All manuals and user guides at all-guides.com COLOR TELEVISION RECEIVER Chassis : KS3A(P) (REV. 2) Model : CS29A5HT8X/BWT CS29A5HT8X/NWT CS29A5HT8X/VWT CZ21A8VW8X/ELS RTV servis Horvat Tel: ++385-31-856-637 Tel/fax: ++385-31-856-139 Mob: 098-788-319 www.rtv-horvat-dj.hr COLOR TELEVISION RECEIVER CONTENTS Precautions Reference Information Specifications Alignment and Adjustments...
Heed the high voltage limits. These include not exceed 0.5 milliamp. Reverse the power- the X–ray Protection Specifications Label, and plug prongs in the AC outlet and repeat the the Product Safety and X-ray Warning Note on test. the service data schematic. www.rtv-horvat-dj.hr Samsung Electronics...
Page 3
14. Components, parts and wiring that appear to have overheated or that are otherwise damaged should be replaced with parts that meet the original specifications. Always determine the cause of damage or overheating, and correct any potential hazards. www.rtv-horvat-dj.hr Samsung Electronics...
Make sure that the portion around 8. Always connect a test instrument’s ground the serviced part has not been damaged. lead to the instrument chassis ground before connecting the positive lead; always remove the instrument’s ground lead last. www.rtv-horvat-dj.hr Samsung Electronics...
Page 5
4. Do not use freon-propelled chemicals. These unpackaged replacement ESDs. Motions such can generate electrical charges that damage as brushing clothes together, or lifting a foot ESDs. from a carpeted floor can generate enough static electricity to damage an ESD. www.rtv-horvat-dj.hr Samsung Electronics...
Hour Millisecond Inches Per Second Millivolt Kilowatt-hour Nanofarad Ω Kilogram Kilohertz Picofarad kΩ Kilohm Pound Kilometer Revolutions Per Minute km/h Kilometer Per Hour Revolutions Per Second Kilovolt Second (Time) Kilovolt-ampere Volt Kilowatt Volt-ampere Liter Watt Megahertz Watt-hour www.rtv-horvat-dj.hr Samsung Electronics...
Page 7
Fail Safe Voltage Controlled Oscillator Ground VCXO Voltage Controlled Crystal Oscillator Green-Y Very High Frequency High Video Intermediate Frequency High-Frequency Variable Resistor HI-FI High Fidelity Video Tape Recorder Inductance-Capacitance VTVM Vacuum Tube Voltmeter Integrated Circuit Transistor Intermediate Frequency www.rtv-horvat-dj.hr Samsung Electronics...
Page 8
KA78RM33 IC903 3.3V Regulator KIA7025AP IC904 MICOM Reset IC Q909 2N7000 IIC Level Shifter Q910 Refer to Table 2-3-4 TU01S TCLS3101PD09A9(S) Main Tuner with IF Block Refer to Table 2-3-5 TU02S TCPN3081PD09A(S) Sub Tuner with IF Block www.rtv-horvat-dj.hr Samsung Electronics...
Page 10
Table 2-3-4 1’st TUNER (TU01S) FUNCTION REMARK SPEC TCLS3101PD09A(S) CS with LNA Function Main TCPS3001PD09D(S) TCPS3001PD09E(S) India Note TCPS3001PD09A(S) is out-of-date, TCPS3001PD09D(S) which is up-to-date has the same function. Table 2-3-5 2’nd TUNER (TU02S) FUNCTION REMARK SPEC TCPS3000PC09B(S) www.rtv-horvat-dj.hr Samsung Electronics...
Page 11
All manuals and user guides at all-guides.com Reference Information Table 2-3-6 TRANS REMARK SPEC FUNCTION FUJ-29B001 29” 21” FUH-29A001B Table 2-3-7 TRANS FLYBACK (FBT) REMARK SPEC FUNCTION AA26-00046A 29” 21” AA26-00044C www.rtv-horvat-dj.hr Samsung Electronics...
