INDOOR UNIT OUTDOOR UNIT ASH070VE/D AXH070VE/D ASH090VE/D AXH090VE/D ASH120VE/D AXH120VE/D ASH071VE/D AXH071VE/D ASH091VE/D AXH091VE/D ASH121VE/D AXH121VE/D ASH074VE/D AXH074VE/D ASH094VE/D AXH094VE/D ASH124VE/D AXH124VE/D ASH075VE/D AXH075VE/D ASH095VE/D AXH095VE/D ASH125VE/D AXH125VE/D Manual SERVICE AIR CONDITIONER CONTENTS 1. Pre c a u t i o n s 2.
9 . Keep children away from the unit while it is being re p a i re d . Fig. 1-3 No Kids Nearby! 1 0 . Be sure to clean the unit and its surro u n d- ing are a . Fig. 1-4 Clean the Unit Samsung Electronics...
Cooling test Condition INDOOR UNIT : DB27°C WB19°C OUTDOOR UNIT : DB35°C WB24°C Heating test Condition INDOOR UNIT : DB20°C OUTDOOR UNIT : DB7°C WB 6°C Maximum operation Condition INDOOR UNIT : DB32°C WB22.5°C OUTDOOR UNIT : DB43°C WB25.5°C Samsung Electronics...
Page 6
2-2 Dimensions 2-2-1 Indoor Unit (Front view) (Remote control) Air out Installation plate (Rear view) 2-2-1 Outdoor Unit (Rear view) (Front view) Samsung Electronics...
Page 7
A X H 0 7 4 V E / A X H 0 7 5 V E •Cooling characteristics •Heating characteristics Outdoor Inlet air D. B. temp.(°C) Outdoor Inlet air D. B. temp.(°C) Outdoor Inlet air D. B. temp.(°C) Outdoor Inlet air D. B. temp.(°C) Samsung Electronics...
Page 8
A X H 0 7 4 V D / A X H 0 7 5 V D •Cooling characteristics •Heating characteristics Outdoor Inlet air D. B. temp.(°C) Outdoor Inlet air D. B. temp.(°C) Outdoor Inlet air D. B. temp.(°C) Outdoor Inlet air D. B. temp.(°C) Samsung Electronics...
Page 9
A X H 0 9 4 V D / A X H 0 9 5 V E •Cooling characteristics •Heating characteristics Outdoor Inlet air D. B. temp.(°C) Outdoor Inlet air D. B. temp.(°C) Outdoor Inlet air D. B. temp.(°C) Outdoor Inlet air D. B. temp.(°C) Samsung Electronics...
Page 10
A X H 0 9 4 V D / A X H 0 9 5 V D •Cooling characteristics •Heating characteristics Outdoor Inlet air D. B. temp.(°C) Outdoor Inlet air D. B. temp.(°C) Outdoor Inlet air D. B. temp.(°C) Outdoor Inlet air D. B. temp.(°C) Samsung Electronics...
Page 11
A X H 1 2 4 V E / A X H 1 2 5 V E •Cooling characteristics •Heating characteristics Outdoor Inlet air D. B. temp.(°C) Outdoor Inlet air D. B. temp.(°C) Outdoor Inlet air D. B. temp.(°C) Outdoor Inlet air D. B. temp.(°C) Samsung Electronics...
Page 12
A X H 1 2 4 V D / A X H 1 2 5 V D •Cooling characteristics •Heating characteristics Outdoor Inlet air D. B. temp.(°C) Outdoor Inlet air D. B. temp.(°C) Outdoor Inlet air D. B. temp.(°C) Outdoor Inlet air D. B. temp.(°C) Samsung Electronics...
Without regard to ON/OFF condition in remote controller, use this button to set current time. TIME Adjust the current time using button. (Data can be transmitted after setting up the time) Samsung Electronics...
Page 15
De-ice end by sensing of the pro c e s s i n g 7. FAN SPEED : Manual (3 step), Auto (4 step) time by de-ice Condition. Fan speed automatically varies depending on both the diff e rence between setting and the room temperature . Samsung Electronics...
Page 16
The LCD also displays the time re m a i n i n g . select, the compulsory operation mode, buzzer is sounded "beep" 11 . 24-Hour ON/OFF Real Setting Ti m e r. : The air conditioner is turned ON at a specified time using ON TIMER Samsung Electronics...
