Page 1
VIDEO PROJECTOR VPL-GH10 REMOTE COMMANDER RM-PJVW60 SERVICE MANUAL 1st Edition...
Page 2
Pour toute réparation faire appel à une personne compétente uniquement. CAUTION Danger of explosion if battery is incorrectly replaced. Replace only with the same or equivalent type recommended by the manufacturer. When you dispose of the battery, you must obey the law in the relative area or country. VPL-GH10...
CB ................... 4-4 DDC/ABGamma/LCK/OGMTable/ GA, GB ................4-5 CSMatrixTable Data from the Board ....1-21 QA (1/3) ................4-6 1-7. Memory ................. 1-22 HA, HB, NF, NR, QA (2/3), TA, TL, U, V ....4-7 QA (3/3) ................4-8 VPL-GH10...
4 Remove the HA board block in the direction of the arrow A. 2 Three claws 5 HA board block Hood block 9 HA chassis HA board CN60 0 HA board 6 HA button 7 Button (P) 8 Two claws (+PSW 3 x 8) VPL-GH10...
5 Screw (+BVTP 3 x 12) 6 NF board CN40 7 NF lens HB board CN80 1 Two screws (+BVTP 3 x 12) 3 Remove the front panel block 8 Front panel block in the direction of the arrow. VPL-GH10...
![ Remove harnesses from the seven claws. Marking is printed Fuse connector on the bottom. assembly Lead with connector Claw (LVDS) != Remove it while pressing the claw D.C. fan of the connector. (Sirocco) Lamp power connector assembly Fan connector VPL-GH10...
CA board, insert the two connectors (SP BG) 3 Five screws Note: and press them securely. Before installing the Shield cover (C), (+PSW 3 x 8) confirm that the Gasket (SP BG) is not turned outward or not peeled off. Gasket (SP BG) VPL-GH10...
9 Optical unit assembly 2 Light interception sheet (C) 1 Remove the C shield case assembly 7 Three claws in the direction of the arrow. 8 Focus ring assembly 4 Optics attachment 6 Lamp block assembly 5 Loosen three screws. VPL-GH10...
3 Remove harnesses from the five claws. Fan connector Fan connector 7 Two screws CN101 (+PSW 3 x 8) 0 Remove the GA board CN103 in the direction of the arrow A. CN105 CN106 CN104 CN107 G Holder 8 Claw 9 Dowel GA board VPL-GH10...
1 Fan connector (+BVTP 3 x 12) 6 Chassis fan duct (OUT) 4 D.C. fan block 9 D.C. fan 3 Louver (R) 8 Eight fan dampers 7 Lamp fan duct (ATT) 5 Two screws (+BVTP 3 x 12) 1-10 VPL-GH10...
![ Sheet (BA) the new part without re-use. Lamp power connector assembly 8 Two screws (+BVTP 3 x 12) !] Lamp power supply 9 Remove the lamp power connector assembly in the direction of the arrow C. 0 Two claws 1-11 VPL-GH10...
When replacing the D.C. motor, replace the two sirocco cushions with new parts without re-use. 0 Two sirocco cushions !- Fan cover (84C) !] D.C. motor 9 Four claws 8 Two screws != Fan cover (+BVTP 3 x 12) (84I) 1-12 VPL-GH10...
3 Raise the food block in the direction of the arrow. 4 Dowel 6 Two screws (+BVTP 3 x 12) 8 Fan duct !- D.C. fan (EX) 7 Two claws 9 Top duct (EX), 0 Eight fan dampers Bottom duct (EX) 1-13 VPL-GH10...
(LVDS) 5 Two hexagon screws (There is a height difference. ) 6 Two hexagon screws 7 Dowel (No height difference) Two hexagon screws (No height difference) Two hexagon screws (There is a height difference. ) NETWORK REMOTE DVI-D 1-14 VPL-GH10...
Note when replacing Heat sink When replacing Heat sink, the (C) cannot be re-used. RADIATION SHEET Be sure to replace the RADIATION SHEET 3 Radiation sheet (C) (C) with the new one when replacing Heat sink. 4 QA board 1-15 VPL-GH10...
D MOLEX service connector assembly (4P) H JST service connector assembly B (6P) ∗ 1. This cable is not used for service for GH10. ∗ 2. For the GH10, only one cable is used among the two cables. 1-16 VPL-GH10...
CN9400 (8P) CN400 From CN303 on the GB board. From CN105 on the GA board. CN601 CN9601 (4P) From X2 on the lamp power supply. CN600 CN9600 (5P) CN1702 (14P) CN702 From the HB, NF, TA and V boards. 1-17 VPL-GH10...