2. Turn on the TV. Set the Brightness and Contrast controls to minimum (zero beam current). 3. Adjust the Brightness and contrast controls to both extremes. Ensure that the high voltage does not exceed 32 KV under any conditions. www.rtv-horvat-dj.hr Samsung Electronics...
Page 14
3. Select “G2-Adjust”. 4. Set the values as below. 29 Inch 21 Inch IBRM = 220 IBRM = 220 WDRV = 35 WDRV = 35 = 220 = 165 COLR G B = 150 150 150 = 70 www.rtv-horvat-dj.hr Samsung Electronics...
Page 15
For example, when the value of “Red Cutoff” is 127, change the value to 128 and restore the value to 127. If you do not follow this procedure, the picture may be abnormal. For example, when the TV set is on, the picture becames brighter gradually. www.rtv-horvat-dj.hr Samsung Electronics...
Page 16
7. Adjust CA-100 so that the final adjustment value can be fixed. 8. Use the Channel Up/Down ( / ) buttons to move the cursor on the adjustment modes. 9. Use the Volume +/- buttons to change the adjustment value. www.rtv-horvat-dj.hr Samsung Electronics...
Page 17
PROM (sometimes MICOM) is replaced, the adjustment values should be controlled. - After the Service adjustment is completed, Do not select “Reset” in the service mode menu. (After above procedure is done, power is on initially and the “Plug and Play” will be operated.) www.rtv-horvat-dj.hr Samsung Electronics...
Page 18
Adjust PIP Vertical Position (Main Picture is PAL) 0 ~ 255 Adjust PIP Vertical Position (Main Picture is NTSC) PIP NTSC V Pos 0 ~ 255 Adjust PIP Horizontal Position PIP H Pos 0 ~ 15 Adjust PIP Green Cutoff Level PIP BLKLG www.rtv-horvat-dj.hr Samsung Electronics...
Page 19
All manuals and user guides at all-guides.com Alignment and Adjustments 4-8-2(B) SCREEN CHANGE (I2C BUS GEOMETRIC ADJUSTMENT) V Shift V Amp V Slope V SC H Trapizium H EW H Symmetry H Parabola H Corner 10 H Shift www.rtv-horvat-dj.hr Samsung Electronics...
Page 20
Refer to Table 1 Beam Control Limit Characteristic Note 3. beam 1.8mA 1.6mA BCL GAIN BCL THESHOLD WDRGB Table 1. YC Delay Adjustment Table SECAM NTSC Delay Def. Def. Def. Value The “Def.” means that TV is in AV mode. www.rtv-horvat-dj.hr Samsung Electronics...
Page 21
Slope 1 [0...15] “Soft Limit” is that Limitting Soft Limit Slope B the peak white without range=256...511 feed-back, but “Peak Limit” is that with feed-back for white Slope 2 [0...15] peak level tilt 1 [0...511] tilt 2 [0...511] 1023 www.rtv-horvat-dj.hr Samsung Electronics...
Page 22
Off, On set to “On” Initial Value : Refer to Note 6 on the next page. Note 5. Sound IC601 MSP3400D, MSP3410D A2/NICAM V-DOLBY MSP3411G Mono Not used this mode for KS3A Chassis L-Stereo www.rtv-horvat-dj.hr 4-10 Samsung Electronics...
Page 23
Adjust Horizontal Parabola in 16:9 Mode -30 ~ 30 H 16:9 Parabola Adjust Horizontal OSD/TTX Position TTX H Shift -30 ~ 30 BG/DK/I/M Mono Sound System V Slice Level 0 ~ 3 Adjust Melody Volumn Melody Volumn 0 ~ 20 www.rtv-horvat-dj.hr Samsung Electronics 4-11...
