Page 1
Стр. 1 из 1 LCD Color Television 40RF350U Ver. 2.01 file://D:\Documents and Settings\Admin\Рабочий стол\toshiba_40rf350u_sm\40RF3... 15.05.2015...
ADJUSTMENT [LCD Color Television] USA Стр. 1 из 8 ADJUSTMENT Service Mode Entering to Service Mode 1. Set VOLUME to minimum and press MUTE button twice on Control. ↓ ↓ ↓ ↓ 2. Press MUTE button again and hold button down.
Page 3
ADJUSTMENT [LCD Color Television] USA Стр. 2 из 8 Key Function in the Service Mode The following key entry during display of adjustment menu provides special functions. Selection of the adjustment items CH (on TV or remote control) Change of the data value Volume +/- (on TV or remote control) Adjustment menu mode ON/OFF MENU button (on remote control) Reset the count of operating...
Page 4
ADJUSTMENT [LCD Color Television] USA Стр. 3 из 8 (a) Seine3 CR Data RF350U : DRMA0579 Rev00 (VX4A00019000) (b) TV-MICRO EEPROM Data : DRMA0588 Rev00 (VX4A00019300) (2) Prior to changing any board containing an EEPROM IC, the exisiting data in each image format should be copied down as a precautionary measure.
Page 5
ADJUSTMENT [LCD Color Television] USA Стр. 4 из 8 OPT3 TV SET OPTION 3 OPT4 TV SET OPTION 4 OPT5 TV SET OPTION 5 SET-ID MODEL ID MAGC AGC of MTS decoder Volume1 Data Volume25 Data Volume50 Data Volume75 Data V100 Volume100 Data VOLBS Correction Volume at DTV VOLST Correction Volume at Stereo/SAP of ATV 00H...
Page 6
ADJUSTMENT [LCD Color Television] USA Стр. 5 из 8 WTBH TruBass High Level WTBL TruBass Low Level VOLM Volume coefficient at 1/2 Mute Factory preset data will be loaded after setting Model ID data. Note: (*1) SET-ID data is subject to the models. Refer to Setting Panel Option Data and SET-ID Data for detail.
ADJUSTMENT [LCD Color Television] USA Стр. 6 из 8 Self Diagnostic Function 1. Press "Recall" button on Remote Control during display of adjustment menu in the service mode. This will bring up the "S" in the right corner of screen. Now press "9" button on remote.
ADJUSTMENT [LCD Color Television] USA Стр. 7 из 8 Bus line normal is "None" displayed. When it is abnormal, the block name is displayed as follows. "SCL-GND" (Red indication) : SCL-GND short circuit "SDA-GND" (Red indication) : SDA-GND short circuit "SCL-SDA"...
Page 9
ADJUSTMENT [LCD Color Television] USA Стр. 8 из 8 Wait several seconds until the yellow LED stops blinking. 8 Green is on (solid). Upgrading in progress. Yellow is on (solid). 9 Green is on (solid). Upgrading succesful. Yellow is off. 10 Green is off.
Page 10
Стр. 1 из 2 FUNCTION AND OPERATION TV Front and Side Panel Controls and Connections file://D:\Documents and Settings\Admin\Рабочий стол\toshiba_40rf350u_sm\40RF3... 15.05.2015...
Page 11
Стр. 2 из 2 file://D:\Documents and Settings\Admin\Рабочий стол\toshiba_40rf350u_sm\40RF3... 15.05.2015...
Стр. 1 из 4 FUNCTION AND OPERATION Learning about the Remote Control file://D:\Documents and Settings\Admin\Рабочий стол\toshiba_40rf350u_sm\40RF3... 15.05.2015...
Page 13
Стр. 2 из 4 file://D:\Documents and Settings\Admin\Рабочий стол\toshiba_40rf350u_sm\40RF3... 15.05.2015...
Page 14
Стр. 3 из 4 file://D:\Documents and Settings\Admin\Рабочий стол\toshiba_40rf350u_sm\40RF3... 15.05.2015...
Page 15
Стр. 4 из 4 file://D:\Documents and Settings\Admin\Рабочий стол\toshiba_40rf350u_sm\40RF3... 15.05.2015...
Стр. 1 из 4 FUNCTION AND OPERATION Programming Channels into the TV's Channel Memory Programming Channels Automatically file://D:\Documents and Settings\Admin\Рабочий стол\toshiba_40rf350u_sm\40RF3... 15.05.2015...