Page 22
CN400 ∗ CN9400 (8P) CN801 CN1001 (9P) ∗ ∗ To the D.C. fan. CN601 (4P) CN9601 (4P) CN1003 (14P) To the lens. ∗ CN600 (5P) CN9600 (5P) CN1702 (14P) ∗ CN702 CN802 To the D.C. fan. CN900 (8P) 1-18 VPL-GH10...
Gain B Copy”.) In case if the original data cannot be copied, perform the Panel Driver Gain B Adjustment. (For the method of Panel Driver Gain B Adjust- ment, refer to “2-5. Panel Driver Gain B Adjust- ment”.) 1-19 VPL-GH10...
* See Technical Memo DPPJ03-064 for more details. 6. Change the value of OTHER: 17 Lens Shift/Right Limit in Device Menu. 7. Change the value of OTHER: 18 Lens Shift/Left Limit in Device Menu. 8. Perform Save to Memory. 1-20 VPL-GH10...
3. Double-click on “QuickAccess.exe” to launch the 2. Turn the power on to the projector. application. 3. Double-click on “QuickAccess.exe” to launch the 4. Select “VPL-GH10” from the [Model] pull-down application. menu. 4. Select “VPL-GH10” from the [Model] pull-down 5. Select “Load” from the [Load/Save] pull-down menu.
Page 28
FAN Memory IRIS Open IRIS Open Memory Memory IRIS Close IRIS Close LUT Memory LUT Memory No Memory No Memory Sub Micro Memory Sub Micro Memory Sub Micro Memory Panel Alignment Memory Panel Alignment Memory Panel Alignment Memory 1-24 VPL-GH10...
1-8. Network 1-8-1. Overview VPL-GH10 is equipped with the Network terminal. The user can check the projector status, and can implement the various settings such as controls of the projector and setups of the Network block by using the Web-browser.
Page 30
When the user is prompted to enter the user name and the password, type them as follows. User name : service Password : vpl-gh10 If the user wants to move to another page from the service mode once, and then re-enter into it again, exit the Web-browser and re-launch it.
1-8-3. Firmware Update Function (1) Update Preparation Set the power of the projector in the standby state. Click the [Update] tab shown on the Service web page. Fig.3 Service screen 1-27 VPL-GH10...
Page 32
The upgrade requirement is issued at the moment when the [Update] button is clicked in the Firmware Updater, which is described later. The upgrade requirement is not issued if simply the Firmware Updater is launched. 1-28 VPL-GH10...
Page 33
Click the [Search] button to specify the projector whose firmware the client wants to upgrade. If the IP address of the projector to be upgraded is already known, it can be typed directly in this field. (Delimit the IP address with a period.) Fig.6 Firmware Updater - Step1 screen (2) 1-29 VPL-GH10...
Page 34
The following information is displayed on the Firmware Updater (1/5) screen (Fig. 8). . Model Name . Serial No. . Location (The display shows blank if the location is not set.) . IP Address Fig.8 Firmware Updater - Step1 screen (3) Click the [Next] button. 1-30 VPL-GH10...
Page 35
. SCALER : Specify the “PixelWorks” firmware (*.inf file). . SUB : Specify the firmware of the Sub microcomputer (*.mot file). After selecting the firmware and the file, click the [Next] button. Fig.10 Firmware Updater - Step2 screen (2) 1-31 VPL-GH10...
Page 36
Fig.11 Firmware Updater - Step3 screen (6) Upgrade Processing Fig.12 Firmware Updater - Processing screen The upgrade process performs the file transfer firstly, and then upgrades the firmware. The end screen automatically appears after the upgrade is completed. 1-32 VPL-GH10...
Page 37
The upgrade may take time due to the block caused by the Firewall function. In this case, temporarily disable the Firewall function. * When performing the upgrade on a PC in which Windows XP SP2 is installed, the upgrade time may be shortened by temporarily setting “Windows Firewall” to [Unblock]. 1-33 VPL-GH10...
. Serial No. : Serial number . Location : Installation location (The screen displays blank if the location is not specified.) . ROM Ver. : SC ROM version, NVM version, SUB ROM version, IP ROM version Fig.14 Event Trace screen 1-34 VPL-GH10...
Page 39
NVM DATA ERROR : NVM DATA Error COOLING SETTING WARNING : Cooling Setting Warning LAMP REPLACE : Lamp Replace SIGNAL WARNING FREQUENCY OVER : Signal Warning Frequency Over FILTER CLEANING : Filter Cleaning FILTER REPLACE : Filter Replace 1-35 VPL-GH10...