Page 24
OSD-G OSD-R Scart1 Ident VDD 2.5V Scart2 Ident Key 1 X-TAL Out H-Sync X-TAL In V-Sync MICOM Reset Key 3 N.C. Key 2 N.C. X-Ray Protect VDD 3.3V IR Input Stand-By LED N.C. Time LED Relay www.rtv-horvat-dj.hr 4-12 Samsung Electronics...
Page 26
VDD 3.3V PX.Y When The Caption Function Adopted, Used. PX.Y N.C. Not Used (Programmed Gound Level) N.C. Sound Amp Mute S-Mute High Picture On/Off Control Power Not Used (Programmed Gound Level) N.C. Tilt Tilt Control Output www.rtv-horvat-dj.hr 4-14 Samsung Electronics...
Page 27
All manuals and user guides at all-guides.com Plug in Power Cord Check LED lamp Check Abnormal Check Normal IC901 MICOM MICOM IIC #5, #6 Input Voltage Normal Abnormal Check and Replace the MICOM Check Level Shifter Q909, Q910 Check Check Normal Normal Abnormal...
Page 28
All manuals and user guides at all-guides.com No Picture, but sound is in normal operation Turn the VR of FBT, higher screen voltage and Check the Deflection Normal Abnormal is in Normal Operation (If the deflection is in operation, flyback signal is appeared) Check Normal Abnormal...
Sound is mute) Normal Check D816, Q906 Check Abnormal IC601 #24, #25 Normal Replace IC602 Check Abnormal IC601 Input Voltages (5V,8V) Normal Check the coils around IC601 Check Abnormal IC601 Input Signal Normal Check Replace the Tuner IC601 www.rtv-horvat-dj.hr Samsung Electronics...
10-1 MAIN 1 TP07 TP01 TP10 TP08 TP02 TP09 TP03 TP09 TP01 TP06 TP10 TP04 TP03 TP05 TP08 TP05 TP04 TP02 TP06 TP07 : Power Line : Signal Line RTV servis Horvat Tel: ++385-31-856-637 Samsung Electronics 10-1 Tel/fax: ++385-31-856-139 Mob: 098-788-319 www.rtv-horvat-dj.hr...
Page 48
All manuals and user guides at all-guides.com Schematic Diagrams 10-2 MAIN 2 TP11 TP12 TP13 TP12 TP13 TP14 TP11 TP25 TP15 TP14 TP25 : Power Line : Signal Line TP15 10-2 Samsung Electronics...
Page 49
Schematic Diagrams 10-3 MAIN3 TP22 TP16 TP23 TP23 TP17 TP24 TP18 TP17 TP16 TP22 TP18 TP19 TP21 TP20 TP24 TP19 TP20 TP21 RTV servis Horvat : Power Line Tel: ++385-31-856-637 : Signal Line Tel/fax: ++385-31-856-139 Mob: 098-788-319 www.rtv-horvat-dj.hr Samsung Electronics 10-3...
Page 50
All manuals and user guides at all-guides.com Schematic Diagrams 10-4 MAIN 4 TP32 TP26 TP33 TP27 TP26 TP33 TP35 TP34 TP28 TP27 TP35 TP29 TP34 TP28 TP32 TP31 TP30 TP29 TP31 TP30 : Power Line : Signal Line 10-4 Samsung Electronics...
Page 51
All manuals and user guides at all-guides.com Schematic Diagrams 10-5 PIP : Power Line Samsung Electronics 10-5...
Page 52
All manuals and user guides at all-guides.com Schematic Diagrams 10-6 CRT, SIDE AV, VIDEO SWITCH SIDE AV VIDEO SWITCH : Power Line : Signal Line 10-6 Samsung Electronics...
Page 53
All manuals and user guides at all-guides.com Schematic Diagrams 10-7 DOUBLE FOCUS, CONTROL DOUBLE FOCUS CONTROL RTV servis Horvat Tel: ++385-31-856-637 Tel/fax: ++385-31-856-139 : Power Line Mob: 098-788-319 www.rtv-horvat-dj.hr Samsung Electronics 10-7...