Page 1
All manuals and user guides at all-guides.com RX-8012PSL SERVICE MANUAL AUDIO/VIDEO CONTROL RECEIVER RX-8012PSL Area suffix US --------- Singapore CATV/DBS VCR 1 AUDIO DVD MUILTI FM/AM TV/DBS VIDEO PHONO VCR 1 VCR 2 TAPE/MD SURROUND ANALOG/DIGITAL SLEEP ON/OFF MODE INPUT...
Page 2
All manuals and user guides at all-guides.com RX-8012PSL 1. This design of this product contains special hardware and many circuits and components specially for safety purposes. For continued protection, no changes should be made to the original design unless authorized in writing by the manufacturer.
Page 3
All manuals and user guides at all-guides.com RX-8012PSL Disassembly method Top cover Removing the top cover (See Fig.1) Remove the four screws A attaching the top cover on both sides of the body. Remove the three screws B on the back of the body.
Page 4
All manuals and user guides at all-guides.com RX-8012PSL Main Removing the DVD board (See Fig.5 and 6) CN722 (on board the center Prior to performing the following procedure, remove amp. board) the top cover and rear panel. CN721 CN723 Cut off the tie bands.
Page 5
All manuals and user guides at all-guides.com RX-8012PSL DSP board S Video board Video board CN601 Video audio board Fig.10 Fig.9 Removing the speaker board (See Fig.11) Relay board Prior to performing the following procedure, remove the top cover and rear panel.
Page 6
All manuals and user guides at all-guides.com RX-8012PSL Removing the main board (See Fig.13) CN721 CN723 Tie band Prior to performing the following procedure, remove the top cover. Remove the card wire and cut off the tie bands. Tie band...
Page 7
All manuals and user guides at all-guides.com RX-8012PSL CN811 Removing the power transformer CN55/CN56 (See Fig.17) Prior to performing the following procedures, remove Power supply board the top cover. Disconnect the harness from the connector CN55 Power /CN56 and CN811 on the power trans1 board.
Page 8
All manuals and user guides at all-guides.com RX-8012PSL <Front panel assembly> Front panel assembly Removing the system control board, Operation switch panel power switch board and switch board (See Fig.1 to 3) Prior to performing the following procedure, remove the top cover and front panel assembly.
Page 9
All manuals and user guides at all-guides.com RX-8012PSL Adjustment method Tuner section 1.Tuner range 87.5MHz~108.0MHz AM(MW) 531kHz~1710kHz Power amplifier section Adjustment of idling current Measurement location B2204-B2205(Lch) , B2213-2214(Rch) Adjustment part VR787(Lch) , VR788(Rch) Attention This adjustment does not obtain a correct adjustment value immediately after the amplifier is used (state that an internal temperature has risen).
Page 10
All manuals and user guides at all-guides.com RX-8012PSL Self-diagnose function 1. Detection of abnormal power supply and voltage When the power is turned ON, if an abnormality is detected during the signal input at the A/D port (IC901, pin 2-5, 7) for one second continuously, the status will become STANDBY mode immediately.
Page 11
All manuals and user guides at all-guides.com RX-8012PSL 4. Self-diagnose To enter the self-diagnose mode, put the power plug in the socket while pressing SETTING key and UP key together simultaneously, then turn the power ON. With the UP/DOWN key operation, DSP microcomputer, ROM No.of system microcomputer as well as working status of DSP can be displayed for five seconds.
Page 12
All manuals and user guides at all-guides.com RX-8012PSL Description of major ICs AK4112A (IC551) : 96kHz 24bit DIR 1. Pin layout 2. Block diagram AVSS AVDD MCKO1 MCKO2 DVDD CM0/CDTO Clock Clock X'tal DVSS CM1/CDTI Recovery Generator Oscillator Input TVDD...
Page 13
All manuals and user guides at all-guides.com RX-8012PSL AK4527B (IC571) : A/D, D/A converter 1.Pin layout 44 ~ 34 1 ~ 11 33 ~ 23 2.Block diagram 12 ~ 22 Audio LIN+ LIN- RIN+ RIN- LRCK LOUT1 DATT BICK DAUX...
Page 14
All manuals and user guides at all-guides.com RX-8012PSL 3. Pin function (2/2) Pin No. Symbol Function DEM0 De-emphasis Pin ORed with serial control register if P/S="L" MCKO Master clock output pin DVDD Digital power supply pin DVSS Digital ground pin Power-down &...
Page 15
All manuals and user guides at all-guides.com RX-8012PSL BA15218F (IC303, IC304, IC372, IC385, IC386, IC521, IC522, IC523, IC524, IC525, IC526, IC527, IC528, IC529) : Op amp. OUT1 -IN1 OUT2 +IN1 -IN2 +IN2 BA7625 (IC201, IC242) : Video selector 1. Block diagram 2.
