Engine General Information And Diagnosis (Tbi For G10) - Suzuki Swift User Manual

ENGINE GENERAL INFORMATION
WARNING:
For vehicles equipped with Supplemental Restraint (Air Bag) System:
D Service on and around the air bag system components or wiring must be performed only by an autho-
rized SUZUKI dealer. Refer to "Air Bag System Components and Wiring Location View" under "Gener-
al Description" in air bag system section in order to confirm whether you are performing service on
or near the air bag system components or wiring. Please observe all WARNINGS and "Service Precau-
tions" under "On-Vehicle Service" in air bag system section before performing service on or around
the air bag system components or wiring. Failure to follow WARNINGS could result in unintentional
activation of the system or could render the system inoperative. Either of these two conditions may
result in severe injury.
D Technical service work must be started at least 90 seconds after the ignition switch is turned to the
"LOCK" position and the negative cable is disconnected from the battery. Otherwise, the system may
be activated by reserve energy in the Sensing and Diagnostic Module (SDM).

ENGINE GENERAL INFORMATION AND DIAGNOSIS (TBI for G10)

ENGINE GENERAL INFORMATION AND DIAGNOSIS (SFI for G13)
ENGINE MECHANICAL (G10)
ENGINE MECHANICAL (G13 1 cam 16 valves)
ENGINE COOLING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ENGINE FUEL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ENGINE AND EMISSION CONTROL SYSTEM (TBI for G10)
ENGINE AND EMISSION CONTROL SYSTEM (SFI for G13)
IGNITION SYSTEM (G10 ENGINE)
IGNITION SYSTEM (G13 ENGINE)
CRANKING SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
CHARGING SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
EXHAUST SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
NOTE:
For the descriptions for vehicle without warm up three way catalytic converter (WUTWC), refer to Section
6 and 6E1 of the Service Manual mentioned in the FOREWORD of this manual.
GENERAL INFORMATION
Statement on Cleanliness and Care
General Information on Engine Service
Precaution on Fuel System Service
Fuel Pressure Relief Procedure
Fuel Leakage Check Procedure
ENGINE DIAGNOSIS . . . . . . . . . . . . . . . . . . .
ENGINE GENERAL INFORMATION AND DIAGNOSIS (TBI FOR G10) 6-1
SECTION 6
AND DIAGNOSIS
(TBI FOR G10)
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
CONTENTS
. . . . . . . . . . . . . . 6- 3
. . . . . 6- 3
. . 6- 3
. . . . . 6- 4
. . . . . . . . 6- 5
. . . . . . . . 6- 5
6- 6
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Description . . . . . . . . . . . . . . . . . . .
On-Board Diagnostic System
Precaution in Diagnosing Trouble
Engine Diagnostic Flow Table
Customer Problem Inspection From
Malfunction Indicator Lamp Check
Diagnostic Trouble Code Check
6
6-1
6-1-1
6A-1
6A1-1
6B-1
6C-1
6E1-1
6E2-1
6F-1
6F1-1
6G-1
6H-1
6K-1
6- 6
. . . . . . . . . . 6- 6
. . . . . . . 6- 9
. . . . . . . . . . 6-10
. . . . . 6-12
. . . . . . 6-13
. . . . . . . . 6-13