Sealey AP890MHV Quick Start Manual

Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these
instructions, and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
Refer to
instructions
1. SAFETY
WARNING! Ensure Health & Safety, local authority, and general workshop practice regulations are adhered to when using this trolley.
‰
Always load evenly with the centre of gravity of the load as near centre of the trolley as possible.
9
DO NOT overload the trolley - see section 3.
8
Use the trolley in a suitable work area.
9
Keep the work area clean, uncluttered and ensure there is adequate lighting.
9
Keep the trolley clean and tidy in accordance with good workshop practice.
9
DO NOT use the trolley for any purpose other than that for which it is designed.
8
DO NOT stand on the trolley, use it as a ladder or allow others to ride on the trolley.
8
Use the wheel locks to prevent the trolley from inadvertently moving.
9
DO NOT leave unattended, especially when loaded, unless the wheels are locked, chocked or the trolley otherwise secured.
8
DO NOT use trolley on uneven ground and do not run over curbs or steps - use a ramp.
8
DO NOT use trolley if any part is significantly damaged, paying particular attention to the wheels.
8
Keep children and unauthorised persons away from the work area.
9
2. INTRODUCTION
Five drawer garage & workshop trolley. With an overall capacity of 320kg evenly distributed. The five drawers are lined with non-slip liners
and have ball-bearing slides as standard. Features rear locking mechanism which engages once the lockable top lid is closed, adding extra
security. There are extra hand tool storage slots situated on either side within the top compartment. Lined Lower shelf is ideal for larger
parts or tool storage. Fitted with a side handle, two fixed castors and two swivel castors with toe brakes to aid manoeuvrability around the
workshop or garage.
3. SPECIFICATION
Model No.: ..........................................................AP890M/HV
Capacity: ......................................................... Overall: 320kg
Top tray and Bottom Tray: ..................................... 80kg each
2 Small drawers: ...................................................20kg each
Other 3 drawers: ...................................................40kg each
Evenly distributed.
Drawer Size:
Small drawer (x2) (W x D x H): ................ 295 x 430 x 55mm
Small deep drawer (x1): ......................... 300 x 430 x 120mm
Medium drawer (x1): ................................624 x 430 x 70mm
Large drawer (x1): ..................................624 x 430 x 120mm
Overall Size: .........................................940 x 515 x 1050mm
Shelf Size (W x D):
Top compartment: ..................................660 x 480 x 120mm
Bottom Tray: ............................................770 x 490 x 90mm
© Jack Sealey Limited
HEAVY-DUTY MOBILE TOOL & PARTS
TROLLEY WITH 5 DRAWERS AND LOCKABLE
TOP
AP890M & AP890MHV
MODELS:
Original Language Version AP890M/HV Issue 2 (3) 11/08/22