VM0303B YC-13 Cord type H05VV-F CEE (13) 53 rd (OC) VCTF Rated Voltage & Current 10A/125V 10A/250V 10A/250V 12A/125V Safety approval UL/CSA * Use a rated plug that complies with the regulation of each country/region and the specifications. 1-36 VPL-GH10...
Advanced Iris in Cinema Black Pro in Picture Adjust is changed without performing “Save to memory”. When “Save to memory” is performed at that time, the UF data of each Iris mode will be overwrit- ten and lost. VPL-GH10...
Repeat the adjustments at 80 IRE and 20 IRE until the specification is satisfied. (x80, y80) = (0.284 ± 0.002, 0.298 ± 0.002) Save the adjusted values. Repeat the adjustments at 80 IRE and 20 IRE until the specification is satisfied. Save the adjusted values. VPL-GH10...
“Other: 03 Iris/Close Reg” when the luminance level reaches 32% of [OFF Luminance]. (11)Save the values of “Other: 03 Iris/Close Reg” of step (10) in a memory. (12)Return the value of “Other: 01 Iris/Adj” to 0, and perform Save to Memory. VPL-GH10...
Ne les remplacer que par une pièce portant le numéro spécifié. 2. Standardization of Parts Some repair parts supplied by Sony differ from those used for the unit. These are because of parts common- ality and improvement. Parts List has the present standardized repair parts.
Page 49
3-879-174-01 s SPRING, HA 3-879-176-11 s KEY TOP 3-879-177-11 s BUTTON, HA 3-879-179-11 s COVER, HA 4-029-432-01 s SCREW (3X12), (+) BVWHTP 4-099-122-02 s SCREW +BV 3X70 TYPE 2, SPECIAL 4-104-449-01 s SHAFT 85 7-685-648-79 s SCREW +BVTP 3X12 TYPE2 IT-3 VPL-GH10...
Page 51
3-080-039-01 s CLAMP (FCR-15), FLAT 3-875-754-01 s SHEET (BA) 3-879-168-11 s LOUVER (R) 3-879-169-11 s LOUVER (L) 4-042-911-21 o INSULATOR 4-123-098-01 s HOLDER 4-374-846-01 o COVER, CAPACITOR, CAP TYPE 7-685-648-79 s SCREW +BVTP 3X12 TYPE2 IT-3 7-682-650-01 s SCREW +PS 3X12 VPL-GH10...
Page 52
+BVTP 3x12 +BVTP 3x12 +BVTP 3x12 +BVTP 3x12 ∗ +BVTP 3x12 +BVTP 3x12 ∗ When replacing the D.C. motor, the 213 CUSHION, SIROCCO cannot be re-used. When replacing the D.C. motor, replace sirocco cushions with new parts without re-use. VPL-GH10...
Page 53
2-695-514-01 s FOOT, REAR 3-215-723-01 s SHEET (C), RADIATION 3-274-866-01 s HEAT SINK EMMA2THH 3-879-171-11 s COVER, LAMP 4-120-037-01 s SHEET J 4-135-297-01 s SHEET, CONNECTOR 4-303-605-01 s NUT 8-835-883-02 s MOTOR, DC SFF22D/C-NP 7-685-648-79 s SCREW +BVTP 3X12 TYPE2 IT-3 VPL-GH10...
Page 54
∗ When the CA board, CB board and other parts are disassembled, replace the radiation sheets with new ones. When removing parts, refer to Disassembly (section 1-3-7 and section 1-3-8). 312 RADIATIOIN SHEET (12-12) and 314 RADIATIOIN SHEET (Q). VPL-GH10...
Page 55
2-580-603-01 s SCREW, +PSW M4X16 2-887-853-21 s CUSHION (LAMP FAN) 3-879-170-01 s FOCUS, RING 4-112-208-01 s CUSHION (LF), SHADING 4-121-030-01 s SHEET (12-12), RADIATION A-1717-431-A s OPTICS BLOCK ASSY 4-116-614-01 s SHEET (Q), RADIATION 7-685-648-79 s SCREW +BVTP 3X12 TYPE2 IT-3 VPL-GH10...