It is harmful to the air conditioner if it is used in the following environments: greasy areas (including areas near machines), salty areas such as coast areas, areas where sulfuric gas is present such as hot spring areas. Contact your dealer for advice. Samsung Electronics...
200mm or more 250mm or more Cut the piping hole sloped slightly Remote control Remote control holder Piping (Liquid) 1/4" Clamper tube 7K/9K BTU Piping(Gas)3/8” Installation plate 12K BTU Piping(Gas)1/2” Installation tube Pipe-connection Vinyl tape Screw Putty Drain hose Samsung Electronics...
Page 19
Result : All inert gas escapes from the indoor unit. • To prevent dirt or foreign objects from getting into the pipes during installation, do NOT remove the caps completely until you are ready to connect the piping. Samsung Electronics...
Page 20
4. Pass the drain hose through the hole in the wall, making sure that it is sloping downwards, as shown in the illustrations above. The hose will be fixed permanently into position once Shield the whole installation has been tested for gas leaks; refer to page 16 for further details. Drain hose Extension drain hose Samsung Electronics...
Page 21
Cap Drain B. 3 . Insert Drain plug into Hole , and then connect drain hose to drain plug. • Inside diameter of drain hose is 18mm. Hole C Hole Hole B Drain Plug Cap-Drain A Cap-Drain B Samsung Electronics...
Page 22
Caution : Burrs not removed may result in leakage of gas. Pipe Reamer Oblique Raughness Burr 3 ) Insert a flare nut into the pipe and modifty flare . Outer diameter A(mm) ø6.35mm ø9.52mm ø12.7mm * Unproper flaring Inclined Surface Cracked Uneven damaged thickness Samsung Electronics...
Page 23
Liquid pipe side Gas pipe side 6. Open the 2-way valve and 3-way valve completely 2-way valve 3-way valve Outdoor Unit 7. Close the cap of each valve. 8. Check each valve for leakage. 3-10 Samsung Electronics...
Page 24
7. Stop operation of the air conditioner. 8. Close the 3-way valve, disconnect the pressure gauge, and open the 3-way valve again. 9. Close the cap of each valve. 3-11 Samsung Electronics...
Page 25
(R-22) for every 1m. (R-22) for every 1m. 3-2-2(j) Flare unt fixing torque Torque (kg-cm) Outter diameter Fixing Torque Final Torque ø 6.35 (9000Btu, 12000Btu) (Liquid Side) ø 9.52 (9000Btu) (Gas Side) ø 12.7 (12000Btu) (Gas Side) 3-12 Samsung Electronics...
Page 26
At this time, cover the pipe of the indoor 8. Remove the mounting plate for the indoor unit and the other pipe using a cap or vinyl unit and move it to a new location. plug to avoid foreign material entering. 3-13 Samsung Electronics...
7) Pull the upper left and right of discharge softly for the outside cover to be pulled out. 8) Pull softly the lower part of discharge and push it up. Caution; Assemble the front panel and fix the hooks of left and right. Samsung Electronics...
Page 29
4) Separate the bush body at the upper side and holder at the rearside. 5) Loosen the two fixing screws of left side. 6) Lifting the heat exchanger up a little to push the up side for separation from the indoor unit. Samsung Electronics...
Page 30
2) Loosen the fixing three screws and separate the motor holder. 3) Loosen the fixing screw of fan motor. (By use of M3 wrench) 4) Separate the fan motor from the fan. 5)Separate the fan from the left holder bearing. Samsung Electronics...
Page 31
Fan and Motor 1) Do “1”, above. 2) Loosen two fixing screw, of the front cabinet. 3) Push the brackets of the outer cover to sepa- rate the protection mesh from the rear side of front cabinet. Samsung Electronics...
Page 32
3) Disassemble the inlet and outlet pipe of com- pressor by welding. 4) Disassemble the inlet and outlet pipe of con- denser by welding 5) Loosen the three bolts of the lower part. 6) separate the compressor. Samsung Electronics...
Indoor unit Room sensor Error (open or short) 3 O P E R ATING and TIMER LED blinking (1Hz) Indoor unit heat exchanger temperature sensor Error (open or short) 4 FAN LEA blinking (1Hz) Indoor fan malfunctioning (for spead is Below 38Orpm) Samsung Electronics...
