliance (prefabricated or masonry) only. -
Page 6: General Information
The installation must conform with local codes or, in absence of local codes, the National Gas and Propane We suggest that our gas Installation Code CSA B149.1 in Canada, or the National hearth products be installed Fuel Gas Code, ANSI Z223.1 / NFPA 54 in the United States. -
Page 7: Rating Plate Information
L LTD. SOUFFLERIE OPTIONELLE GZ550-KT, GD65. SERIAL NUMBER/NO. DE SERIE: IR3/CIR3 24 NAPOLEON ROAD, BARRIE. ONTARIO L4M 0G8 CANADA N ROAD, BARRIE. ON ROAD, BARRIE. O W385-0660 / C INSTALLER: It is your responsibility to check off the appropriate box on the rating plate according to the model, venting and gas type of the appliance. -
Page 8: Installation
3.0 INSTALLATION WARNING RISK OF FIRE, MAINTAIN SPECIFIED AIR SPACE CLEARANCES TO VENT PIPE AND APPLIANCE. Clean out ashes from the inside of the wood-burning appliance. Make sure that the chimney and wood-burning appliance are in a clean and sound condition and constructed of non-combustible materials. If necessary have any repair work done by a qualifi... -
Page 9: Chimney Connection
CHIMNEY CONNECTION Chimney installation must conform to both national and local code requirements. The chimney must be lined with one 3" (76.2mm) diameter liner for intake and one 3" (76.2mm) diameter liner for exhaust. The minimum and maximum vent lengths are 10 ft (3.1m) and 35 ft (10.7m) respectively. Recommended kits come in 3 lengths: 2-3"... -
Page 10: Gas Installation
GAS INSTALLATION WARNING RISK OF FIRE, EXPLOSION OR ASPHYXIATION. ENSURE THERE ARE NO IGNITION SOURCES SUCH AS SPARKS OR OPEN FLAMES. SUPPORT GAS CONTROL WHEN ATTACHING GAS SUPPLY PIPE TO PREVENT DAMAGING GAS LINE. ALWAYS LIGHT THE PILOT WHETHER FOR THE FIRST TIME OR IF THE GAS SUPPLY HAS RUN OUT WITH THE GLASS DOOR OPENED OR REMOVED. -
Page 11: Minimum Mantel Clearances
MINIMUM MANTEL CLEARANCES WARNING RISK OF FIRE, MAINTAIN ALL SPECIFIED AIR SPACE CLEARANCES TO COMBUSTIBLES. FAILURE TO COMPLY WITH THESE INSTRUCTIONS MAY CAUSE A FIRE OR CAUSE THE APPLIANCE TO OVERHEAT. ENSURE ALL CLEARANCES (I.E. BACK, SIDE, TOP, VENT, MANTEL, FRONT, ETC.) ARE CLEARLY MAINTAINED. -
Page 12: Log Placement
76.1A PHAZER logs and glowing embers exclusive to Napoleon, provide a unique and realistic glowing effect that is different in every installation. Take the time to carefully position the glowing embers for a maximum glowing effect. Log colours may vary. During the initial use of the appliance, the colours will become more uniform as colour pigments burn in during the heat activated curing process. -
Page 13: Optional Rock Placement
OPTIONAL ROCK PLACEMENT WARNING REAL ROCKS MUST NOT BE USED IN THIS APPLIANCE. HEAT WILL CAUSE THEM TO EXPLODE Before beginning with the installation, remove the door and all burner media from the appliance including logs and charcoal strips. Retain the glowing embers. B. -
Page 14: Electrical Information
5.0 ELECTRICAL INFORMATION WARNING DO NOT USE THIS APPLIANCE IF ANY PART HAS BEEN UNDER WATER. CALL A QUALIFIED SERVICE TECHNICIAN IMMEDIATELY TO HAVE THE APPLIANCE INSPECTED FOR DAMAGE TO THE ELECTRICAL CIRCUIT. RISK OF ELECTRICAL SHOCK OR EXPLOSION. DO NOT WIRE 110V TO THE VALVE OR TO THE APPLIANCE WALL SWITCH. -
Page 15: Operation
6.0 OPERATION WARNING IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. ALWAYS LIGHT THE PILOT WHETHER FOR THE FIRST TIME OR IF THE GAS SUPPLY HAS RUN OUT WITH THE GLASS DOOR OPENED OR REMOVED. -
Page 16: Operation
OPERATION WARNING IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. ALWAYS LIGHT THE PILOT WHETHER FOR THE FIRST TIME OR IF THE GAS SUPPLY HAS RUN OUT WITH THE GLASS DOOR OPENED OR REMOVED. -
Page 17: Turning "On" The Appliance
6.2.3 TURNING "ON" THE APPLIANCE Place the "ON/OFF" switch in the "ON" position by the receiver, refer to "INSTALLATION OVERVIEW" for location. Using the remote transmitter simultaneously press the large fl ame button and the OFF button until you hear a short beep, this confi rms the start of the appliance, you can then release both buttons. (The ignition process has begun once continuous beeping has begun). -
Page 18: Temperature Display
