ICs inside the unit. 2. To protect the pickup unit from electrostatic dis- charge during serviving, take an appropriate treat- L 13942296513 ment(shorting-solder) by referring to "the DISAS- SEMBLY" on page 51. u163 DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 3
By following the instructions in this manual, be sure to apply the prescribed grease or glue to proper portions by the appropriate amount.For replacement parts or tools, the prescribed ones should be used. L 13942296513 u163 DEH-P660/XN/UC http://www.xiaoyu163.com...
• Screw adjacent to mark on the product are used for disassembly. • For the applying amount of lobricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.) 2.1 PACKING L 13942296513 u163 DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 9
Carton See Contrast table(2) Inner Box XHW7001 Contain Box See Contrast table(2) Protector CHP2663 (2) CONTRAST TABLE DEH-P660/XN/UC and DEH-P6600/XN/UC are constructed the same except for the following: Mark Description DEH-P660/XN/UC DEH-P6600/XN/UC L 13942296513 Remote Control Assy Not used CXC3173...
Page 11
XNM7041 Panel CNS7245 Screw See Contrast table(2) CNV6486 Holder See Contrast table(2) Lighting Conductor CNV6487 u163 Transistor(Q651,911,921) 2SD 2396 CD Mechanism Module(S10) CXK5602 Choke Coil(L301) CTH1280 Screw ISS26P055FTC Cable XDE7003 Tuner Amp Unit See Contrast table(2) Screw ASZ26P060FTC DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 12
(2) CONTRAST TABLE DEH-P660/XN/UC and DEH-P6600/XN/UC are constructed the same except for the following: 3 7 63 1515 0 Mark Description DEH-P660/XN/UC DEH-P6600/XN/UC Panel CNS6935 XNS7070 Remote Control Assy CZX3257 Not used Cover CZN7655 Not used Tuner Amp Unit...
Practical value 0.01uF 12k ohms 101/10 100uF/10V 10k ohms The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 19
> SUB WOOFER R ch SUB WOOFER L ch 600µH L 13942296513 SYSTEM CONTROLLER CEK1208 > DETACH SENSE SW SYS+B REG. FM:+30.6dBs AM:+20.1dBs VDD REG. IP-BUS:+35.3dBs CD:+36.46dBs B.UP SENSE ILM SENSE ACC SENSE TEL MUTE u163 DC/DC CONVERTER DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 20
3 7 63 1515 0 L 13942296513 u163 FM(100%):-19.5dBs FM/AM TUNER UNIT AM(30%):-30.0dBs DEH-P660/XN/UC http://www.xiaoyu163.com...
3.3 KEYBOARD UNIT 3 7 63 1515 0 REMOTE CONTROL 3.3V REG. SENSOR VOLUME S-818A33AUC-BGN PAUSE L 13942296513 u163 DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 25
L 13942296513 20K(B) For resistors and capacitors in the circuit diagrams, their resistance values or capacitance values are expressed in codes: Ex. *Resistors Code Practical value u163 12k ohms 10k ohms *Capacitors Code Practical value 0.01uF 101/10 100uF/10V DEH-P660/XN/UC http://www.xiaoyu163.com...
For further information for WIRED REMOTE respective destinations, be sure to check with the schematic dia- gram. 2.Viewpoint of PCB diagrams IP-BUS Capacitor Connector SIDE A SIDE B Chip Part P.C.Board L 13942296513 u163 DETACH SENSE SW DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 31
3 7 63 1515 0 CORD ASSY SIDE A ANTENNA L 13942296513 u163 CN1950 CN701 FRONT DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 32
3 7 63 1515 0 TUNER AMP UNIT L 13942296513 u163 DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 33
3 7 63 1515 0 SIDE B L 13942296513 u163 DEH-P660/XN/UC http://www.xiaoyu163.com...
4.4 CD CORE UNIT(S10) 3 7 63 1515 0 CD CORE UNIT(S10) SIDE A LOADING /CARRIAGE MOTOR SPINDLE MOTOR L 13942296513 CN651 HOME u163 DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 37
3 7 63 1515 0 CD CORE UNIT(S10) SIDE B 12EJ DSCSNS CLAMP L 13942296513 u163 DEH-P660/XN/UC http://www.xiaoyu163.com...