Page 16
All manuals and user guides at all-guides.com RX-8012PSL BU2092 (IC402) : Port expander 1.Pin layout DATA CLOCK CONTROL CIRCUIT 2.Pin function Symbol Function Pin No. Connect to GND DATA Serial Data input CLOCK Shift Clock of Data Latch Clock of Data...
Page 17
All manuals and user guides at all-guides.com RX-8012PSL MB90088 (IC203) : Display controller 1.Pin layout AVss YOUT VOUT AVcc COUT IOUT SCLK TEST BOUT HSYNC ROUT VSYNC GOUT EXHSYN EXVSYN 2.Block diagram Serial Input Each Control, Data SCLK Control EXHSYN...
Page 18
All manuals and user guides at all-guides.com RX-8012PSL 3.Functions Symbol I/O Function Lux signal Input terminal for Superinpause indication Composite video signal input terminal for Superinpause indication Contrast signal input terminal for Superinpause indication Analog power supply terminal AVcc IOUT...
Page 19
All manuals and user guides at all-guides.com RX-8012PSL NJM4580DD (IC301) : LPF, Mic and headphone amp. 1.Pin layout A OUT A -IN B OUT A +IN B -IN B +IN (TOP VIEW) 2.Block diagram INPUT OUTPUT NJU7241F33 (IC411) : Voltage regulator PIN FUNCTION 1.
Page 20
All manuals and user guides at all-guides.com RX-8012PSL PCM2702E-X (IC410) : USB D/A converter 1.Pin layout 2. Block diagram VccP USB packet audio DGNDC data data AGNDP FIFO Low-pass WRCLK VccL VOUTL USB I/F Filter Multi-level Oversampling DGND VBUS AGNDL...
Page 21
All manuals and user guides at all-guides.com RX-8012PSL TC9162AN (IC380) : Analog switch R-S1 L-S1 R-S2 L-S2 R-COM1 L-COM1 R-S3 L-S3 R-S4 L-S4 R-COM2 L-COM2 R-S5 L-S5 R-S6 L-S6 R-COM3 L-COM3 R-S7 L-S7 R-COM4 L-COM4 DATA R-S1 L-S1 R-S2 L-S2...
Page 22
All manuals and user guides at all-guides.com RX-8012PSL TC9163AF-X (IC371) : Analog switch R-S1 L-S1 R-S2 L-S2 R-S3 L-S3 R-COM1 L-COM1 R-S4 L-S4 R-S5 L-S5 R-S6 L-S6 R-COM2 L-COM2 R-S7 L-S7 R-S8 L-S8 R-COM3 L-COM3 DATA R-S1 L-S1 R-S2 L-S2...
Page 23
All manuals and user guides at all-guides.com RX-8012PSL TC9164AF-X (IC302) : Analog switch R-S1 L-S1 R-S2 L-S2 R-S3 L-S3 R-S4 L-S4 R-COM1 L-COM1 R-S5 L-S5 R-S6 L-S6 R-COM2 L-COM2 R-S7 L-S7 R-S8 L-S8 R-COM3 L-COM3 DATA R-S1 L-S1 R-S2 L-S2...
Page 24
All manuals and user guides at all-guides.com RX-8012PSL TC9459F (IC381, IC382, IC383) : Electronic volume control 1.Pin layout 2. Block diagram L-OUT R-OUT L-OUT R-OUT L-IN 915TEP R-IN L-1N R-IN L-ch L-LD1 R-ch R-LD1 Same as L-ch L-LD2 R-LD2 L-LD1...
Page 25
All manuals and user guides at all-guides.com RX-8012PSL PQ3DZ53 (IC583) : Regulator IC DC INPUT(Vin) DC OUTPUT(Vo) CUSTOM IC ON/OFF CONTROL(Vc) TC74HC4053AF (IC388, IC389) : Multiplexe 1. Pin layout 2. Truth table CONTROL INPUTS INHIBIT Y-COM X-COM Z-COM X: Don't Care.
Page 26
All manuals and user guides at all-guides.com RX-8012PSL UPD784215AGC152 (IC581) : Unit CPU 1.Pin layout 2.Pin function Pin No. Symbol Function Non connect Power supply terminal Connecting the crystal oscillator for system main clock Connecting the crystal oscillator for system main clock...
Page 27
All manuals and user guides at all-guides.com < M E M O >...
Page 28
All manuals and user guides at all-guides.com RX-8012PSL VICTOR COMPANY OF JAPAN, LIMITED AUDIO & COMMUNICATION BUSINESS DIVISION PERSONAL & MOBILE NETWORK BUSINESS UNIT. 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan (No.21066) 200202(V)
Page 29
All manuals and user guides at all-guides.com RX-8012PSL ock diagrams gnal I/O block section Main section LVA10220-1 LVA10221-1 CN731 CN732 LVA10221-2 Q761 L ch Q763 RY831 SPK1 CN244 CN242 S Video LVA10219-5 Q762 RY832 SPK2 R ch Q764 CN200 CN204...