1-112-777-11 s CAP, CERAMIC 0.01MF X7R 1005 C2011 1-114-353-11 s CAP, CERAMIC 0.01MF X7R (1410) C3030 1-112-777-11 s CAP, CERAMIC 0.01MF X7R 1005 C2012 1-114-353-11 s CAP, CERAMIC 0.01MF X7R (1410) C3031 1-112-777-11 s CAP, CERAMIC 0.01MF X7R 1005 3-10 VPL-GH10...
Page 57
1-100-909-11 s CAP, CERAMIC 10MF X6S 2012 C3529 1-112-777-11 s CAP, CERAMIC 0.01MF X7R 1005 C3588 1-100-909-11 s CAP, CERAMIC 10MF X6S 2012 C3530 1-100-909-11 s CAP, CERAMIC 10MF X6S 2012 C3589 1-100-909-11 s CAP, CERAMIC 10MF X6S 2012 3-11 VPL-GH10...
Page 58
1-100-909-11 s CAP, CERAMIC 10MF X6S 2012 C4546 1-114-353-11 s CAP, CERAMIC 0.01MF X7R (1410) C5045 1-100-909-11 s CAP, CERAMIC 10MF X6S 2012 C4547 1-114-353-11 s CAP, CERAMIC 0.01MF X7R (1410) C5046 1-112-777-11 s CAP, CERAMIC 0.01MF X7R 1005 3-12 VPL-GH10...
Page 59
1-112-779-11 s CAP, CERAMIC 0.047MF X7R 1005 C5512 1-114-326-11 s CAP, CERAMIC 0.22MF X7R 1608 C6030 1-100-911-11 s CAP, CERAMIC 4.7MF X7R (3216) C5513 1-114-326-11 s CAP, CERAMIC 0.22MF X7R 1608 C6031 1-100-911-11 s CAP, CERAMIC 4.7MF X7R (3216) 3-13 VPL-GH10...
Page 60
C7056 1-112-777-11 s CAP, CERAMIC 0.01MF X7R 1005 C6534 1-137-942-21 s CAP, ELECT 47MF (6.3X5.4) C7501 1-100-916-11 s CAP, CERAMIC 0.1MF X7R 1005 C6535 1-137-942-21 s CAP, ELECT 47MF (6.3X5.4) C7502 1-114-333-11 s CAP, CERAMIC 47MF X6S 3216 3-14 VPL-GH10...
Page 61
1-112-779-11 s CAP, CERAMIC 0.047MF X7R 1005 ET015 1-694-802-21 s CONTACT TERMINAL C8020 1-112-779-11 s CAP, CERAMIC 0.047MF X7R 1005 C8021 1-112-779-11 s CAP, CERAMIC 0.047MF X7R 1005 ET016 1-694-802-21 s CONTACT TERMINAL C8022 1-112-779-11 s CAP, CERAMIC 0.047MF X7R 1005 3-15 VPL-GH10...
Page 62
1-469-551-21 s INDUCTOR, CHIP 2.2UH (LB2016) FL6002 1-234-939-21 s FILTER, EMI REMOVAL (SMD) L2007 1-469-551-21 s INDUCTOR, CHIP 2.2UH (LB2016) FL6501 1-234-939-21 s FILTER, EMI REMOVAL (SMD) L2008 1-469-551-21 s INDUCTOR, CHIP 2.2UH (LB2016) FL6502 1-234-939-21 s FILTER, EMI REMOVAL (SMD) 3-16 VPL-GH10...
Page 63
1-218-990-81 s CONDUCTOR, CHIP (1005) Q1504 6-550-663-01 s TRANSISTOR RSS100N03FD5TB R1504 1-218-990-81 s CONDUCTOR, CHIP (1005) Q2501 6-551-321-01 s TRANSISTOR RT3WLMM-TP-1F R1505 1-208-923-81 s RES, CHIP 33K (1005) R1506 1-208-935-81 s RES, CHIP 100K (1005) Q2502 6-551-690-01 s TRANSISTOR RT3N11M-TP-1 3-17 VPL-GH10...
Page 64
1-218-935-81 s RES, CHIP 33 R2038 1-218-941-81 s RES, CHIP 100 R3514 1-218-935-81 s RES, CHIP 33 R2039 1-218-941-81 s RES, CHIP 100 R3515 1-218-935-81 s RES, CHIP 33 R2040 1-218-941-81 s RES, CHIP 100 R3516 1-218-939-81 s RES, CHIP 68 3-18 VPL-GH10...
Page 65
1-218-937-81 s RES, CHIP 47 R4013 1-218-965-81 s RES, CHIP 10K R5041 1-218-937-81 s RES, CHIP 47 R4014 1-216-864-91 s CONDUCTOR, CHIP (1608) R5043 1-218-933-81 s RES, CHIP 22 R4015 1-218-953-81 s RES, CHIP 1.0K R5044 1-218-933-81 s RES, CHIP 22 3-19 VPL-GH10...