Page 17
Стр. 2 из 4 file://D:\Documents and Settings\Admin\Рабочий стол\toshiba_40rf350u_sm\40RF3... 15.05.2015...
Стр. 3 из 4 Manually Adding and Deleting Channels in the Channel Memory file://D:\Documents and Settings\Admin\Рабочий стол\toshiba_40rf350u_sm\40RF3... 15.05.2015...
Page 19
Стр. 4 из 4 file://D:\Documents and Settings\Admin\Рабочий стол\toshiba_40rf350u_sm\40RF3... 15.05.2015...
Handling the LCD Module Стр. 1 из 4 SAFETY INSTRUCTION Handling the LCD Module Safety Precaution In the event that the screen is damaged or the liquid crystal (fluid) leaks, do not breathe in or drink this fluid. Also, never touch this fluid. Such actions could cause toxicity or skin irritation. If this fluid should enter the mouth, rinse the mouth thoroughly with water.
Page 21
Handling the LCD Module Стр. 2 из 4 3. If the panel surface becomes soiled, wipe with cotton or a soft cloth. If this does not remove the soiling, breathe on the surface and then wipe again. If the panel surface is extremely solied, use a CRT cleaner as a cleaner. Wipe off the panel surface by drop the cleaner on the cloth.
Page 22
Handling the LCD Module Стр. 3 из 4 6. CMOS-LSI circuitry is used in the LCD module, so avoid damage due to static electricity. When handling the module, use a wrist ground or anchor ground. 7. Do not expose the LCD module to direct sunlight or strong ultraviolet rays for an extended period of time.
Page 23
Handling the LCD Module Стр. 4 из 4 10. When transporting the LCD module, do not use packing containing epoxy resin (amine) or silicon resin (alcohol or oxim). The gas generated by these materials can cause loss of polarity. file://D:\Documents and Settings\Admin\Рабочий стол\toshiba_40rf350u_sm\40RF3... 15.05.2015...
Стр. 1 из 1 PANEL IDENTIFICATION Panel Identification If the several panels are alternatively used in the same model without amending the model name, the identification marking will be shown at the last digit of the set serial number on the specification label on the back cover.
Page 25
U02A LOW-B U03D U01A POWER U03A U04A AV TERM U03B Digital FRONT- U03C U03E LED/IR-PATH ILLUMINATION...
Стр. 1 из 3 SAFETY INSTRUCTION WARNING: BEFORE SERVICING THIS CHASSIS, READ THE "SAFETY PRECAUTION" AND "PRODUCT SAFETY NOTICE" INSTRUCTIONS BELOW. Safety Precaution WARNING: SERVICING SHOULD NOT BE ATTEMPTED BY ANYONE UNFAMILIAR WITH THE NECESSARY PRECAUTIONS ON THIS RECEIVER. THE FOLLOWING ARE THE NECESSARY PRECAUTIONS TO BE OBSERVED BEFORE SERVICING THIS CHASSIS.
Page 27
Стр. 2 из 3 inflammability, voltage resistance, etc. therefore, use only replacement parts that have these same characteristics. Use only the specified parts when the mark is indicated in the circuit diagram or parts list. 7. Parts mounting and routing dressing of wirings should be the same as that used originally.
Стр. 3 из 3 limit constitutes a potential shock hazard and must be corrected immediately. Product Safety Notice Many electrical and mechanical parts in this chassis have special safety-related characteristics. These characteristics are often passed unnoticed by a visual inspection and the protection afforded by them cannot necessarily be obtained by using replacement components rated for higher voltage, wattage, etc.
Стр. 1 из 3 SPECIFICATION file://D:\Documents and Settings\Admin\Рабочий стол\toshiba_40rf350u_sm\40RF3... 15.05.2015...
Page 30
Стр. 2 из 3 Acceptable signal formats for PC IN and HDMI terminals file://D:\Documents and Settings\Admin\Рабочий стол\toshiba_40rf350u_sm\40RF3... 15.05.2015...
Page 31
Стр. 3 из 3 file://D:\Documents and Settings\Admin\Рабочий стол\toshiba_40rf350u_sm\40RF3... 15.05.2015...
Unless otherwise noted in schematic, all capacitor values less than 1 are expressed in F, and the values more than 1 in pF. All capacitors are ceramic 50 V, unless otherwise noted as the following marks. file://D:\Documents and Settings\Admin\Рабочий стол\40RF350U Ver. 2.01\40RF35... 15.05.2015...
