Page 1
Assembly instructi0ns!Use and Care Manual ® Liquid Propane Gas Grill Model No. 415.t62130 ASSEMBLY This Grill is For Outdoor Use Only * Read this manua_ before cooking gril. FaiJure to foJJow alJ manufacturers' instructions could resumt in fire or expmosion...
Safety Symbols The symbols and boxes shown below explain what each heading means, Read and follow all of the messages found throughout the manual, FOR YOUR SAFETY 1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
Repair Protection Agreements Congratulations on making a sma,,tpurc,Sase,Your new WARRANTY SERVICE Kenmore®product is designed and manufactured for years of Warranty service is available by contacting Sears at dependable operation. But like all products, it may require repair 1-800-4-MY-HOME®. from time to time. That's when having a Repair Protection Agreement can save you money and aggravation.
Page 7
Leg Extenders, Axb Rods, Wheels and TankThumbscrew Turn cart upside down. insert leg extenders. Checkto make sure bg extender is all the way into the bg. f---... Qty: 1 Attach u-nut to tab. See enlargement of u-nut for correct position. Not to scale Threadtank thumbscrew into hob and u-nut Screw flanged hex nut onto end of tank thumbscrew.
Page 8
Rail Assembly Overlap rails (all identical) and hook tabs into slots. Pull rails to latch. Attach rail to legs with two screws in each corner. HINT: Qty:10 Firmly push rail down into leg notches. Attach lower screw first. Attach one screw in center of each rail. Rail 8,463353505...
Page 9
Hose Heat ShieRd Attach hose heat shield to right side of cart. Rightsideof cart Qty:2 Front Panel Placefront panel between front legs. Place tabs on front panel beside leg tabs. Securetop of panel to legs using push fasteners. Qty:2 FrontS Panel 463353505.9...
Page 10
Grill Bottom Assembly Angle grill bottom assembly around and under the rails. Makesure ribs on each side of bottom casting are nestled into notches on casting seat. Attach four screws inside grill bottom and into casting seat. Qty:4 Grill Bottom Castin'g Seat 10,4(}3353505...
Page 11
Electrode with Wing Nut or Nut inside bottom casting insert electrode and attach with wing nut or nut. Viewof electrodeattachedand aligned with a portholein the burner..WingNutor Nut Finger tighten only Front Electrode 463353505,11...
Page 12
Console Assembly Hold control panel dose to bottom casting, Feedthe vaive/hosdreguiator assembly over the front panel so that it hangs inside the cart. Attach ignitor wire to electrode. Position valves into burner tubes (see burner-valve view). Rotate control panel up and rest flange over rail. Attach control panel to legs with two screws on each side.
Top Casting, Control Knobs and Condiment Basket Attach top casting with shoulder bolts. Push control knobs onto valve stems. insert tabs on condiment basket into holes in front panel. Secure basket to front panel using one push fastener. Qty: 1 Qty.2 f.Top Casting 31..
Grill@Night Night Light HandleAssembly Note: On the underside of the lamp assemblies are "L" for left side and "R" for right side. Matchto letter on the handle. RemoveGrill@Night label if present from front of grill lid. install lamp assemblies inside grill lid. Position lamp assembly so that terminal passes through larger hole in Grill Lid.
CookingGrids SwingAway Insert pivot wire into holes in sides of grill lid. insert leg wire into holes in sides of grill bottom. Pivot Wire Leg Wire 16,463353505...
LPTank LPtank is soldseparately. Use only with an See Use and Care section to correctly Leak Test and (over-fill protection device} OPCequipped perform the Burner FRame C heck. LP tank. Fill and leak check before attaching to grill and regulator. PlaceLP tank into hole in bottom shelf.
LP Tank • The LP tank used with your grill must meet the following requirements: Use LP tanks only with these required measurements: 12" (30.5cm) (diameter) x 18" (45.7 cm) (tall) with 20 Ib. (9 kg.) capacity maximum. LP tanks must be constructed and marked in accordance with Never fill the cyJinder beyond 80% full.