Page 66
1-218-933-81 s RES, CHIP 22 R5548 1-218-933-81 s RES, CHIP 22 R6039 1-218-933-81 s RES, CHIP 22 R5549 1-218-933-81 s RES, CHIP 22 R6040 1-218-933-81 s RES, CHIP 22 R5550 1-218-933-81 s RES, CHIP 22 R6041 1-218-933-81 s RES, CHIP 22 3-20 VPL-GH10...
Page 67
1-218-929-81 s RES, CHIP 10 R6110 1-218-929-81 s RES, CHIP 10 R6559 1-218-973-81 s RES, CHIP 47K R6111 1-218-929-81 s RES, CHIP 10 R6560 1-218-973-81 s RES, CHIP 47K R6112 1-218-969-81 s RES, CHIP 22K R6561 1-218-965-81 s RES, CHIP 10K 3-21 VPL-GH10...
Page 68
1-218-929-81 s RES, CHIP 10 R7050 1-218-933-81 s RES, CHIP 22 R7535 1-218-933-81 s RES, CHIP 22 R7051 1-218-933-81 s RES, CHIP 22 R7536 1-218-933-81 s RES, CHIP 22 R7052 1-218-933-81 s RES, CHIP 22 R7537 1-218-933-81 s RES, CHIP 22 3-22 VPL-GH10...
Page 69
1-218-941-81 s RES, CHIP 100 RB1503 1-234-371-21 s RES, NETWORK 47 (1005X4) R8025 1-218-965-81 s RES, CHIP 10K RB2501 1-234-371-21 s RES, NETWORK 47 (1005X4) R8028 1-218-965-81 s RES, CHIP 10K RB2502 1-234-371-21 s RES, NETWORK 47 (1005X4) 3-23 VPL-GH10...
Page 70
1-234-370-21 s RES, NETWORK 22 (1005X4) RB4008 1-234-371-21 s RES, NETWORK 47 (1005X4) RB3506 1-234-370-21 s RES, NETWORK 22 (1005X4) RB4009 1-234-371-21 s RES, NETWORK 47 (1005X4) RB3507 1-234-370-21 s RES, NETWORK 22 (1005X4) RB4010 1-234-371-21 s RES, NETWORK 47 (1005X4) 3-24 VPL-GH10...
Page 71
1-814-033-11 s QUARTZ CRYSTAL UNIT (33.3MHZ) RB5013 1-234-370-21 s RES, NETWORK 22 (1005X4) X2502 1-814-032-11 s OSCILLATOR, CRYSTAL RB5014 1-234-370-21 s RES, NETWORK 22 (1005X4) X4001 1-814-033-11 s QUARTZ CRYSTAL UNIT (33.3MHZ) RB5015 1-234-370-21 s RES, NETWORK 22 (1005X4) 3-25 VPL-GH10...
Page 72
C3060 1-100-916-11 s CAP, CERAMIC 0.1MF X7R 1005 C2008 1-114-367-11 s CAP, CERAMIC 0.1MF X6S 1005 C3061 1-100-905-11 s CAP, CERAMIC1000PF X7R 1005 C2009 1-100-905-11 s CAP, CERAMIC1000PF X7R 1005 C3062 1-100-916-11 s CAP, CERAMIC 0.1MF X7R 1005 3-26 VPL-GH10...
Page 73
C3178 1-100-916-11 s CAP, CERAMIC 0.1MF X7R 1005 C3120 1-100-916-11 s CAP, CERAMIC 0.1MF X7R 1005 C3179 1-100-916-11 s CAP, CERAMIC 0.1MF X7R 1005 C3121 1-100-905-11 s CAP, CERAMIC1000PF X7R 1005 C3180 1-100-905-11 s CAP, CERAMIC1000PF X7R 1005 3-27 VPL-GH10...
Page 74
1-100-909-11 s CAP, CERAMIC 10MF X6S 2012 C4048 1-112-777-11 s CAP, CERAMIC 0.01MF X7R 1005 C4112 1-131-956-21 s CAP, ELECT 220MF (6.3X5.4) C4049 1-112-777-11 s CAP, CERAMIC 0.01MF X7R 1005 C4113 1-100-909-11 s CAP, CERAMIC 10MF X6S 2012 3-28 VPL-GH10...
