Page 1
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL SERVICE MANUAL AUDIO/VIDEO CONTROL RECEIVER RX-6010RBK RX-6012RSL Area Suffix RX-6010RBK Continental Europe Northern Europe RX-6010RSL U.K. Continental Europe Northern Europe SLEEP AUDIO SURROUND TEST – SUBWOOFER + SURROUND MODE EFFECT – CENTER +...
Page 2
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL 1. This design of this product contains special hardware and many circuits and components specially for safety purposes. For continued protection, no changes should be made to the original design unless authorized in writing by the manufacturer.
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Disassembly method Top cover Removing the top cover (See Fig.1) Remove the four screws A attaching the top cover on both sides of the body. Remove the three screws B on the back of the body.
Page 4
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Removing each board connected to the rear side of the audio board (See Fig.5 to 8) Prior to performing the following procedure, remove Audio the top cover and the rear panel. board Cut off the tie band fixing the harness.
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Removing the audio board CN385 Relay board (See Fig.9) Prior to performing the following procedure, remove the top cover and the rear panel. power supply board Disconnect the card wire from connector CN402 on CN473 the audio board.
Page 6
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Removing the power transformer (See Fig.13) Prior to performing the following procedures, remove the top cover. Power Power Unsolder the two harnesses connected to the power transformer supply board board transformer. FW201...
Page 7
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Removing the system control board / Operation switch panel Front panel assembly power switch board (See Fig.16 to 18) Prior to performing the following procedure, remove the top cover and the front panel assembly.
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Adjustment method Tuner section 1.Tuner range 87.5MHz~108.0MHz AM (MW) 522kHz~1629kHz (LW) 144kHz~ 288kHz Power amplifier section Adjustment of idling current Measurement location TP301(Lch) , TP302(Rch) Adjustment part VR301(Lch) , VR302(Rch) Attention This adjustment does not obtain a correct adjustment value immediately after the amplifier is used (state that an internal temperature has risen).
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Description of major ICs SAA6588 (IC191) : RDS detector 2.Pin Function 1.Terminal Layout Symbol Function Multi-path rectifier output Non connect Test control input pin SCOUT Oscillator output OSCO OSCO Vref Oscillator input...
Page 10
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL AK4527B (IC601) : A/D,D/A converter 1.Pin layout DZF2/OVF SDOS RIN+ RIN- SMUTE LIN+ BICK AK4527BVQ LIN- LRCK ROUT1 SDTI1 LOUT1 SDTI2 Top View ROUT2 SDTI3 LOUT2 SDTO ROUT3 DAUX LOUT3 2. Pin function (1/2)
Page 11
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Pin function (2/2) AK4527(1/2) No Connect Pin name Function No internal bonding. Analog Input Format Select Pin ADIF "H" : Full-differential input, "L" : Single-ended input Chip Address 1 Pin Chip Address 0 Pin...
Page 12
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL TC9164AN (IC402) : Analog switch 1.Function Switch to On/Off of S1 to S8 by control of LSI. 2.Terminal Lay out & Block Diagram TC9164AN L-S1 R-S1 SHIFT SHIFT RESISTOR RESISTOR & &...
Page 13
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL W24L010AJ-12 (IC641) : CMOS SRAM Pin layout Block diagram CLK GEN. PRECHARGE CKT. CORE CELL ARRAY 7024 ROWS 728x8 COLUMN5 I/O8 I/O7 I/O1 I/O6 I/O2 I/O3 I/O5 I/O4 I/O 1 DATA I/O CKT COLUMN DECODER CNTRL.
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL M62446FP (IC428) : 6CH master volume 1.Block Diagram OUT4 DVDD OUT- OUT3 OUT2 PORT DATA volume OUT1 LATCH AVDD DGND volume SWIN AGND GNDS SWout SRin SRout volume SLin SLout GNDC Cout...
Page 15
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL 2.Pin Function Pin No. Symbol Descriptions SURROUND SURROUND control terminal BASS BOOST BASS BOOST control terminal INPUT-ATT Input attenuator control terminal MUTING MUTING control terminal AVDD Analog positive power supply terminal SWIN SUB Woofer volume signal input terminal A.GND...
Page 16
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL MN101C35DHK1 (IC701) : System controller Pin function (1/2) Symbol Function Pin No. TXD/SB00/P00 VOL.JOG IN_1 RXD/SBI0/P01 VOL.JOG IN_2 SBT0/P02 DATA (PLL) SB01/P03 (PLL) SBI1/P04 (PLL) SBT1/P05 VIDEO S/C DVD BUZZER/P06 VIDEO S/C VCR...
Page 17
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Pin function (2/2) Symbol Function Pin No. (DSP) SBT2/P32 READY (DSP) RESET (DSP) RELAY S RELAY C RELAY L/R 1 RELAY L/R 2 DGT17/P67 RELAY HEADPHONE DGT16/P66 FL GRID SIGNAL CONTROL OUT...
Page 18
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL TC9446F-014 (IC631) : Digital signal processor for dolby digital (AC-3) / MPEG2 audio decode Pin No. Symbol Function Reset signal input terminal (L:reset H:Operation usually) MIMD Microcomputer interface mode selection input terminal (L:serial H:IC bus)
Page 19
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL UPD784215AGC103 (IC671) : UNIT CPU 1.Pin layout 2.Pin function Pin No. Symbol Function Non connect Power supply terminal Connecting the crystal oscillator for system main clock Connecting the crystal oscillator for system main clock...
