1. Dust cap
2. Latch
3. Air-cleaner cover
6.
Squeeze the dust cap sides to open it and knock
the dust out.
7.
Clean the inside of the air-cleaner cover with
compressed air that is under 205 kPa (30 psi).
Important:
Do not use compressed air on
the air-cleaner body.
8.
Check the service indicator.
•
If the service indicator is clear, install the
air-cleaner cover with the dust cap oriented
downward and secure the latches
32).
•
If the service indicator is red, replace the
air filter as described in
(page
27).
Replacing the Filter
Important:
To prevent engine damage, always
operate the engine with the air filter and cover
installed.
1.
Gently slide the filter out of the air-cleaner body
(Figure
32).
Note:
Avoid knocking the filter into the side of
the body.
Important:
Do not attempt to clean the filter.
2.
Inspect the new filter for tears, an oily film, or
damage to the rubber seal. Look into the filter
while shining a bright light on the outside of the
filter; holes in the filter appear as bright spots.
If the filter is damaged, do not use it.
3.
Carefully install the filter
Note:
Ensure that the filter is fully seated
by pushing on the outer rim of the filter while
installing it.
Figure 32
4. Primary filter
5. Air-filter body
6. Service indicator
(Figure
Replacing the Filter
(Figure
32).
Important:
area of the filter.
4.
Install the air-cleaner cover with the dust cap
oriented downward and secure the latches
(Figure
32).
5.
Close the hood.
Servicing the Carbon
Canister
g031236
Replacing the Carbon-Canister Air
Filter
Service Interval: Every 200 hours—Replace the
1.
Park the machine on a level surface, engage the
parking brake, and lower the loader arms.
2.
Shut off the engine and remove the key.
3.
Remove the rear-access cover.
4.
Remove and discard the carbon-canister air
filter
(Figure
1. Hose clamp
2. Hose to carbon canister
3. Carbon canister
5.
Install a new filter onto the carbon canister
(Figure
33).
6.
Install the rear-access cover.
27
Do not press on the soft inside
carbon-canister air filter (Service
more frequently if conditions are
extremely dusty or sandy).
33).
Figure 33
4. Air filter
5. Purge-line filter
6. Rear access door
g018430