Page 19
LP Tank Exchange Connecting Regulator To The LP Tank , Many retailers that sell grills offer you the option of replacing 1. LP tank must be properly secured onto grill. (Refer to your empty LP tank through an exchange service, Use only assembly section.) those reputable exchange companies that inspect, precision fill, 2.
Page 20
Leak Testing Valves, Hose and Regulator 1, Turn aHgrilJcontrol knobs to OFF. Be sure regulator is tightly connected to LP tank. Completely open LP tank valve by turning OPD hand wheel counterclockwise, if you hear a rushing sound, turn gas off immediately.
Page 21
Safety Tips ,& Before opening LP tank valve, check the coupling nut for tightness, For Safe Use Of Your Gritl And To Avoid Serious ,& When grill is not in use, turn offall control knobs and LP tank Injury: valve, •...
Match-Lighting CAUTION A Do not lean over grill while lighting. 1, Open lid. Turn on gas at LP tank. • Putting out grease fires by closing the lid is not possible. Grills are we)) ventilated for safety reasons. 2. Place lit match into match lighting hole from outside of grill bottom (as shown).
Page 23
Turning GriJl Off Repainting Your Grill . Turn al! knobs to OFF position. Turn LP tank off by turning . After extended use and exposure to weather, paint on grill may OPD hand wheel clockwise to a full stop. deteriorate or become spotted. Although this detracts from grill's appearance, it will not impair its performance.
Page 24
C_eaning The Burner Assembly Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting the grill, Turn gas off at control knobs and LP tank. Remove cooking grids and vaporizer tents, Remove two pal nuts, carry-over tube and burners, Under grill remove grease pan and tray, Clean with soap and water, Under console disengage ignitor wire, Wipe ceramic electrode with rubbing alcohol and cloth,...
Page 25
Storing Your Grill , Clean cooking grates, , Store in dry location, , When LP tank is connected to grill, store outdoors in well- ventilated space and out of reach of children, , Cover grill if stored outdoors, , Store grill indoors ONLY if LP tank is turned off and disconnected, removed from grill and stored outdoors, , When removing grill from storage follow "Cleaning Burner Assembly"...
Page 26
Cooking Table Cooking times and temperatures may vary according to specific recipes, cooking conditions or barbecue equipment used, Take these factors into consideration to insure best results, If you use the indirect cooking method (indirect cooking is lighting only one burner and placing food on opposite side of cooking grate), allow more grilling time, Temperatures: High = 650°F / Medium = 450°F / Low = 300°F.
Troubleshooting , Old hose,cut in hose. Gasleakingfrom , Turnoff gas at LP tank. If hoseis cut or cracked,replace cracked/cu_burned valve/hose/regulator. If burned,discontinueuseof productuntila gas hose. servicetechnician/plumber hasinvestigated causeand correctionis made. Gasleakingfrom LP , Mechanical f ailuredue to rustingor , Turnoff LP tankvalve. tank.
Page 28
Troubleshooting (centinued) Burner(s) w ill not light , Push-button sticksat bottom., o Replaceignitor. usingignitor, , Sparkingbetweenignitorand electrode, , Inspectwire insulationand properconnection,Replacewires if insulationis broken. Burner(s) w ill not , See "GAS iSSUES:"on previouspage, matchlight. , Impropermethodof match-lighting. , See"Match-Lighting" s ectionof Useand Care, Suddendrop in gas , Outof gas.
Troubleshooting - Electronic Ignition SECTION1 Nosparksappearat , Batterynot installed , Checkbatteryorientation, o Installbattery(makesure that"-" and "+" any electrodeswhen properly, connectors are orientedcorrectly,with "-" end up ignitionbuttonis and "+" enddown,) pushed;no noisecan be heardfrom spark o Deadbattery, , Has batterybeen used , Replacebatterywith newAAA-sizealkalinebattery, module, previously?
Page 31
Please register your grill online at: Sirvase registrar su parriJJaen Jinea, e n: (If you register online, you do not need to send in this registration card.!Si la registra en linea, no es necesario que envie esta tarjeta de registro.) PLEASE FULL OUT THiSCARD ANDRETURN IT WtTNtN 10DAYS OFPURCHASE.