Page 30
All manuals and user guides at all-guides.com RX-8012PSL RX-8012PSL section Video input section LVA10219-3 LVA10219-4 DVD F DATA TV/DBS IC 203 DATA/CLK MON Y/C OUT VCR1 REC Y/C SEP SOURCE IC 202 SELECTOR IC 201 IC 371 MON Y/C IN VCR1 P.B...
Page 31
All manuals and user guides at all-guides.com RX-8012PSL Tuner section FL display & system control section LVA10009 LVA10218-1 TUNER AM/FM DET RF 101 IC102 FL DISPLAY DI400 SYSTEM CONTROLLER MW RF & OSC T111 IC121 IC 400 DATA Audio input section...
Page 41
All manuals and user guides at all-guides.com RX-8012PSL ystem control FL display section C409 C400 C410 4.7/50 4.7/50 4.7/50 DI400 QLF0084-001 Q402 Q404 CN412 D405 Q407 QGF1205F1-08 DTC114YKA DTC114TKA 1SS133 DTC114YKA Q408 Sheet 1/11 DTC114YKA CN410 IC411 M_CLK QGF1205F1-10 NJU7241F33...
Page 42
All manuals and user guides at all-guides.com RX-8012PSL RX-8012PSL ection FM/TUNER Signal Parts are safety assurance parts. When replacing those parts make AM Signal sure to use the specified one. CN101 SHEET 11/11 Sheet 3/11 2-14...
Page 43
All manuals and user guides at all-guides.com RX-8012PSL nted circuit boards ain board Relay board B521 B522 B523 CN491 B241 B524 B525 CN72 B526 B527 CN82 B528 B529 B530 B531 S831 B117 R860 ST831 ST851 C853 B118 R863 B119 C847...
Page 44
All manuals and user guides at all-guides.com RX-8012PSL RX-8012PSL Power supply board supply board / Audio board FW51 PW28 B3230 B3191 RY63 Voltage select board PW40 B3122 CN55 PW29 B3231 B3234 TH71 B3123 B3430 B3233 B3334 RY62 Power trans1 board...
Page 45
All manuals and user guides at all-guides.com RX-8012PSL ont board System control board B1115 R424 B1114 B1313 B1118 R417 R423 R472 R419 K452 C446 C441 C442 C465 S431 R495 C462 R415 R477 R418 S424 S419 S415 S417 S423 S418 S420...
Page 46
All manuals and user guides at all-guides.com RX-8012PSL RX-8012PSL oard (Forward side) S video board Audio input board Video audio board R385 R1211 C259 R1227 C257 CN416 CN244 C260 R271 C1227 C256 C258 D240 C261 D241 C1228 IC242 IC241 R1228...
Page 47
All manuals and user guides at all-guides.com RX-8012PSL put board (Reverse side) Video audio board Audio input board S video board R390 R389 R388 R385 C253 R387 R1211 R345 IC303 C259 IC393 CN416 R1243 R1227 C257 CN244 R1225 R1241 C260...
Page 48
All manuals and user guides at all-guides.com RX-8012PSL RX-8012PSL oard DSP board Rear Lch amp. board (Forward side) R2554 R2551 R2555 C2557 R2557 IC551 R2275 C2261 R2221 R2233 R2283 B2131 R2263 R2285 C2283 C2237 CN581 R2237 R1873 B2501 IC525 Front Lch amp. board...
Page 50
All manuals and user guides at all-guides.com RX-8012PSL PARTS LIST [ RX-8012PSL ] * All printed circuit boards and its assemblies are not available as service parts. Area suffix US ---------------------- Singapore - Contents - 3- 3 Exploded view of general assembly and parts list (Block No.M1) 3- 5 Electrical parts list (Block No.01~07)
Page 51
All manuals and user guides at all-guides.com RX-8012PSL < M E M O >...
Page 52
All manuals and user guides at all-guides.com RX-8012PSL Exploded view of general assembly and parts list Block No. Power trans board I/O board Vol sel Power trans board board Power/Fuse board Speaker board Relay board Power supply Main Audio board...
Page 53
All manuals and user guides at all-guides.com RX-8012PSL RX-8012PSL Parts list (General assembly) Parts list (General assembly) Block No. M1MM Block No. M1MM Item Parts number Parts name Q'ty Description Area Item Parts number Parts name Q'ty Description Area LV10469-006A...
Page 54
All manuals and user guides at all-guides.com RX-8012PSL Electrical parts list (Main board) Block No. 01 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area C 801 QFN82CK-104 M CAPACITOR .10MF 10% 160V D 825...