Page 48
AC volts. 5. Waveforms are taken receiving color bar signal with enough sensitivity. 6. Voltage reading shown are nominal values and may vary ±20 % except H.V. file://D:\Documents and Settings\Admin\Рабочий стол\40RF350U Ver. 2.01\40RF35... 15.05.2015...
Page 140
Стр. 1 из 2 CABINET Stand Exploded View A425 A426 A427 A428 A429 file://D:\Documents and Settings\Admin\Рабочий стол\40RF350U Ver. 2.01\40RF35... 15.05.2015...
Page 141
Стр. 2 из 2 file://D:\Documents and Settings\Admin\Рабочий стол\40RF350U Ver. 2.01\40RF35... 15.05.2015...
Abbreviations Capacitors CD : Ceramic Disk Resistors : Carbon film OMF : Oxide Metal Film : Plastic Film : Carbon Composition : Variable Resistor : Electrolytic file://D:\Documents and Settings\Admin\Рабочий стол\40RF350U Ver. 2.01\40RF35... 15.05.2015...
Page 143
Стр. 2 из 2 : Metal Film : Fusible Resistor All CD and PF capacitors are ±5 %, 50 V and all resistor, ±5 %, 1/6 W unless otherwise noted. file://D:\Documents and Settings\Admin\Рабочий стол\40RF350U Ver. 2.01\40RF35... 15.05.2015...
Page 144
U01A POWER (PE0450) C8807 76285104 CAPACITOR, CERAMIC CHIP, 50V B 0.1UF K U01A POWER (PE0450) C8808 76092883 CAPACITOR, CERAMIC CHIP, 50V B 0.1UF K U01A POWER (PE0450) C881 76092337 CAPACITOR, CERAMIC DISC, 2KV 220PF K file://D:\Documents and Settings\Admin\Рабочий стол\40RF350U Ver. 2.01\40RF35... 15.05.2015...
Page 145
D894 23357408 DIODE, FMX-12S(023-108) U01A POWER (PE0450) D894B 23717240 SCREW, BITTB3X10SZN U01A POWER (PE0450) D895 23362197 DIODE, SCHOTTKY, RB085T-60 U01A POWER (PE0450) D895B 23717240 SCREW, BITTB3X10SZN U01A POWER (PE0450) D896 23357408 DIODE, FMX-12S(023-108) file://D:\Documents and Settings\Admin\Рабочий стол\40RF350U Ver. 2.01\40RF35... 15.05.2015...
Page 146
IC, PHOTO COUPLER, TLP421F(GR) U01A POWER (PE0450) Q882 23085587 IC, TA76431S U01A POWER (PE0450) R801 75007964 RESISTOR, CARBON FILM, 1/2W 2.2M OHM J U01A POWER (PE0450) R802 76004718 RESISTOR, METAL GLAZE, 1/2W 8.2M OHM J file://D:\Documents and Settings\Admin\Рабочий стол\40RF350U Ver. 2.01\40RF35... 15.05.2015...
Page 147
COIL, LINE FILTER, TRF3258AD U01A POWER (PE0450) T860 75006066 TRANSFORMER, ST-3496 U01A POWER (PE0450) T861 75006066 TRANSFORMER, ST-3496 U01A POWER (PE0450) T880 23217840 TRANSFORMER, CONVERTER, TPW3585AD U02A LOW_B (PE0451) U02A 75008574 PWU, LOWB, PE0451A1 file://D:\Documents and Settings\Admin\Рабочий стол\40RF350U Ver. 2.01\40RF35... 15.05.2015...
Page 170
V03GD0001318 CHIP CERAMIC CAPACITOR (2012) U04AS SEINE (PE0434) CN60 75008681 0.5MM PITCH W TO B CONNECTOR U04AS SEINE (PE0434) CN61 V22GD0001451 2MM PITCH W TO B CONNECTOR U04AS SEINE (PE0434) CN70 23713819 CONNECTOR file://D:\Documents and Settings\Admin\Рабочий стол\40RF350U Ver. 2.01\40RF35... 15.05.2015...