Page 20
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL VICTOR COMPANY OF JAPAN, LIMITED AUDIO & COMMUNICATION BUSINESS DIVISION PERSONAL & MOBILE NETWORK BUSINESS UNIT. 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan Printed in Japan (No.20932) 200104(V)
Page 21
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL ock diagram IC191 SELECTOR AM/FM DET TUNER VCR P.B. IC501 RF101 IC102 VCR REC WOOFER MW RF&OSC IC121 MONITOR T111 CN451 TUNER COMPU PLL CLK, PLL DATA, PLLCE, LINK CN501 CN431 CN411...
Page 22
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL d schematic diagrams pply section PW311 PW101 CN251 F202 CN201 T2AL RY_HP RY_LR2 F203 RY_LR1 RY_C T2AL RY_S PW302 PROTECTOR_IN PW102 R201 POWER RY_SURROUND FW201 FW201 F201 PW203 PW103 T2.5AL F205 PW204...
Page 23
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL dio & Speaker terminal section Sheet 1/8 CN351 0.1/160 C1301 C1302 D1301 D1302 D1303 D1304 C1303 FW485 0.01/500 R1321 Q1308 (LVA10211-1) CN385 C1305 2SC2235/OY/ C1304 QQLZ005-R45 6800/63 6800/63 L1351 Sheet 4/8 CN321...
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL PARTS LIST [ RX-6010RBK ] [ RX-6012RSL ] * All printed circuit boards and its assemblies are not available as service parts. Area suffix B ------------------------------- U.K. E ----------- Continental Europe EN ------------ Northern Europe...
Page 36
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL < M E M O >...
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Exploded view of general assembly and parts list Block No. Power trans board Power trans board Speaker board Power/Fuse board Relay board Main board Audio board Power supply board power switch board...
Page 38
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Parts list (General assembly) Block No. M1MM Parts list (General assembly) Block No. M1MM Item Parts number Parts name Q'ty Description Area Item Parts number Parts name Q'ty Description Area LV10457-009A FRONT PANEL...
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Block No. 01 Electrical parts list (Power amp board) Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area C 201 QFLC2AJ-104Z M CAPACITOR .10MF 5% 100V C 812...
Page 40
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Block No. 01 Electrical parts list (Power amp board) Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area D 220 1SR139-400-T4 DIODE Q 311 KTC3200/GL/-T TRANSISTOR D 221...
Page 41
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Electrical parts list Block No. 01 (Power amp board) Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area R 315 QRJ146J-271X UNF C RESISTOR 270 5% 1/4W...
Page 42
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Block No. 01 Electrical parts list (Power amp board) Item Remarks Parts number Parts name Area R 929 QRE141J-471Y C RESISTOR 470 5% 1/4W R 931 QRJ146J-100X UNF C RESISTOR 10 5% 1/4W...
Page 43
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Block No. 02 Electrical parts list (Main board) Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area C 419 QCBB1HK-223Y C CAPACITOR .022MF 10% 50V C1373 QFLC1HJ-223Z M CAPACITOR .022MF 5% 50V...
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Block No. 02 Electrical parts list (Main board) Item Remarks Parts number Parts name Area R 440 QRE141J-102Y C RESISTOR 1.0K 5% 1/4W R 441 QRE141J-104Y C RESISTOR 100K 5% 1/4W R 442...
Page 45
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Block No. 03 Electrical parts list (System control & Audio board) Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area BK701 LV42093-001A FL HOLDER(L) C1428 QFLC1HJ-153Z M CAPACITOR .015MF 5% 50V...
Page 46
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Block No. 03 Electrical parts list (System control & Audio board) Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area Q 709 DTC114YKA-X D TRANSISTOR R 712...
Page 47
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Block No. 03 Electrical parts list (System control & Audio board) Item Remarks Item Parts number Parts name Remarks Area Parts number Parts name Area R 789 NRSA63J-221X MG RESISTOR R1474 NRSA63J-102X...
Page 48
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL (DSP board) Block No. 04 Electrical parts list Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area C 601 NCB31HK-102X C CAPACITOR C2514 NCB31HK-122X C CAPACITOR C 602...
Page 49
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL (DSP board) Block No. 04 Electrical parts list Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area IC683 RN5RZ33BA-X R 681 NRSA63J-103X MG RESISTOR IC690 BA15218F-XE R 682...
Page 50
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Block No. 04 Electrical parts list (DSP board) Item Remarks Parts number Parts name Area R2568 NRSA63J-103X MG RESISTOR R2575 NRSA63J-102X MG RESISTOR R2576 NRSA63J-102X MG RESISTOR R2577 NRSA63J-104X MG RESISTOR R2578...
Page 51
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL (Tuner board) Block No. 05 Electrical parts list Item Remarks Item Remarks Parts number Parts name Area Parts number Parts name Area AT101 QNB0014-001 ANT TERMINAL Q 102 2SC535/BC/-T TRANSISTOR BK 1...
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Packing materials and accessories parts list Block No. Block No. Ver.E/EN A2~A8 Ver.B A2~A8 3-18...
All manuals and user guides at all-guides.com RX-6010RBK/RX-6012RSL Parts list (Packing) Block No. M2MM Item Parts number Parts name Q'ty Description Area QPA02503505P POLY BAG FOR INST LV20983-006A PACKING CASE RX-6012RSL LV20983-005A PACKING CASE RX-6012RSL LV20983-003A PACKING CASE RX-6010RBK LV20925-001A...