Replace Check PCB pattern . ICO2 10ms Replace main PCB. Is voltage output terminal of D101~D105(IN4007) normal? Are voltage at #30 and #31 of the micom normal? Replace resonator (X501) 100ns Replace IN4007 Is operation normal? Replace micom Samsung Electronics...
Page 35
Is the supply voltage of the fan out of order. be replaced. motor sufficient? Test rod location Normal voltage PCB CN73 Condition Fan operate AC 180V MF-C is out of order Replace MFC Fan motor Fan motor should be is out of order. replaced. Samsung Electronics...
Page 36
Tap(TB71) and RY 71 terminal No. 3 Outdoor unit is out of order. 1 NO 2 NO Is the room sensor normal register? 10°C 20°C 30°C 17.96k Ω 12.09k Ω 8.3k Ω YES 3 Samsung Electronics...
Page 37
Is the munber #15 of IC07 (KID65003) LOW? Abnormal IC07 Is the voltage between CN71 #3 and RY71 NO AC198~264? Abnormal RY73 Abnormal 4way valve of Outdoor Unit. or connecting Cable PCB should be replaced. 4 way valve should be replaced or connecting Cable Check. Samsung Electronics...
Page 38
Voltage at PIN #30 of Remocon Micom change? Voltage at collecter of Q601 or Q602 change? Q601(C4375Y) or Q602(C1623Y) is faulty. IR LED(CL-1L5EU) is faulty. Voltage at pin #26 of micom (IC04) change (INDOOR UNIT)? Receiver module is faulty. Micom (IC04) is faulty. Samsung Electronics...
The parts should be replaced in the following pro c e d u re . Check for any faulty part. Detach the faulty part. Replace it with a new part. Check the operation of the new part. The repair is completed. Samsung Electronics...
1. Indoor unit fan motor is faulty. RMC switch pushed. above 180V~ 1. [FAN] mode 2. Fan speed [Hi] 2. Indoor unit fan motor does not operate. 2. Poor connection of indoor fan motor 3. Continuously operation and connector of RPM sensing (CN43) Samsung Electronics...
Black, Red ∞, O Ω … open or short Abnormal Measure resistance between red wire and each terminal. Stepping Motor Normal Approx. 380Ω at ambient temperature (20°C ~30°C) (UP/DOWN swing motor) ∞, O Ω … open or short Abnormal Samsung Electronics...
ART 90 DB68-10790A LABEL DOOR ART 90 PH-M2 SCREW TAP PH-M2 DB67-60061A SPRING BATTERY SUS 304 DB67-60062A SPRING BATTERY SUS 304 DB67-60063A SPRING BATTERY SUS 304 90 250 PE BAG 90 250 DB93-40179C ASS’Y PCB REMOCON DB61-40243A HOLDER REMOCON Samsung Electronics...
4-WAY VALVE • 4-WAY VALVE DRIVE TEMPERATURE SELECT STEPPING MOTOR STEPPING MOTOR • DRIVE BUZZER SLEEP SELECT • BUZZER DRIVE TIME SETTING DC 5V DC 12V VOLTAGE REGULATOR AC INPUT POWER TRANSFORMER DR : 200-220V/50Hz ER : 220-240V/50HZ Samsung Electronics...
Page 53
WIRE SO COPER OP01 DE39-60001A WIRE SO COPER PI0.6 SN T 52MM OP02 DE39-60001A WIRE SO COPER PI0.6 SN T 52MM OP03 DE39-60001A WIRE SO COPER PI0.6 SN T 52MM OP04 DE39-60001A WIRE SO COPER PI0.6 SN T 52MM Samsung Electronics...
10. Schematic Diagrams 10-1 Indoor Unit 10-1 Samsung Electronics...
Page 60
10-2 Remote Control 10-2 Samsung Electronics...
Page 61
And if you need more information, please see the service bulletin Copyright Tr a d e m a r k s Samsung is a registered trademark and ®œ 1995 by Samsung Electronics Co., Ltd. SyncMaster 17GLi/CMG7387L and MacMaster All rights reserved. Cable Adapter are trademark of Samsung This manual may not, in whole or in part, be Electronics Co., Ltd.