Page 75
1-112-777-11 s CAP, CERAMIC 0.01MF X7R 1005 C5055 1-164-874-81 s CAP,CHIP CERAMIC 100PF CH 1005 C6047 1-112-777-11 s CAP, CERAMIC 0.01MF X7R 1005 C5056 1-100-916-11 s CAP, CERAMIC 0.1MF X7R 1005 C6048 1-100-905-11 s CAP, CERAMIC1000PF X7R 1005 3-29 VPL-GH10...
Page 76
1-400-331-21 s FERRITE, EMI (SMD) (1005) FB3002 1-400-462-21 s FERRITE, EMI (SMD) (1005) Q1006 6-550-663-01 s TRANSISTOR RSS100N03FD5TB FB3003 1-400-331-21 s FERRITE, EMI (SMD) (1005) Q1007 6-550-663-01 s TRANSISTOR RSS100N03FD5TB FB3004 1-400-462-21 s FERRITE, EMI (SMD) (1005) Q1008 6-709-438-01 s TRANSISTOR FDS6986AS 3-30 VPL-GH10...
Page 77
1-218-935-81 s RES, CHIP 33 R1062 1-218-959-81 s RES, CHIP 3.3K R2065 1-218-935-81 s RES, CHIP 33 R1063 1-218-957-81 s RES, CHIP 2.2K R2066 1-218-935-81 s RES, CHIP 33 R1064 1-218-990-81 s CONDUCTOR, CHIP (1005) R2067 1-218-935-81 s RES, CHIP 33 3-31 VPL-GH10...
Page 78
1-218-990-81 s CONDUCTOR, CHIP (1005) R4001 1-218-933-81 s RES, CHIP 22 R5034 1-218-990-81 s CONDUCTOR, CHIP (1005) R4002 1-218-933-81 s RES, CHIP 22 R5035 1-218-990-81 s CONDUCTOR, CHIP (1005) R4003 1-218-933-81 s RES, CHIP 22 R5036 1-218-990-81 s CONDUCTOR, CHIP (1005) 3-32 VPL-GH10...
Page 79
1-218-941-81 s RES, CHIP 100 R5104 1-218-965-81 s RES, CHIP 10K R6063 1-218-990-81 s CONDUCTOR, CHIP (1005) R5105 1-218-965-81 s RES, CHIP 10K R6064 1-218-990-81 s CONDUCTOR, CHIP (1005) R5108 1-218-965-81 s RES, CHIP 10K R6065 1-218-990-81 s CONDUCTOR, CHIP (1005) 3-33 VPL-GH10...
Page 80
1-234-371-21 s RES, NETWORK 47 (1005X4) RB5032 1-234-702-21 s RES, NETWORK 68 (1005X4) RB4013 1-234-371-21 s RES, NETWORK 47 (1005X4) RB5033 1-234-702-21 s RES, NETWORK 68 (1005X4) RB4014 1-234-371-21 s RES, NETWORK 47 (1005X4) RB5034 1-234-702-21 s RES, NETWORK 68 (1005X4) 3-34 VPL-GH10...
Page 81
6-550-760-01 s TRANSISTOR 2SA1363-T111-1E Q102 8-729-620-07 s TRANSISTOR 2SC3052EF-T1-LEF Q104 6-551-678-01 s TRANSISTOR 2SA1364-T111-1DE Q105 8-729-620-07 s TRANSISTOR 2SC3052EF-T1-LEF Q106 8-729-038-28 s TRANSISTOR RT1N441C-TP-1 R101 1-245-502-21 s ANTI SURGE RESISTOR 4.7M R104 1-219-759-91 s RESISTOR (SURGE RESISTANT) 1M 3-35 VPL-GH10...
Page 82
1-112-222-21 s CAP, ELECT 2200MF 105 C317 1-114-325-11 s CAP, CERAMIC 0.1MF X7R 1608 C318 1-128-955-31 s CAP, ELECT 2200MF C319 1-128-955-31 s CAP, ELECT 2200MF C320 1-114-325-11 s CAP, CERAMIC 0.1MF X7R 1608 C321 1-114-325-11 s CAP, CERAMIC 0.1MF X7R 1608 3-36 VPL-GH10...
Page 83
1-218-871-91 s RES, CHIP 10K (1608) R229 1-216-849-91 s RES, CHIP 220K (1608) L201 1-457-277-11 s CHOKE COIL 260UH R230 1-216-837-91 s RES, CHIP 22K (1608) L202 1-481-165-11 s COIL, CHOKE 100UH R231 1-249-393-91 s RES, CARBON (SMALL) 10 3-37 VPL-GH10...
