Sealey SA93 Instructions

Thank you for purchasing a Sealey product . Manufactured to a high standard, this product will, if used according to these
instructions, and properly maintained, give you years of trouble free performance .
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY . NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS . USE THE
PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED . FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY . KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE .
1 . SAFETY
Refer to
Wear eye
instruction manual
protection
Familiarise yourself with the application and limitations of the air hose reel, as well as the specific hazards.

WARNING! Disconnect the air hose reel from the air supply before servicing or performing any maintenance.

Maintain the air hose reel in good condition (use an authorised service agent).

Replace or repair damaged parts. Use recommended parts only. Unauthorised parts may be dangerous and will invalidate the

warranty.
Locate and fix the air hose reel in a suitable working area, ensure that the correct fixings are used to secure the unit to the wall.

DO NOT position the hose in direct sun light, or in areas of extreme heat or cold.

DO NOT mount inside spray booth/oven.

Ensure that there is adequate lighting.

WARNING! Ensure maximum air pressure is not exceeded.

WARNING! DO NOT over extend the hose as this will cause the mechanism to malfunction, preventing the hose from retracting.

Keep extended air hose away from heat, oil and sharp edges.

Check hose for wear before each use and ensure all connections are secure.

Keep the unwound air hose away from wet, damp, oily surfaces.

WARNING! Always wear approved eye protection when operating the air hose reel.

Maintain correct balance and footing. Ensure the floor is not slippery and wear non-slip shoes.

Remove ill fitting clothing. Remove ties, watches, rings, other loose jewellery and contain and/or tie back long hair.

Keep children and unauthorised persons away from the working area.

DO NOT operate the air hose reel if any parts are damaged or missing as this may cause failure and/or personal injury.

DO NOT use the air hose reel for any purpose other than that for which it is designed.

DO NOT operate the air hose reel when you are tired or under the influence of alcohol, drugs or intoxicating medication.

DO NOT direct air from the air hose at yourself or others.

When not in use, ensure the air supply is turned off and tools disconnected. Disconnect from the air supply and retract the hose into

case.
WARNING! DO NOT dismantle the hose reel casing. To do so may result in damage to the appliance and/or personal injury and will

invalidate the warranty. Internal maintenance, which will require the opening of the casing, must only be undertaken by an authorised
service agent.
2 . INTRODUCTION
Tough, durable design suitable for the professional workshops. Features a solid brass internal spindle for added strength and durability. Auto
rewind mechanism with self layering system provides tangle free operation. Positive latching at every full revolution of inner drum for hose length
control. Fitted with reinforced PVC braided hose. Supplied with heavy-duty swivel mounted wall bracket and 2mtr inlet hose.
3 . SPECIFICATION
Model No: . . . . . . . . . . . . . . . . . . SA93 . . . . . . . . . . . . . . . . . . . . SA94
Hose Length: . . . . . . . . . . . . . . . . 20mtr . . . . . . . . . . . . . . . . . . . . 15mtr
Hose Size (ID/OD):. . . . . . . . . 10/16mm . . . . . . . . . . . . . . 12.5/18.5mm
Maximum Pressure: . . . . . . . . . . 300psi . . . . . . . . . . . . . . . . . . . .300psi
Hose Type: . . . Reinforced Braded PVC . . . . . Reinforced Braided PVC
Inlet/Outlet: . . . . . . . . . . . . . . .3/8"BSPT . . . . . . . . . . . . . . . . . 1/2"BSPT
© Jack Sealey Limited
INSTRUCTIONS FOR:
RETRACTABLE AIR HOSE REEL
15MTR/20MTR
SA93/SA94
MODEL NO'S:
Original Language Version
SA93, SA94 Issue: 1 - 22/10/14