Part No. D 301 Diode S5688G D 302 Diode S5688G D 303 Diode S5688G D 304 Diode S5688G Unit Number:XWM7049(DEH-P660) D 401 Diode S5688G Unit Number:XWM7050(DEH-P6600) Unit Name:Tuner Amp Unit D 402 Diode S5688G D 403 Diode S5688G D 651...
Page 39
Circuit Symbol and No. Part No. Circuit Symbol and No. Part No. 3 7 63 1515 0 RESISTORS R 601 (DEH-P660) RS1/16S104J R 602 (DEH-P6600) RS1/16S104J R 101 RS1/16S101J R 606 RS1/16S104J R 102 RS1/16S620J R 607 RS1/16S822J R 103...
Page 40
CKSRYB473K25 C 211 CEJQ4R7M35 C 851 CEJQ470M16 C 212 CEJQ4R7M35 C 853 4.7µF CCG1111 C 213 CEJQ4R7M35 C 855 CEJQ100M25 C 214 CEJQ4R7M35 C 856 CCSRCH331J50 C 215 CEJQ4R7M35 C 857 CEJQ330M25 C 216 CEJQ4R7M35 C 858 CKSRYB104K16 DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 41
C 931 CEJQ1R0M50 R 1902 RS1/16S222J C 932 CKSRYB104K16 R 1903 RS1/16S473J R 1905 RS1/16S680J R 1906 RS1/16S680J Unit Number:XWM7055(DEH-P660) R 1907 RS1/16S680J Unit Number:XWM7056(DEH-P6600) R 1908 RS1/16S680J R 1909 RS1/16S181J Unit Name:Keyboard Unit R 1910 RS1/16S151J R 1911 RS1/16S103J...
Page 42
R 1970 RS1/16S101J R 505 RS1/16S102J R 1971 RS1/16S101J R 506 RS1/16S221J R 1972 RS1/16S0R0J R 507 RS1/16S221J u163 CAPACITORS R 508 RS1/16S221J R 509 RS1/16S221J R 601 RS1/16S101J C 1970 CKSRYB104K16 R 602 RS1/16S101J R 603 RS1/16S0R0J DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 43
C 304 CKSRYB472K50 C 305 CKSRYB103K25 C 306 CKSRYB104K16 C 501 CKSRYB103K25 C 502 CKSRYB103K25 C 702 100µF/16V CCH1504 C 703 CKSRYB104K16 C 705 10µF/6.3V CCH1470 Miscellaneous Parts List Pickup Unit(P10)(Service) CXX1641 Motor Unit(SPINDLE) CXB6007 Motor Unit(LOADING/CARRIAGE)CXB8933 u163 DEH-P660/XN/UC http://www.xiaoyu163.com...
Digital Multi-Meter L 13942296513 <When the OEL Unit has been replaced> u163 1. Use VR1970 to adjust the resistance between TP1 and TP3 to 11.4kΩ. 2. Use VR1971 to adjust the resistance between TP2 and TP3 to 5.8kΩ. DEH-P660/XN/UC http://www.xiaoyu163.com...
• The load and eject operation is not guarantied with the mechanism upside down. If the mechanism is blocked due to mistaken eject operation, reset the product or turn off and on the ACC to restore it. u163 DEH-P660/XN/UC http://www.xiaoyu163.com...
Because of eccentricity in the disc and a slight misalignment of the clamping center the grating waveform may be seen to "wobble" ( the phase difference changes as the disc rotates). The angle specified above indicates the average angle. • Hint u163 Reloading the disc changes the clamp position and may decrease the "wobble". DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 48
3 7 63 1515 0 Ech → Xch 20mV/div, AC Grating waveform Fch → Ych 20mV/div, AC 0° 30° 45° 60° L 13942296513 75° 90° u163 DEH-P660/XN/UC http://www.xiaoyu163.com...
Remarks: Mechanical errors are not displayed (because a CD is turned off in these errors). Unreadable TOC does not constitute an error. An intended operation continues in this case. Upper digits of an error code are subdivided as shown below: 1x: Setup relevant errors, 3x: Search relevant errors, Ax: Other errors. u163 DEH-P660/XN/UC http://www.xiaoyu163.com...