Page 84
1-220-778-81 s RES, NONFLAMMABLE FUSE 0.1 R317 1-216-833-91 s RES, CHIP 10K (1608) R318 1-216-833-91 s RES, CHIP 10K (1608) R320 1-216-833-91 s RES, CHIP 10K (1608) R321 1-243-803-71 s RES, OXIDE METAL FILM 0.33 R322 1-216-845-91 s RES, CHIP 100K (1608) 3-38 VPL-GH10...
Page 85
6-551-817-01 s TR UNR52A3G0LS0 1-216-813-91 s RES, CHIP 220 (1608) 1-216-809-91 s RES, CHIP 100 (1608) 1-216-809-91 s RES, CHIP 100 (1608) VDR80 1-803-974-21 s VARISTOR, CHIP (1608) VDR81 1-803-974-21 s VARISTOR, CHIP (1608) VDR82 1-803-974-21 s VARISTOR, CHIP (1608) 3-39 VPL-GH10...
Page 86
1-100-916-11 s CAP, CERAMIC 0.1MF X7R 1005 C425 1-114-331-11 s CAP, CERAMIC 4.7MF X7R 2012 C334 1-100-916-11 s CAP, CERAMIC 0.1MF X7R 1005 C426 1-112-781-11 s CAP, CERAMIC 1MF X7R 1608 C427 1-112-774-11 s CAP, CERAMIC 470PF X7R 1005 3-40 VPL-GH10...
Page 87
1-100-916-11 s CAP, CERAMIC 0.1MF X7R 1005 C516 1-112-777-11 s CAP, CERAMIC 0.01MF X7R 1005 C611 1-112-777-11 s CAP, CERAMIC 0.01MF X7R 1005 C517 1-112-777-11 s CAP, CERAMIC 0.01MF X7R 1005 C612 1-112-777-11 s CAP, CERAMIC 0.01MF X7R 1005 3-41 VPL-GH10...
Page 88
1-128-004-21 s CAP, ELECT (CHIP) 10MF C807 1-114-325-11 s CAP, CERAMIC 0.1MF X7R 1608 C1105 1-100-916-11 s CAP, CERAMIC 0.1MF X7R 1005 C808 1-114-325-11 s CAP, CERAMIC 0.1MF X7R 1608 C1106 1-100-916-11 s CAP, CERAMIC 0.1MF X7R 1005 3-42 VPL-GH10...
Page 89
1-820-190-11 s HEADER ASSEMBLY (PRINT PWB)13P FB600 1-400-331-21 s FERRITE, EMI (SMD) (1005) CN704 1-565-269-12 s SOCKET, CONNECTOR (D-SUB,L) 9P FB601 1-400-331-21 s FERRITE, EMI (SMD) (1005) CN800 1-819-474-11 s HEADER ASSEMBLY FOR PWB 6P FB602 1-400-331-21 s FERRITE, EMI (SMD) (1005) 3-43 VPL-GH10...
Page 90
6-704-843-01 s IC AIC1117A-PEJTR FB1020 1-400-331-21 s FERRITE, EMI (SMD) (1005) IC1105 6-808-643-01 s IC S29AL016D70TFI020-941IP100 FB1022 1-400-331-21 s FERRITE, EMI (SMD) (1005) IC1202 6-710-544-01 s IC M95640-WDW6TP FB1101 1-400-693-21 s INDUCTOR, FERRITE BEAD (1005) IC1204 6-703-225-01 s IC S-80928CNMC-G8YT2G 3-44 VPL-GH10...
Page 91
1-218-953-81 s RES, CHIP 1.0K Q605 6-551-321-01 s TRANSISTOR RT3WLMM-TP-1F R289 1-218-990-81 s CONDUCTOR, CHIP (1005) Q606 6-550-180-01 s TRANSISTOR SSM6N16FE(TPLR3) R290 1-218-961-81 s RES, CHIP 4.7K Q607 6-551-817-01 s TR UNR52A3G0LS0 R296 1-218-961-81 s RES, CHIP 4.7K 3-45 VPL-GH10...
Page 92
1-218-929-81 s RES, CHIP 10 R427 1-218-949-81 s RES, CHIP 470 R627 1-218-965-81 s RES, CHIP 10K 1005 R428 1-218-949-81 s RES, CHIP 470 R628 1-218-973-81 s RES, CHIP 47K R429 1-218-990-81 s CONDUCTOR, CHIP (1005) R629 1-218-941-81 s RES, CHIP 100 3-46 VPL-GH10...