Page 171
IC VOLTAGE REGULATOR U04AS SEINE (PE0434) IC641 75008003 IC ANALOG SWITCH U04AS SEINE (PE0434) IC642 75008003 IC ANALOG SWITCH U04AS SEINE (PE0434) IC643 75008003 IC ANALOG SWITCH U04AS SEINE (PE0434) IC646 75008004 IC 3TO1DVI/HDMI SWITCH file://D:\Documents and Settings\Admin\Рабочий стол\40RF350U Ver. 2.01\40RF35... 15.05.2015...
Page 172
U04AS SEINE (PE0434) Q6415 V41GD0000243 PNP TRANSISTOR U04AS SEINE (PE0434) Q6416 V41GD0000243 PNP TRANSISTOR U04AS SEINE (PE0434) Q6418 V41GD0000243 PNP TRANSISTOR U04AS SEINE (PE0434) Q6419 V41GD0000243 PNP TRANSISTOR U04AS SEINE (PE0434) Q642 V41GD0000236 NPN TRANSISTOR file://D:\Documents and Settings\Admin\Рабочий стол\40RF350U Ver. 2.01\40RF35... 15.05.2015...
Page 173
R1055 V01GD0002421 CHIP RESISTOR(1005) U04AS SEINE (PE0434) R1056 V01GD0002421 CHIP RESISTOR(1005) U04AS SEINE (PE0434) R1057 V01GD0002421 CHIP RESISTOR(1005) U04AS SEINE (PE0434) R1058 V01GD0002421 CHIP RESISTOR(1005) U04AS SEINE (PE0434) R1060 75004059 CHIP RESISTOR (1005) file://D:\Documents and Settings\Admin\Рабочий стол\40RF350U Ver. 2.01\40RF35... 15.05.2015...
Page 174
CHIP RESISTOR (1005) U04AS SEINE (PE0434) R313 75008335 CHIP RESISTOR (1005) U04AS SEINE (PE0434) R314 V01GD0001349 CHIP RESISTOR (1005) U04AS SEINE (PE0434) R315 V01GD0001319 CHIP RESISTOR (1005) U04AS SEINE (PE0434) R316 V01GD0001319 CHIP RESISTOR (1005) file://D:\Documents and Settings\Admin\Рабочий стол\40RF350U Ver. 2.01\40RF35... 15.05.2015...
Page 175
V01GD0001733 CHIP RESISTOR (1005) U04AS SEINE (PE0434) R6133 V01GD0001733 CHIP RESISTOR (1005) U04AS SEINE (PE0434) R6134 V01GD0001733 CHIP RESISTOR (1005) U04AS SEINE (PE0434) R6135 V01GD0001733 CHIP RESISTOR (1005) U04AS SEINE (PE0434) R6136 V01GD0001733 CHIP RESISTOR (1005) file://D:\Documents and Settings\Admin\Рабочий стол\40RF350U Ver. 2.01\40RF35... 15.05.2015...
Page 176
CHIP RESISTOR (1005) U04AS SEINE (PE0434) R6442 75007601 CHIP RESISTOR (1005) U04AS SEINE (PE0434) R6443 75007601 CHIP RESISTOR (1005) U04AS SEINE (PE0434) R6444 75007987 CHIP RESISTOR (1005) U04AS SEINE (PE0434) R6445 75008532 CHIP RESISTOR (1005) file://D:\Documents and Settings\Admin\Рабочий стол\40RF350U Ver. 2.01\40RF35... 15.05.2015...
Page 177
CHIP RESISTOR (1005) U04AS SEINE (PE0434) R933 V01GD0001352 CHIP RESISTOR (1005) U04AS SEINE (PE0434) R934 V01GD0001352 CHIP RESISTOR (1005) U04AS SEINE (PE0434) R936 75008329 CHIP RESISTOR (1005) U04AS SEINE (PE0434) R937 V01GD0002207 CHIP JUMPER 1005TYPE file://D:\Documents and Settings\Admin\Рабочий стол\40RF350U Ver. 2.01\40RF35... 15.05.2015...
Page 178
V01GD0002207 CHIP JUMPER 1005TYPE U04AS SEINE (PE0434) W308 V01GD0002207 CHIP JUMPER 1005TYPE U04AS SEINE (PE0434) W309 V01GD0002207 CHIP JUMPER 1005TYPE U04AS SEINE (PE0434) W6003 V01GD0002209 CHIP JUMPER 1608TYPE U04AS SEINE (PE0434) W601 V01GD0002207 CHIP JUMPER 1005TYPE file://D:\Documents and Settings\Admin\Рабочий стол\40RF350U Ver. 2.01\40RF35... 15.05.2015...