Page 55
All manuals and user guides at all-guides.com RX-8012PSL Electrical parts list (Main board) Block No. 01 Item Parts number Parts name Remarks Area R 864 QRE141J-472Y C RESISTOR 4.7K 5% 1/4W R 865 QRE141J-472Y C RESISTOR 4.7K 5% 1/4W R 866...
Page 56
All manuals and user guides at all-guides.com RX-8012PSL Electrical parts list (Front board) Block No. 02 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area BK400 LV42092-001A FL HOLDER(R) D 480 SLR-342VC-T (STANDBY) BK401 LV42093-001A...
Page 57
All manuals and user guides at all-guides.com RX-8012PSL Electrical parts list (Front board) Block No. 02 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area R 440 NRSA63J-222X MG RESISTOR S 418 QSW0683-001Z PUSH SWITCH...
Page 58
All manuals and user guides at all-guides.com RX-8012PSL Electrical parts list (Power board) Block No. 03 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area C 701 QTE1V06-106Z E CAPACITOR C1808 QETN1CM-107Z E CAPACITOR 100MF 20% 16V...
Page 59
All manuals and user guides at all-guides.com RX-8012PSL Electrical parts list (Power board) Block No. 03 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area Q 712 KTC3200/GL/-T TRANSISTOR R 726 QRE141J-152Y C RESISTOR 1.5K 5% 1/4W...
Page 60
All manuals and user guides at all-guides.com RX-8012PSL Electrical parts list (Power board) Block No. 03 Item Parts number Parts name Remarks Area R1793 QRE141J-183Y C RESISTOR 18K 5% 1/4W R1795 QRE141J-473Y C RESISTOR 47K 5% 1/4W R1801 QRE141J-222Y C RESISTOR 2.2K 5% 1/4W...
Page 61
All manuals and user guides at all-guides.com RX-8012PSL Electrical parts list (Input board) Block No. 04 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area C 201 QETN1HM-475Z E CAPACITOR 4.7MF 20% 50V C 308...
Page 62
All manuals and user guides at all-guides.com RX-8012PSL Electrical parts list (Input board) Block No. 04 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area CN243 QGB1214J1-10S CONNECTOR C1381 NCS31HJ-470X C CAPACITOR CN244 QGA2501F1-04 CONNECTOR...
Page 63
All manuals and user guides at all-guides.com RX-8012PSL Electrical parts list (Input board) Block No. 04 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area Q 200 KTA1267/YG/-T TRANSISTOR R 249 NRSA63J-151X MG RESISTOR Q 201...
Page 64
All manuals and user guides at all-guides.com RX-8012PSL Electrical parts list (Input board) Block No. 04 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area R 372 NRSA63J-471X MG RESISTOR R1336 NRSA63J-102X MG RESISTOR R 373...
Page 65
All manuals and user guides at all-guides.com RX-8012PSL Electrical parts list (DSP board) Block No. 05 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area C 571 NCB31HK-103X C CAPACITOR C2308 NEA71EM-475X E CAPACITOR C 573...
Page 66
All manuals and user guides at all-guides.com RX-8012PSL Electrical parts list (DSP board) Block No. 05 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area C2601 NCB31CK-104X C CAPACITOR R 575 NRSA63J-432X MG RESISTOR C2602...
Page 67
All manuals and user guides at all-guides.com RX-8012PSL Electrical parts list (DSP board) Block No. 05 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area R2507 NRSA63J-473X MG RESISTOR R2222 NRSA63J-333X MG RESISTOR R2508 NRSA63J-473X...
Page 68
All manuals and user guides at all-guides.com RX-8012PSL Electrical parts list (Micon board) Block No. 06 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area QCZ9104-472 C CAPACITOR 4700PF D 52 1SR35-400A-T5 DIODE C 51...
Page 69
All manuals and user guides at all-guides.com RX-8012PSL Electrical parts list (Micon board) Block No. 06 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area Q 53 KRC105M-T D TRANSISTOR R 961 QRK126J-120X C RESISTOR...
Page 70
All manuals and user guides at all-guides.com RX-8012PSL Electrical parts list (Tuner board) Block No. 07 Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area AT101 QNB0014-001 ANT TERMINAL R 122 NRSA02J-472X MG RESISTOR BK 1...
Page 71
All manuals and user guides at all-guides.com RX-8012PSL Packing materials and accessories parts list Block No. Block No. A2~A6 3-22...
Page 72
All manuals and user guides at all-guides.com RX-8012PSL Parts list (Packing) Block No. M3MM Item Parts number Parts name Q'ty Description Area QPA02503505P POLY BAG 1 FOR INST BOOK LV20989-016A CARTON BOX LV32034-003A SHEET LV20947-001A PACKING PAD LV20948-001A PACKING PAD...