Page 93
1-208-911-81 s RES, CHIP 10K (1005) R777 1-218-941-81 s RES, CHIP 100 R710 1-208-911-81 s RES, CHIP 10K (1005) R778 1-218-965-81 s RES, CHIP 10K 1005 R711 1-218-990-81 s CONDUCTOR, CHIP (1005) R780 1-218-965-81 s RES, CHIP 10K 1005 3-47 VPL-GH10...
Page 94
1-208-927-81 s RES, CHIP 47K (1005) R856 1-218-929-81 s RES, CHIP 10 R1016 1-218-937-81 s RES, CHIP 47 R857 1-208-947-81 s RES, CHIP 330K (1005) R1017 1-218-937-81 s RES, CHIP 47 R859 1-218-929-81 s RES, CHIP 10 R1018 1-218-937-81 s RES, CHIP 47 3-48 VPL-GH10...
Page 95
R1257 1-218-990-81 s CONDUCTOR, CHIP (1005) R1135 1-218-961-81 s RES, CHIP 4.7K R1136 1-218-955-81 s RES, CHIP 1.5K RB500 1-234-370-21 s RES, NETWORK 22 (1005X4) R1137 1-218-961-81 s RES, CHIP 4.7K RB501 1-234-370-21 s RES, NETWORK 22 (1005X4) 3-49 VPL-GH10...
Page 96
PACKING MATERIALS & SUPPLIED ACCESSORIES ---------------------------------------- Ref. No. or Q'ty Part No. SP Description 1-480-412-11 s REMOTE COMMANDER (RM-PJVW60) 1-831-499-31 s POWER-SUPPLY CORD SET 3-218-516-02 s PACK, CD-ROM 4-139-070-01 s MANUAL, INSTRUCTION (FRENCH, GERMAN) 200pc 7-632-452-24 s TAPE (NO.303) 18MMX35M YEL 3-50 VPL-GH10...
LEFT, RIGHT, DOWN, UP, KEY0,1 KEY0,1 ENTER, MENU, IC705 PIC MUTING, EEPROM POWER, LENS RY101 ECO ON ECO ON LAMP LED LAMP MON POWER LED X700 STBY LED IC101 16.384MHz ON/STB LINE STANDBY ECO3.3V AC IN FILTER POWER SUPPLY VPL-GH10...
Page 103
BE RST O PEARL RST AD1-AD5, AC1-AC4 LAN_RXD IC703 UART SW FW_WRT O EXCONT SW ROMOE IC712 ROMWE NETWORK SW O NET_POWER ON IC711 PEARL TXD0 AH12 TXD0 PEARL RXD0 AG12 RXD0 PEARL TXD1 TXD1 PEARL RXD1 RXD1 NETWORK_SW VPL-GH10...
Page 104
RUN/SS2 CN802 OUT 4 FAN4 PANEL Q806 Q801 PROT4 PCNT POWER ON PROT POWER PROT Q802 SUB5V NETWORK_SUB_5V NETWORK_SUB_3.3V IC1104 IC407 IC1103 Q803 5V REG 3.3V REG 1.5V REG Q1102 FAN PROT NETWORK_SUB_1.5V FAN STOP PLL_1.5V Q800 Q1101 NETWORK_SW VPL-GH10...
Page 105
Indicator 5-53 Front IR 5-54 Rear IR 5-54 Thermostat Sensor 5-55 Thermostat Sensor 5-55 Lamp Cover 5-56 Filter Cover 5-56 The components identified by mark contain confidential information. Strictly follow the instructions whenever the components are repaired and/or replaced. VPL-GH10...
Page 159
TA, TL CN35 -A SIDE- -B SIDE- SUFFIX: -11 SUFFIX: -11 -A SIDE- B SIDE- SUFFIX: -11 SUFFIX: -11 LAMP_TEMP TO QA TH35 1608 LAMPCOVER_IN TH70 LAMPCOVER_OUT CN70 GND_1 1608 EXT_TEMP TO QA FILTCOVER_OUT FILTCOVER_IN GND_1 CN35 5-55 5-55 VPL-GH10...
Page 160
U, V U, V CN30 -A SIDE- -B SIDE- -A SIDE- -B SIDE- SUFFIX: -11 SUFFIX: -11 SUFFIX: -11 SUFFIX: -11 LAMP_COVER TO QA TO QA FILT_COVER CN20 CN30 GND_1 GND_1 5-56 5-56 VPL-GH10...