The frequency of the clock signal is 312.5kHz that is one 32th of the fundamental frequency. The clock signal should be 312.5kHz. If the clock signal is out of the range, the X'tal (X601) should be replaced with new one. L 13942296513 u163 DEH-P660/XN/UC http://www.xiaoyu163.com...
Fig.1 Grille Assy Removing the Tuner Amp Unit (Fig.2) Remove the screw. Remove the three screws. Straighten the tabs at three locations indicated. Remove the screw and then remove the Tuner Amp Unit. u163 Tuner Amp Unit Fig.2 DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 52
L 13942296513 Caution: Before installing the carriage mechanism in the frames, be sure to apply some alcohol to the dampers and set the mechanism to the clamp mode. Carriage Mechanism Damper Lower Frame Damper Damper u163 DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 53
Caution: In assembling, move the planet gear to the load/eject position before setting the feed screw in the inner holder. Washer Pickup Lock Arm Change Arm Styling Holder L 13942296513 Feed Screw Inner Holder Planet Gear u163 DEH-P660/XN/UC http://www.xiaoyu163.com...
7.1.2 CONNECTOR FUNCTION DESCRIPTION 3 7 63 1515 0 L 13942296513 u163 DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 55
Back up sense input Not used ROMDATA ROM correction : Data input/output u163 EVOL : Strobe output EVOL : Data output EVOL : Clock output IPPW IPBUS : Driver power supply control output ASENBO IPBUS : Slave ACC sense output DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 56
TUNER : Data output(PLL) TUNPCK TUNER : Clock output(PLL) * PD5923A IC's marked by * are MOS type. Be careful in handling them because they are very liable to be damaged by electrostatic induction. L 13942296513 * S-80835CNUA-B8U u163 DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 57
OPEN 71-86 D15-0 Data bus 15-0 ks!-^ 87-92 key strobe flstby FLASH memory stand-by signal AVSS GND connection fl!@on Not used OPEN VREF GND connection AVCC VCC connection flbusy FLASH memory busy signal OPEN u163 FWRST GND connection DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 58
3 7 63 1515 0 * PD5932A Format Meaning CMOS Nch open drain HA12240FP BUS+ BUS- BIAS DRIVER L 13942296513 OUTPUT RECEIVER OUTPUT u163 DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 60
Output of focus drive PWM Output of tracking drive PWM Output of tracking drive PWM Output of thread drive PWM Output of thread drive PWM u163 Output of spindle drive PWM Output of spindle drive PWM DGND Ground for digital circuits DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 61
Connected to the capacitor for output of REFOUT Reversal input of FE Output of FE ADCIN TEST L 13942296513 Reversal input of TE Output of TE AGND Ground for the analog system PWMSW Servo PWM mode switching * UPD63712AGC u163 DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 62
Output pin for preamplifier for thread OPINLSL Input pin for preamplifier for thread OPOUT3 CH3 preamplifier output pin OPIN3(-) Input pin for inverting input for CH3 preamplifier OPIN3(+) Input pin for non-inverting input for CH3 preamplifier PREVCC PreVcc L 13942296513 BA5835FP u163 DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 63
Ground of audio block 23 L ch O L channel output FM stereo “L-ch” signal output or AM audio output 24 R ch O R channel output FM stereo “R-ch” signal output or AM audio output u163 DEH-P660/XN/UC http://www.xiaoyu163.com...
In case of the above signal, the communication with Grille microcomputer may fail. Source keys If the time interval is not 300msec, the oscillator operative may be defective. Source ON SYSPW←H Pin 1 u163 Completes power-on operation. (After that, proceed to each source operation) DEH-P660/XN/UC http://www.xiaoyu163.com...
Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools: Portions to be cleaned Cleaning tools CD pickup lenses Cleaning liquid : GEM1004 Cleaning paper : GED-008 L 13942296513 u163 DEH-P660/XN/UC http://www.xiaoyu163.com...
Page 69
1. Attach the holders to both sides of the front panel. Holder CND1249 Holder CND1250 2. Replace the front panel to the unit. L 13942296513 3. Flip the holders into upright positions. 4. Fix the front panel to the unit using fixing screws. Fixing Screw BPZ20P060FZK u163 DEH-P660/XN/UC http://www.xiaoyu163.com...