6.2.6 TEMPERATURE DISPLAY NOTE: Press the "OFF" button and the small flame button simultaneously until the temperature display changes from Fahrenheit to Celsius, and vice versa. When changing from Fahrenheit to Celsius the clock will change from a 12 hour to 24 hour clock, refer to "GENERAL REMOTE TRANSMITTER LAYOUT". -
Page 19: Low Battery
6.2.10 LOW BATTERY Frequent beeping for 3 seconds when the appliance turns on indicates low battery on the remote receiver. The battery pack is located on the bottom right side of the appliance, refer to "INSTALLATION OVERVIEW" for location. Low battery indicator is in the top right corner of the remote, we also recommend replacing the batteries every two years. -
Page 20: Flame Characteristics
FLAME CHARACTERISTICS THERMOCOUPLE It’s important to periodically perform a visual check of the pilot and 3/8” - 1/2” burner fl ames. Compare them to the illustration provided. If any PILOT (9.5mm - 12.7mm) fl ames appear abnormal call a service person. BURNER ELECTRODE FLAME MUST ENVELOP... -
Page 21: Maintenance
8.0 MAINTENANCE MAINTENANCE MAINTENANCE WARNING MAINTENANCE TURN OFF THE GAS AND ELECTRICAL POWER BEFORE SERVICING THE APPLIANCE. APPLIANCE MAY BE HOT, DO NOT SERVICE UNTIL APPLIANCE HAS COOLED. DO NOT USE ABRASIVE CLEANERS. DO NOT PAINT THE PILOT ASSEMBLY. CAUTION: Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation. -
Page 22: Care Of Glass
CARE OF GLASS WARNING DO NOT CLEAN GLASS WHEN HOT! DO NOT USE ABRASIVE CLEANERS TO CLEAN GLASS. HOT GLASS WILL Buff lightly with a clean dry soft cloth. Clean both sides CAUSE BURNS. of the glass after the fi rst 10 hours of operation with a DO NOT TOUCH GLASS recommended fi... -
Page 23: Burner Removal
BURNER REMOVAL Remove the glass door, see "DOOR REMOVAL AND INSTALLATION" section. Remove the logs, see "FINISHING" section. Remove the 5 screws that secure the log support in place. Lift the support out, refer to Figure 1. Remove the 4 screws that secure the front burner support in place, refer to Figure 2. Lift the burner up and out. -
Page 24: Replacements
PROPANE GAS BURNER ORIFICE W010-3039 PROPANE GAS PILOT ASSEMBLY W010-3031 NATURAL GAS PILOT ASSEMBLY W240-0014 ELECTRODE W680-0019 THERMOCOUPLE W385-0334 NAPOLEON LOGO W562-0008 GLASS GASKET W010-2701 GLASS W/ GASKET W010-2702 DOOR, GLASS & GASKET ASSEMBLY W010-0133 BURNER ASSEMBLY W361-0016 GLOWING EMBERS... - Page 25 OFF ON MANTEMPTIMER ACCESSORIES REF NO. PART NO. DESCRIPTION GI-RB RISER BOX - PAINTED BLACK MKRY GREY RIVER ROCKS MKRM MULTI-COLOURED RIVER ROCKS I3S6 5 PC SURROUND < 25.5H X 37.5W - MATTE BLACK I3S9 5 PC SURROUND < 30H X 48W - MATTE BLACK CI3S CAST IRON SURROUND KIT <...
- Page 26 W415-1198 /05.24.13...
-
Page 27: Troubleshooting
10.0 TROUBLESHOOTING WARNING ALWAYS LIGHT THE PILOT WHETHER FOR THE FIRST TIME OR IF THE GAS SUPPLY HAS RAN OUT, WITH THE GLASS DOOR OPEN OR REMOVED. TURN OFF THE GAS AND ELECTRICAL POWER BEFORE SERVICING THE APPLIANCE. APPLIANCE MAY BE HOT, DO NOT SERVICE UNTIL APPLIANCE HAS COOLED. DO NOT USE ABRASIVE CLEANERS. - Page 28 SYMPTOM PROBLEM TEST SOLUTION Exhaust fumes Appliance is spilling. Check door seal. smelled in room, Check for exhaust damage. headaches. Check that venting is installed correctly. Room is in negative pressure; increase fresh air supply. Pilot will not light. Wiring. Verify the wire for the ignitor are correctly connected to the Makes noise with module and pilot assembly.
- Page 29 SYMPTOM PROBLEM TEST SOLUTION Pilot lights. No Valve is not functioning Valve is on pilot fl ow. Turn to to the high setting, gas fl ow. properly. doudle click the large fl ame button on the remote. Replace valve. Do not overtighen the thermocouple. Manual override knob is Turn the knob to the “ON”...
-
Page 30: Warranty
All parts replaced under the President’s Limited Lifetime Warranty Policy are subject to a single claim. During the fi rst 10 years NAPOLEON® will replace or repair the defective parts covered by the lifetime warranty at our discretion free of charge. From 10 years to life, NAPOLEON®... -
Page 31: Service History
12.0 SERVICE HISTORY 43.1 W415-1198 / 05.24.13... - Page 32 Fireplace Inserts • Charcoal Grills • Gas Fireplaces • Waterfalls • Wood Stoves Heating & Cooling • Electric Fireplaces • Outdoor Fireplaces • Gourmet Grills 24 Napoleon Road, Barrie, Ontario, Canada L4M 0G8 214 Bayview Drive, Barrie, Ontario, Canada L4N 4Y8...