Page 1
Component Replacement - electrical - Xperia C5502 /C5503/ M36h 1287.4302 Rev 1 Sony Mobile Communications AB – Company Internal...
Page 2
1220-1336: Generic Repair Manual - electrical Test after electrical replacement: refer to 1273-1772 Mechanical Test Instruction Do not remove shield can lids (Heat pasta are added and RF performance will be damaged) 1287-4302 Rev 1 Sony Mobile Communications AB – Company Internal 2(10)
HA/ST = Hot Air for removal - Soldering Tool for mounting BGA = BGA Station BH = Bottom Heater ADDITIONAL INFORMATION 1 (2,3,4, etc.) = Proceed to ‘Additional Repair Info’ for further instructions in the indicated section(s). 1287-4302 Rev 1 Sony Mobile Communications AB – Company Internal 3(10)
Page 4
S HA+BH 13 X8006 Conn Pogopin Plug 1p 1267-0901 S HA+BH 14 X8400 Conn Pogopin Plug 1p 1267-0901 S HA+BH 15 X8600 Conn Leaf Spring Plug 1p Antenna/Groundi 1238-5876 1287-4302 Rev 1 Sony Mobile Communications AB – Company Internal 4(10)
Component Placing To access the Component Placing document, double-click the icon below. Applicable for on-screen viewing only – icon not shown on hard-copies. Primary side Secondary side 1287-4302 Rev 1 Sony Mobile Communications AB – Company Internal 5(10)
Replace if open circuit (USB charger not working) Protect the USB and BtB connectors with capton tape! R1300 Replace if open circuit (Phone dead) Protect the Battery connector with capton tape! 1287-4302 Rev 1 Sony Mobile Communications AB – Company Internal 6(10)
Page 7
Protect the BtB connector with capton tape! X2801 Replace if open circuit 1-2 (No or bad network, main antenna) X2802 Replace if mechanical damaged (No or bad network, main antenna) 1287-4302 Rev 1 Sony Mobile Communications AB – Company Internal 7(10)
Page 8
Protect the Coax, USB and BtB connectors with capton tape! X8001 Replace if open circuit 1-2 ( no or bad WLAN/ BT/ GPS) Protect the BtB connector with capton tape! 1287-4302 Rev 1 Sony Mobile Communications AB – Company Internal 8(10)
Page 9
GPS) Protect the Coax connector with capton tape! X8600 Replace if mechanical damaged ( no or bad NFC) Protect the Coax, USB and BtB connectors with capton tape! 1287-4302 Rev 1 Sony Mobile Communications AB – Company Internal 9(10)